CLIVET MSAN 81 Anleitung Zur Installation, Bedienung Und Wartung Seite 65

07 Manipulation and storage Technical measures/precautions.
Form of storage and manipulation applicable to the products:
PRESSURIZED GAS.
Ensure adequate ventilation and evacuation for the level of
equipment.
Advice for use: Prevent sparks and contact with hot surfaces.
DO NOT SMOKE.
Technical measures/Storage procedures: Store at room
temperature in the original container. Keep away from flames, hot
surfaces and sparks. Store in a cool, well-ventilated place.
Protect full containers from sources of heat to avoid excessive
pressures.
Recommended: Ordinary steel.
Avoid: Alloy containing more than 2% magnesium.
Plastics.
08 Control of individual Precautionary measures to be taken: Ensure a sufficient
exposure/protection exchange of air and/or suction in workplaces.
Control parameters.
Exposure limits: No limit value F-USA
Forane 134a recommended limit value by Elf : VME=1000ppm
Forane 32 recommended limit value by Elf : VME=1000ppm
Forane 125 recommended limit value by Elf : VME=1000ppm
Individual protective equipment:
Respiratory protection: In case of insufficient ventilation, carry
suitable breathing apparatus.
Protection for the hands: Gloves
Protection for the eyes: Protective eyewear
09 Physical and chemical Physical state (20°C): liquid gas
properties Colour: colourless
Smell: Slightly similar to ether; pH: not applicable.
Boiling point/interval: -42,4 °C
Flash point: No flare up at test conditions
Vapour pressure: (25°C): 1.13 Mpa (11,3 bar) a (50°C): 2.11
Mpa (21,1 bar) a (70°C): 3.26 Mpa (32,6 bar)
Vapour density: At boiling point 4,54 kg/m3
Density: (25°C) 1133 kg/m3 a (50°C) 1004 kg/m3 a (70°C) 861
kg/m3
10 Stability and reactivity Conditions to avoid: Avoid contact with flames and red-hot
metal surfaces.
Dangerous decomposition products: Thermal decomposition
into toxic and corrosive products: (hydrofluoric acid
Other Information: Stable product at normal storage and
handling conditions
11 Toxicological information Inhalation: In experiments on animals Forane 134a, 32, 125
practically non-toxic. No mortality noticed on rats at 500000
ppm/4h. As with other volatile aliphatic halogenated compounds,
with the accumulation of vapours and/or the inhalation of large
quantities, the product can cause: loss of consciousness and
heart problems aggravated by stress and lack of oxygen; risk of
death.
Contact with skin: Frostbite possible from splashes of liquefied
gas.
Chronic toxicity: Studies on animal protracted inhalation do not
highlight any sub-chronic toxic effect (rat/3 month(s)/ Inhalation:
50000ppm)
Specifical effects: Genotoxicity according experimental available
data Forane 134a, 32, 125 NOT Genotoxic
Cancerogenesis: Forane 134a: experiments on animals do not
highlight carcinogen effect clearly demonstrated (rat /Inhalation –
for oral administration)
Toxicity for reproduction: Foetal growth Forane 134a, 32, 125
according to available data no toxic effect for foetal development.
Fertility, according the limited data on animal: Forane 134a no
effects on fertility (rats/inhalation)
Technical measures/precautions.
Form of storage and manipulation applicable to the products:
PRESSURIZED GAS.
Ensure adequate ventilation and evacuation for the level of
equipment.
Advice for use: Prevent sparks and contact with hot surfaces.
DO NOT SMOKE.
Technical measures/Storage procedures: Store at room
temperature in the original container. Keep away from flames, hot
surfaces and sparks. Store in a cool, well-ventilated place.
Protect full containers from sources of heat to avoid excessive
pressures.
Recommended: Ordinary steel.
Avoid: Alloy containing more than 2% magnesium.
Plastics.
Precautionary measures to be taken: Ensure a sufficient
exchange of air and/or suction in workplaces.
Control parameters.
Exposure limits:
France 1989: VME = 1000
USA 1992: TWA = 1000 p.p.m. = 3500 mg/m3
Individual protective equipment:
Respiratory protection: In case of insufficient ventilation, carry
suitable breathing apparatus.
Protection for the hands: Gloves
Protection for the eyes: Protective eyewear.
Specific hygiene measures: avoid contact with the skin, eyes and
inhalation of the vapours.
Physical state (20°C): liquid gas
Colour: colourless
Smell: Slightly similar to ether; pH: not applicable.
Boiling point/interval: -40.8 °C
Melting point/interval: -160 °C
Decomposition temperature: 480 °C
Vapour pressure: (20 °C) 0.91 Mpa (9.1 bar); at 50 °C: 1.91
Mpa (19.4 bar)
Vapour density: (20° C) 3.57 kg/m3
Solubility: water (25 °C) 3g/l - solvent soluble in hydrocarbons
and chlorinated solvents, alcohols, ketones, esters.
Solubility of water in the product at 30° C: 0.15% in weight.
Conditions to avoid: Avoid contact with flames and red-hot
metal surfaces.
Dangerous decomposition products: Thermal decomposition
) into toxic and corrosive products: hydrofluoric acid, hydrochloric
acid in gaseous form, phosgene, carbon monoxide (CO)
Inhalation: Practically non-toxic in experiments conducted on
animals. No effect below 50,000 p.p.m.
As with other volatile aliphatic halogenated compounds, with the
accumulation of vapours and/or the inhalation of large quantities,
the product can cause: loss of consciousness and heart problems
aggravated by stress and lack of oxygen; risk of death.
Contact with skin: Frostbite possible from splashes of liquefied
gas.
Contact with the eyes: Temporary irritation.
65