Inhaltsverzeichnis
Werbung
Sicherheitsaufklebersatz ANSI-Norm
NOTICE
Jump starting with
welding equipment will
result in damage to the
electrial system.
Hinweis zum Überbrückungsstart (1827)
INTERVAL
REF
IDENTIFICATION
HOURS
PTS
1
ENGINE
2
TRANSMISSION
3
HYDRAULIC TANK
4
RADIATOR EXPANSION TANK
10
DAILY
6
FUEL FILTER / WATER SEPARATOR
7
ENGINE AIR CLEANER
18
DRIVE BELTS
1
ENGINE CRANKCASE BREATHER
3
HYD. FILTER RESTRICTION GAUGE
24
TYRES
9
OSCILLATION BUSHES
12
SUSPENSION BEAM BUSHINGS
10
STEERING CYLINDER PINS
50
11
BODY CYLINDER PINS
WEEKLY
13
BODY HINGE /TAILGATE PINS
15
WHEEL RIM NUTS
30
CAB FRESH AIR FILTER
14
PANHARD ROD BEARINGS
BATTERY ELECTROLITE
8
19
WHEEL PLANETARIES
20
DIFFERENTIALS
250
21
OSCILLATION PIVOT
MONTHLY
25
ARTICULATION BEARINGS
27
PARKING BRAKE PADS
18
DRIVE BELTS
35
FRONT AXLE (IFS)
1
ENGINE
500
16
ENGINE OIL FILTER
3 MONTH
2
TRANSMISSION
2
TRANSMISSION
3
HYDRAULIC TANK BREATHER
6
FUEL FILTER / WATER SEPARATOR
1000
17
DCA4 COOLANT FILTER
6 MONTH
2
TRANSMISSION BREATHER
28
TRANSMISSION OIL FILTERS
29
TRANSMISSION INTERNAL
STRAINER
22
DRIVESHAFT BEARINGS
30
CAB FRESH AIR FILTER
32
FUEL TANK
3
HYDRAULIC TANK
19
BRAKE PACKS
19
WHEEL PLANETARIES
20
DIFFERENTIALS
2000
25
ARTICULATION PIVOT NUT
ANNUALLY
31
HYDRAULIC OIL FILTER
3
HYDRAULIC TANK STRAINER
23
DRIVELINES
1
ENGINE MOUNTING BOLTS
2
TRANSMISSION MOUNTING BOLTS
1
TURBOCHARGER MOUNTING
BOLTS
1
ENGINE WATER PUMP
34
AXLE MOUNTING BOLTS
5
COOLING SYSTEM
4000
33
AIR CON. COMPRESSOR
NOTES ON LUBRICATION AND SERVICE CHART
NOTE 1
- CAPACITIES GIVEN ARE APPROXIMATE - WORK TO DIPSTICK, SIGHT GAUGES OR LEVEL PLUGS.
NOTE 2
- CAPACITY OF FRONT AND REAR DIFFERENTIALS 21 LTR (5.5 US GAL)
CAPACITY OF CENTRE DIFFERENTIAL IS 23 LTR (6 US GAL)
NOTE 3
- LUBRICATE SLOWLY UNTIL EXCESS LUBE IS SEEN.
NOTE 4
- REMOVE PLUG FROM PORT ON UNDERSIDE OF OSCILLATION HUB. PLUG IS REMOVED TO DRAIN THE CAVITY OF ANY OIL THAT
ENTERS THE CAVITY WHEN FILLING. REMOVE THE COVER PLATE AND LEVEL PLUG ON SIDE OF OSCILLATION HUB. ADD OIL
IF REQUIRED. REFIT ALL PLUGS.
EO
- ENGINE OIL. REFER TO "RECOMMENDED LUBRICANTS".
HO
- HYDRUALIC OIL. REFER TO "RECOMMENDED LURICANTS".
EPL
- EXTREME PRESSUREGEAR LUBRICANT. REFER TO "RECOMENDED LUBRICANTS".
EP,NLGI - EXTREME PRESSURE LITHIUM No. 2 GREASE (WITHOUT "MOLY").
PAG OIL - POLYALKLENE GLYCOL (PAG) COMPRESSOR LUBRICATING OIL - LOW VISCOSITY (ISO46)
Jump start using
identical battery
pack.
15333282
LUBRICATION AND SERVICE CHART
NO.
