Manufacturer's Information; Delivery; Packaging; Transport - Gemü SUPM SUMONDO Betriebsanleitung

8 Manufacturer's information

8 Manufacturer's information

8.1 Delivery

1. Check that all parts are present and check for any dam-
age immediately upon receipt.
The product's performance is tested at the factory. The
scope of delivery is apparent from the dispatch documents
and the design from the order number.

8.2 Packaging

The product is packed in a cardboard box which can be re-
cycled as paper.

8.3 Transport

1. Only transport the product by suitable means. Do not
drop. Handle carefully.
2. After the installation dispose of transport packing mater-
ial according to relevant local or national disposal regula-
tions / environmental protection laws.

8.4 Storage

1. Store the product free from dust and moisture in its ori-
ginal packaging.
2. Avoid UV rays and direct sunlight.
3. Do not exceed the maximum storage temperature (see
chapter "Technical data").
4. Do not store solvents, chemicals, acids, fuels or similar
fluids in the same room as GEMÜ products and their
spare parts.
GEMÜ SUPM

9 Installation in piping

9.1 Preparing for installation

The equipment is subject to pressure!
▶ Risk of severe injury or death.
Depressurize the plant.
●
Completely drain the plant.
●
The actuator cover is under spring pres-
sure!
▶ Risk of severe injury or death!
●
Corrosive chemicals
▶ Risk of caustic burns
●
●
Sharp edges on the mounting plate!
▶ Risk of cuts!
●
Use as step.
▶ Damage to the product.
▶ Risk of slipping-off.
Choose the installation location so that the product can-
●
not be used as a foothold.
Do not use the product as a step or a foothold.
●
Exceeding the maximum permissible pressure.
▶ Damage to the GEMÜ product.
Provide precautionary measures against exceeding the
●
maximum permitted pressures caused by pressure
surges (water hammer).
Leakage
▶ Emission of dangerous materials.
●
Only apply pressure to the single-use dia-
phragm valve body when it is assembled
to the pneumatic stainless steel actuator!
▶ Otherwise the single-use diaphragm
40 / 56
WARNING
WARNING
Do not open the actuator.
WARNING
Wear suitable protective gear.
Completely drain the plant.
CAUTION
Wear protective gloves.
CAUTION
CAUTION
CAUTION
Provide precautionary measures
against exceeding the maximum per-
mitted pressures caused by pressure
surges (water hammer).
CAUTION
valve body may be damaged.
www.gemu-group.com