Single Safety Inspection Before Commissioning - Nussbaum ATT TOP LIFT 2.35 TS Betriebsanleitung

9.1

Single safety inspection before commissioning

i Copy, complete and leave in the inspection book Serial number: _________________________________
Test step
Condition model plate .....................................
Condition short operating manual .................
Condition, load bearing capacity sticker ......
Function button "lift / lower" .............................
Condition drive-on rails/flat carrier fixture ..........
Condition, function lifting arm .........................
Condition, function lifting arm block and
Toothed washer.................................................
Condition, function rubber plate ....................
Condition, function drive-on ramps and rollers ...
Condition of polymer overlays ........................
Condition/ function pusher plates ..................
General lift condition ........................................
Condition, function cable riser ........................
Leak-tightness integrated pan ........................
Condition of paint / (galvanizing) ...................
Condition, function operating element .........
Load bearing constr. (deformations, cracks)
Condition of the lifting post pipe ....................
Fastening screw torque ...................................
Condition of weld seams .................................
Cover conditions ...............................................
Hydraulic system leak-tightness .......................
Condition integrated pan ................................
Leak-tightness integrated pan ........................
Condition of concrete floor .............................
Hydraulic oil filling level .....................................
Condition of hydraulic lines and screw fittings .......
Condition electrical lines ..................................
Functional test lift with vehicle.........................
Condition, function lighting .............................
Function limit button/CE-Stop, warning signal
Condition, function foot bumper ....................
*) place a checkmark in the relevant, if a retest is required then check it again!
Safety inspection done on:
Performed by company:
Name, address of specialist:
Result of inspection:
______________________________
Signature of specialist
If requested to take care of deficiencies
Deficiency removed on:
(use a new form for reinspection!)
OPI_TOP LIFT 2.35 TS TSK TSA - HYMAX INGROUND 2.35 R B P_V1.1_DE-EN-FR-ES-IT
OK Defect
missing
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................. ................
□ □
................ ................
□ □
................. ................
_________________________________________________________________
_________________________________________________________________
_________________________________________________________________
□
Continued operation questionable, reinspection required
□
Continued operation possible, remove defects by ______________
□
No deficiencies, continue to operate
______________________________
Operating company signature
______________________________
Retest Remarks
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
□
_______________________________
______________________________
Operating company signature
83