Suction Grid And Vent Cleaning; Scheduled Maintenance Table; Period Of Inactivity - Mase Generators MPF 16 Brauchsanweisung Und Wartungsvorschriften

MPF 16-22
GB
The batteries develop a highly explosive gas. It is
recommended not to smoke nor cause sparks in the
vicinity, in particular during charging.
Wear protective goggles. When dismantling the battery,
disconnect the negative cable (-) first.
When remounting it, connect the positive cable (+) first.
6.8 S
UCTION GRID AND VENT CLEANING
Always check cleanliness of the air suction grids and vents
(Ref. 1,2,3,4).
These must be free of elements which obstruct regular
cooling air flow (leaves, paper, cloths, etc.).
1
3
6.9 S
CHEDULED MAINTENANCE TABLE
The check indicated in this section can be carried out either
by the workshop or by machine user.
Check oil level sump
Check water level in radiator (1)
Check air cleaner for clogging (1)
Check radiator/intercooler for restriction (1)
Check electrolyte level in batteries (1) (2)
The routine maintenance operations, must be carried out by
qualified personnel who have the appropiate equipment and
protections.
ROUTINE MAINTENANCE
Change engine oil (2 - 4 - 5)
Change oil filters (2 - 4)
Change fuel filter (2)
Clean fuel pump filter (2)
Adjust drive belt tension (2)
Adjust valve clearance
Calibrate injectro and possible nozzles replacement
GB
- 26
2
4
2
CHECKS
(1) = The regularity of these operations can vary
depending on engine use and the ambient
conditions in which it operates.
(2) = These operations must be carried out annually even
when the specified operating hours have not been
reached.
(3) = Maximum period, with high-quality fuel; it may vary
depending on fuel .
(4) = Change after the first 50 hours of service (running-in)
(5) = If fuel with a sulphur content of more than 0.5% in
used, the engine oil change intervals must be halved
6.10 P
ERIOD OF INACTIVITY
If the generator is not to be used for a long period of time,
the following operations must be carried out.
• Completely empty out the fuel tank.
• Change the engine oil.
• Clean the air filter.
• Disconnect the battery cables. We recommend you
recharge the battery every month in order to prevent it
from going completely flat which, sometimes,
compromises its integrity.
• Clean the outside of the generator, removing all dust
and impurities.
• Cover the generator with a nylon sheet and store it in
horizontal position in a dry and ventilated place.
REGULARITY
daily
daily
daily
daily
300 hours
REGULARITY
300 hours
300 hours
300 hours (3)
300 hours (3)
300 hours
900 hours
900 hours