Scheppach DP3000 Originalbetriebsanleitung Seite 23

Safety instructions for handling
flammable supplies
1. WARNING!: Petrol is highly flammable:
2. Store fuel in containers specifically designed for this
purpose.
3. Refill the gasoline tank only outdoors and do not
smoke meanwhile.
4. Add fuel before starting the engine. Never remove
the cap of fuel tank or add petrol while the engine is
running or when the engine is hot.
5. If petrol is spilled, do not attempt to start the engine
but move the machine away from the area of spillage
and avoid creating any source of ignition until petrol
vapours have dissipated. Replace all fuel tank and
container caps securely.
Adding fuel
• Always switch off the engine before refuelling.
m Attention! Always open the fuel filler cap carefully to
decompose slowly the excess pressure.
• Whilst working with the machine high tempera-
tures can attain on the case. Allow the engine to
cool before refuelling.
m Attention! In case of insufficient cooling of the ma-
chine the fuel may ignite and lead to serious burns dur-
ing refueling.
• Make sure not to fill the tank with too much fuel. Imme-
diately remove the fuel and clean the machine when
spilling fuel.
• Always close the screw plug on the fuel tank in order
to avoid loosening which may occure by vibrations
when using the machine.
m DANGER
Never refuel the engine nearby open flames.
Additional safety instructions while hand-ling with
combustion engines
m DANGER
Combustion engines constitute a special danger dur-
ing operation and refuelling. Always read and note the
warnings. Failure to do so can lead to serious or even
deadly injuries.
1. No changes may be made to the device.
2. m Attention!
Danger of poisoning, Emissions, fuels and lubri-
cants are toxic. Emissions shall not be inhalated.
3. m Attention!
Risk of burns. Do not touch the exhaust system
or drive unit.
4. Never operate the machine in non ventilated rooms
or in a highly inflammable environment. If you in-
tend to operate the machine in rooms with good
ventilation, the exhaust gases must be chan-
nelled directly outdoors through an exhaust hose.
 www.scheppach.com  service@scheppach.com  +(49)-08223-4002-99  +(49)-08223-4002-58
m Attention! Toxic exhaust gases can escape
despite the exhaust hose. Due to the fire hazard,
never direct the exhaust hose towards inflammable
materials.
5. m Risk of explosion!
Never operate the machine in rooms with combus-
tible materials.
6. Secure the device against shifting and toppling dur-
ing transport.
7. Make sure that when you refuel the device no fuel
is spilt on the engine or exhaust pipe.
8. Repairs and adjustment work may only be carried
out by authorized trained personnel.
9.
Do not touch any mechanically driven or hot parts.
Do not remove the safety guards.
10. The values quoted in the technical data under sound
power level (LWA) and sound pressure level (LpA)
are emission values and not necessarily reliable
workplace values. As there is a correlation between
emission and immission levels, the values cannot
be taken to reliably determine the possible need for
additional precautions. Factors influencing the cur-
rent immission level of the user/operator include the
properties of the work area, other sound sources
etc., e.g. the number of machines and other neigh-
boring processes, and the time span over which the
user/operator is subjected to the noise. Also, the
permitted immission level can vary from country
to country. Nevertheless, this information makes it
possible for the user to be able to make a better as-
sessment of the dangers and risks involved.
11. Never put any items into the ventilation openings.
This applies even when the device is switched off.
Non-observance may lead to injury, or damage to
the device.
12. Keep the generator free of oil, dirt and other impu-
rities.
13. Ensure the sound absorber and air filter work prop-
erly. These parts serve as flame protection in case
of misfire.
14. Stop the engine:
- whenever you leave the machine
- before refueling
15. Always close the fuel valve when the machine is
not in operation.
16. Never use the choke lever to stop the engine.
23 I 108