en
2.4
Transport
2.5
Installing/dismantling
118
DANGER
When dismantled, the permanent magnet rotor inside the pump can pose
mortal danger for people with medical implants (e.g. pacemakers).
• Follow the general behavioural guidelines that apply to handling elec-
trical devices!
• Do not open the motor!
• Dismantling and installation of the rotor may only be carried out by
Wilo customer service! If you have been fitted with a pacemaker, you
must not carry out this kind of work!
NOTICE
The magnets inside the motor do not pose a danger provided the motor
is completely assembled. Persons with pacemakers can approach the
pump without restrictions.
•
Wear protective equipment:
safety gloves for protection against cuts
–
safety shoes
–
sealed safety goggles
–
safety helmet (when using lifting equipment)
–
•
Only use legally specified and approved lifting gear.
•
Select the lifting gear based on the prevailing conditions
(weather, attachment point, load etc.).
•
Always attach the lifting gear to the designated attachment
points (lifting eyes).
•
Position the lifting equipment in a way that ensures stability
during use.
•
When using lifting equipment, a second person must be
present to coordinate the procedure if required (e.g. if the op-
erator's field of vision is blocked).
•
Persons must not stand underneath suspended loads. Do not
move loads over workplaces where people are present.
•
Wear protective equipment:
Safety shoes
–
Safety gloves for protection against cuts
–
Safety helmet (when using lifting equipment)
–
•
Locally applicable laws and regulations on work safety and ac-
cident prevention must be complied with.
•
The procedure described in the installation and operating in-
structions for shutting down the product/unit must be strictly
observed.
•
Disconnect the device from the mains and secure it against be-
ing switched on again without authorisation.
•
All rotating parts must be at a standstill.
•
Close the gate valve in the inlet and in the pressure pipe.
•
Provide adequate aeration in enclosed spaces.
Installation and operating instructions • Wilo-Yonos GIGA2.0-I/-D • Ed.01/2023-03