LUBRICANT
SERVICE INSTRUCTIONS
PTS
OR COOLER
CHECK OIL LEVEL. ADD OIL IF LOW
1
EO
CHECK OIL LEVEL. ADD OIL IF LOW
1
EO
CHECK OIL LEVEL. ADD OIL IF LOW
1
HO
CHECK COOLANT LEVEL. ADD IF LOW
1
ETHYLENE
GLYCOL
DRAIN
1
-
CHECK. RENEW ELEMENT IF REQ'D
1
-
VISUAL INSPECTION FOR DAMAGE
2
-
INSPECT. CLEAN IF REQUIRED
1
-
CHECK. RENEW ELEMENT IF REQ'D
1
-
CHECK CONDITION & PRESSURE
6
-
LUBE
2
EP, NLGI
LUBE
2
EP, NLGI
LUBE
4
EP, NLGI
LUBE
4
EP, NLGI
LUBE
2
EP, NLGI
CHECK TORQUE
72
-
INSPECT & CLEAN IF REQUIRED
1
-
LUBE
4
EP, NLGI
CHECK LEVEL. ADD ELECTRO IF LOW
2
-
CHECK OIL LEVEL. ADD IF LOW
6
EPL
CHECK OIL LEVEL. ADD IF LOW
3
EPL
CHECK END FLOAT. ADJUST IF REQ'D
1
-
LUBE
2
EP, NLGI
CHECK WEAR. RENEW IF REQ'D
2
-
CHECK TENSION. TIGHTEN IF REQ'D
2
-
LUBE
1
EP,NLGI
DRAIN OIL & REFILL WITH NEW OIL
1
EO
RENEW
1
-
DRAIN OIL & REFILL WITH NEW OIL
1
EO
RUN AEB STARTER
1
-
RENEW
1
-
RENEW
1
-
RENEW
1
-
CLEAN IF REQUIRED
1
-
RENEW
2
-
CLEAN
1
-
CHECK OIL LEVEL. ADD IF LOW
1
EPL
RENEW
1
-
RENEW CAP FILTER / CATRIDGE
1
-
DRAIN OIL & REFILL WITH NEW OIL
1
HO
CHECK BRAKE WEAR
6
-
DRAIN OIL & REFILL WITH NEW OIL
6
EPL
DRAIN OIL & REFILL WITH NEW OIL
3
EPL
CHEK TORQUE
1
-
RENEW
1
-
CLEAN
1
-
CHECK FOR LEAKS & DAMAGE
5
-
CHECK TORQUE
4
-
CHECK TORQUE
3
-
CHECK TORQUE
4
-
1
-
INSPECT DRAIN HOLE.
CLEAN IF REQUIRED
CHECK TORQUE
24
-
DRAIN, FLUSH & REFILL WITH NEW
-
-
COOLANT
DRAIN, FLUSH & REFILL WITH NEW
1
PAG OIL
REFRIGERANT OIL
TA25/27/30 Wartungs- und Schmiertabelle (2191)
NOTICE
AIR
N
Use nitrogen only
to inflate tyres.
15333283
Hinweis zu Reifen mit
Stickstoffüllung (1828)
SERVICE QUANTITIES
AS REQUIRED
AS REQUIRED
17
AS REQUIRED
33
8
REF. ENGINE MANUAL
6
SEC 160-0050
16
7
SEE NOTE 3
SEE NOTE 3
SEE NOTE 3
SEE NOTE 3
SEE NOTE 3
600 Nm / 442 lbf ft
SEE NOTE 3
AS REQUIRED
29
2
AS REQUIRED
AS REQUIRED
28
-
SEE NOTE 3
35
-
-
10
SEE NOTE 3
-
11
-
9
-
-
REF. SERVICE MANUAL
21
-
-
-
-
-
19
SEE NOTE 4
-
-
23
12
-
15
REF. SERVICE MANUAL
-
SEE NOTE 2
1425 Nm / 1050 lbf ft
-
-
-
298 Nm / 220 lbf ft
26
920 Nm / 679 lbf ft
65 Nm / 50 lbf ft
-
34
671 Nm / 495 lbf ft
-
-
Sicherheit
NOTICE
Power down truck
when not in use
or damage may
occur.
15333284
Nachricht zum Ausschaltung der
Stromversorgung (1829)
5
18
1
32
4
30
3
31
25
22
27
20
13
24
14
15347627
2-27
Werbung
Inhaltsverzeichnis
