Recommended Lubricants/Oil Mist Lubricator; Cleaning And Servicing; Spare And Wearing Parts - Bosch WBE 4510 Originalbetriebsanleitung

en 60 | WBE 4510 | Maintenance
14. Maintenance
14.1 Recommended lubricants/oil mist
lubricator
Component Lubricant
Compressed air system ESSO FEBIS K 32
Tab. 2: Lubricant table
!
The manufacturer cannot accept any liability for da-
mage arising from the use of other lubricants.
14.2

Cleaning and servicing

!
Before cleaning and servicing, switch off WBE 4510
and disconnect mains plug.
!
Do not use any solvent-based cleaning agents. Use
alcohol or similar cleaning agents for plastic parts.
The following work is essential to ensure proper opera-
tion and high performance of the WBE 4510:
14.2.1 Service intervals
Servicing
Clean moving mechanical parts, treat with spray oil
or kerosene and lubricate with engine oil or
a suitable grease.
Remove condensate.
Check the oil level in the oil mist lubricator.
Replace the oil in the oil mist lubricator.
Tab. 3: Service intervals
14.2.2 Removing condensate
1. Turn the red knob at the bottom of the water separa-
tor counter-clockwise.
2. Remove the accumulated condensate.
3. Turn back the red knob at the bottom of the water
separator.
|
1 695 655 163 2010-07-17
14.2.3
1. Remove the compressed air connection.
2. Screw the container to the oil mist lubricator.
3. Top up with oil.
Standard
ISO 32
14.2.4
1. Remove the compressed air connection.
2. Screw the container to the oil mist lubricator.
3. Drain off and dispose of the oil.
4. Fill with fresh oil.
14.3
The manufacturer cannot accept any liability for
damage arising from the use of non-genuine replace-
ment parts.
x
Designation
x
Standard centering flange
x
Quick-action clamping nut
x
Centering cone 42 - 64,5 mm
Centering cone 54 - 79,5 mm
Centering cone 74 - 111,5 mm
Weight pliers
Manual vernier caliper
Test clip
Calibration weight
Calibration weight (calibrated)
Voltage sticker
Direction of wheel rotation sticker
Tab. 4:
Topping up oil in oil mist lubricator
Replacing oil in oil mist lubricator

Spare and wearing parts

Spare and wearing parts
Order number
1 695 602 400
1 695 616 200
1 695 632 500
1 695 652 862
1 695 605 600
1 695 606 500
1 695 629 400
1 695 602 700
1 695 654 377
1 695 654 376
1 695 100 789
1 695 653 878
Robert Bosch GmbH