Tractel Tralift Gebrauchs- Und Wartungsanleitung Seite 11

Fig. 7a
Chain lubrication label (fig. 8) fastened on each
unit.
Fig.: 8
10.2. Optional marking
Label (fig. 9) fastened on each unit equipped
with load limiter option.
Fig.: 9
11. Do nots
Do not:
– Use the hoist if it has not been inspected for
more than one year.
– Use the hoist if the chains show any
deformation, wear or extensive corrosion.
– Use the hoist with any chain other than a
genuine TRACTEL chain.
– Use the hoist if the load chain is not correctly
positioned in the load sheave and in the pulley
block.
– Make any changes to the hoist.
– Use any parts or components other than
genuine TRACTEL parts and components.
– Use a hoist which is not in good condition.
– Use the hoist without first having performed
the checks described in this manual.
– Fasten the hoist to any anchor point which is
not sufficiently strong.
– Secure the hoist by any means other than its
suspension hook.
0
– Clamp the suspension hook.
– Attempt to lift fixed or blocked loads.
– Use a high pressure cleaner or chemical
products (acids, chlorinated products) to clean
the hoist except for the Tralift Duratech load
chain and lifting hook.
– Use the hoist at loads exceeding its working
load limit (WLL*).
– Use the hoist in an explosive environment
(device not compliant with ATEX directive) or
in a highly corrosive environment.
– Use the hoist at temperatures of less than -10
°C or greater than + 50 °C.
– Use the hoist to lift a load when the wind speed
is greater than 50 km/h.
– Use the hoist, even occasionally, to lift or move
persons.
– Use the hoist for operations other than those
for which it is intended or using setup diagrams
other than those described in this manual.
– Use the hoist under lighting conditions which
are not sufficient to clearly observe the load
along its entire path.
– Apply the load to the hook end.
– Pull the hand chain in the load lowering
direction when the load chain is abut against
the low limit stop.
– Pull the hand chain in the load lifting direction
when the lifting hook is against the hoist.
– Pull sideways on loads to be lifted.
– Use the Tralift or Tralift Duratech load chain as
a sling.
– Use the Tralift or Tralift Duratech hoist as a
sling.
– Raise or lower a load without having a clear
view of the entire path.
– Allow the load to swing under the hoist.
– Stand under or move around under the load.
– Allow the load or hand chains to rub against
an obstacle.
– Work on the hoist without first having removed
the load from the hoist.
– To alter the load limiter adjustment.
EN
11