Hazard Warnings; Residual Risks - Zipper Zi-Rd300 Betriebsanleitung


Danger of burns! During the operation flow of hot exhaust gases and engine parts such as
the muffler and engine become hot.

Let the machine cool down before storage.

After the operation, the machine must cool down. Otherwise there is an imminent risk of
burns

WARNING: Fuel is highly flammable!

Stop the engine before refuelling

Smoking and open flames are prohibited during refuelling.

Do not refuel when the engine and carburettor are still very hot

Refuel only outdoors or in a well ventilated area.

Avoid contact with skin and clothes (fire hazard).

Check after refuelling tank cap and check for leaks.

Spilled fuel is to wipe immediately.

Keep the fuel in suitable containers only

Make sure the fuel does not overflow. If the fuel overflows, the engine must not be started.
Remove any dirt from the appliance and prevent any attempt at ignition until fuel fumes
have evaporated.

Damaged fuel tank or other tank cap must be replaced immediately

After the operation the fuel cock must be closed (if available)

Work attentively, safety conscious and always be fully aware safe stand when working! Cau-
tion on uneven work surfaces and work surfaces with a slope!

Never operate the machine on slopes where the angle is over 15°!

Avoid use in wet grass. Risk of slipping!

Regular breaks reduce the security risk to loss of control due to fatigue.

Walk! Never run with the machine

Be especially careful when you turn the machine or move backwards!

Never use the machine on soft ground. Risk of tipping!

Take especially care, if the ground contains many stones or roots. An unattended stalling of
the drill might easily cause an accident

Use personal safety equipment: ear protectors, safety gloves in EN 388, class 3111, safety shoes
S1, safety goggles or face protection when working with the machine!

Never operate the machine without or with soft shoes!

Do not operate in an enclosed or confined areas.

Exhaust contains poisonous carbon monoxide. The exposure can cause unconsciousness and
death.

If the fuel tank has to be emptied it must be done outdoors. Keep the drained fuel in a spe-
cially designated container or dispose of carefully

Never leave the machine running unattended! Before leaving the working area switch the
machine off and wait until the machine stops.

Switch off the machine before maintenance or adjustment.

Never remove the fuel tank cap when the engine is running or hot

Switch of the engine and remove the ignition key (if is available):

Before check, clean or work on the machine

Before refueling

Always if you leave the machine
11.4

Hazard warnings

11.4.1

Residual risks

Despite intended use, certain residual risk factors remain.

Risk of noise:
Working for a long time can damage your hearing if you do not use a very good hearing pro-
tection.

Risks of working area:
Keep attention for stones and other things that can be thrown around by the machine.

Risk to the hands or fingers:
Risk of crushing: Operate the machine firmly with both hands. When tilting the dump box
keep extreme caution.
Risk of burns: Access while it is working in the mowing apparatus. After the operation, the
machine must cool down. Otherwise, there is an acute risk of scalding!

Risk of fire and explosion:
Fuel is highly flammable and explosive under certain conditions.
NEVER refuel fuel or engine oil while the machine is in operation or is hot.
When refueling and at places where fuel is stored not smoke or allow open flames or sparks.
Do not overfill the fuel tank and avoid the spillage of fuel during refueling. If fuel is spilled
make sure the area is completely dry and cleaned before starting the engine.
Make sure that the filler cap is tightly closed again after refueling safely.

Chemical risks:
Never use or refuel a gasoline or diesel engine in a closed area without adequate ventilation.
Carbon monoxide emissions from the internal drive units of the engine can cause in confined
spaces through inhalation health effects and death. Therefore use the machine only in well-
ventilated rooms or outdoors in operation.
ZIPPER MASCHINEN GmbH www.Zipper-Maschinen.at
SAFETY
28
ZI-RD300