Maintenance Recommendations - Husqvarna SM 610 2006 Werkstatt-Handbuch

I.20
SOSPENSIONE ANTERIORE
BOZZA-DRAFT
FRONT SUSPENSION
SUAPENSION AVANT
VORDERGABEL
SUSPENSIÓN DELANTERA
MAINTENANCE

Maintenance recommendations

This fork is the result of years of experience made on the most important racing
tracks. Even though it is a high technology product, no particular maintenance
is needed. Since it is designed for a sporting use, maintenance is very easy to
perform and needs no special tools.
Routine maintenance
1- Dust seal cleaning:After every race
CROSS, ENDURO
2- Oil change:
CROSS
ENDURO
3- Oil seal change:
CROSS
ENDURO
4- Air bleeding:
CROSS, ENDURO
Note: On muddy or sandy terrain forks should be checked after shorter periods
of time (-30%) than those shown in the above table.
Note: reference numbers in this chapter refer to the parts belonging to the fork
exploded view on page I.16.
1- Dust seal cleaning (FIG. 5)
NOTE
There is no need to disassemble the fork legs to clean the dust seal.
No special tools are required.
Use silicone grease spray.
PROCEDURE
Before cleaning the dust seal, clean the stanchion tubes
Remove the dust seal (12) from the slider (7). Do not score the stanchion tube
(5- 6).
Lower the dust seal down the stanchion and clean the inner side of the dust
seal and its seat in the slider with compressed air.
Never use metal tools to remove the dirt. Pump the slider slightly up and down
and remove any possible dirt from the stanchions. Lubricate the dust seal and
the visible part of the oil seal.
Reposition the dust seal in the stanchion.
2- Oil change
NOTE
To change the oil, the fork legs must be disassembled.
Required tools: no. 2 19-mm Allen wrenches, scale or gauge.
Tightening torque for damper rod: 10 Nm.
Tightening torque for plug check nut: 30 Nm.
Tightening torque for slider plug: 25 Nm.
1.5 lt. of recommended oil.
Use
Competition
After every ride
After 6 hours
After 30 hours After 60 hours
After 30 hours After 60 hours
After 6 hours
After 30 hours After 60 hours
After every ride
Part. N. 8000 A4640 (04-2005)
Not competition
After 20 hours
After 20 hours
Every month