Camp Safety TEMPORARY LIFELINE Bedienungsanleitung Seite 19

recommended after each use in a marine environment. If the defect persists after lubrication, the connection
must be retired from service.
Summary
CAMP "Express Ring" ref.1040xx is a temporary anchoring device certified in accordance with standard EN 795:2012
Type B and standard EN 566:2017.
Use
The characteristics of the sling are indicated on table D. For installation, see fig.10. Avoid installation on surfaces with
sharp edges or abrasive surfaces.
Anchoring of the system must be preferably located above the user's position and must have resistance in conformity
with standard EN 795 (fig.8).
REVISION
In addition to the normal inspection required before, during and after each use, this product must be inspected by a
skilled person every 12 months, starting from date the product is first used; this date and the subsequent checks must
be recorded on the product's life sheet: keep this literature for inspection and reference for the life of the device. Check
the legibility of the product's markings.
In case of one of the following defects are present, the product should be withdrawn from service immediately or the
component (ref.0981E, ref.1040xx) must be replaced:
• presence of cutting and/or burning on the sling
• presence of cutting and/or burning on the seams
• deep corrosion that seriously alters the surface state of the metal (which does not disappear after a light rubbing with
emery paper)
• presence of cracks in the metallic parts
• permanent deformation of the ratchet
• malfunction of the ratchet mechanism
• play or exit of the rivet from the gate of the carabiner
• incorrect placement of the gate on the carabiner body
• play or exit of the rotation axis of the gate of the carabiner
• general wear and tear of the body which causes a significant reduction of the body section, which is deeper than 1mm
We recommend that the anchoring device be marked with the date of the last inspection or the next one.
Any product or component showing any defect or wear, or if in doubt, should be withdrawn from service immediately.
Each product in the safety system can be damaged during a fall and must be always inspected before use it again. Do
not continue to use a product after a major fall because a damage may have occurred, even no external signs are
visible.
LIFETIME
Temporary Lifeline ref.1095-109501 + Express Ring ref.1040xx [11]: The lifetime of the product is 10 years from the
date the product is first used and (taking storage into consideration) in any case cannot exceed the end of the twelfth
year from manufacturing (i.e. manufacture year 2018, lifetime until end of 2030, or 10 year from the date of first use,
whichever comes first).
Carabiner ref.0981E [10]: The lifetime of the product is unlimited.
Temporary Lifeline ref.1095-109501 + Express Ring ref.1040xx [11] + Carabiner ref.0981E [10]: The lifetime is
understood to be in the absence of causes which would place the product out of order with the condition that periodic
inspections are carried out at least once every 12 months starting from the date the product is first used and the results
"EXPRESS RING" item 1040XX SPECIFIC INFORMATION
17