Seite 3 Volume 1 “Chassis & Body” of this paired Service Mitsubishi Motors Corporation reserves the right to make changes Manual. in design or to make additions to or improvements in its products without...
Seite 4 G E N E R A L Name Name Fusible link Dedicated fuse No. 1 to No. 7 Dedicated fuse No. 8 and No. 9 Multi-purpose fuse Dedicated fuse No. 10 00002606...
Seite 5 GENERAL - Inspection Terminal Location Name Symbol Name Symbol Data link connector <From 1994 models> Fuel pump check connector Data link connector <Up to 1993 models> Ignition timing adjustment connector Engine speed detection connector '0257 connector TSB Revision...
Seite 6 GENERAL - Groundina Location Xl 9FO134 NOTE Same ground numbers are used in the circuit diagram. q Z - i’...
Seite 7 GENERAL - Grounding Location crossmember I \\ 1 TSB Revision...
Seite 8 GENERAL - Relay Location Name Symbol Name Symbol Auto-cruise control relay Motor relay (ABS hydraulic unit) Blower motor relay Pop-up motor relay*3 Blower motor relay (Hl)*5 Power window relay Condenser fan motor relay (HI) Radiator fan motor control relay*3 Radiator fan motor relay (HI) Condenser fan motor relay (LO) Radiator fan motor relay (LO) Defogger relay...
Seite 9 GENERAL - Relay Location starter relay TSB Revision...
Seite 10 GENERAL - Relay Location control relay Rear intermittent TSB Revision...
Seite 11: Sensor Location
GENERAL - Sensor Location Name Symbol Name Symbol ABS front speed sensor ABS rear speed sensor Knock sensor Air inlet sensor (for A/C) Left bank heated oxygen sensor Air therm0 sensor (for A/C) Manifold differential pressure sensor*4 Automatic transaxle oil temperature sensor M Photo sensor Camshaft posit!on sensor and crankshaft N Power steering pressure switch...
Seite 12 GENERAL - Sensor Location 00002701 Volume air flow sensor...
Seite 13 GENERAL - Sensor Location and from 1966 models Revolution pick-up sens’or Throttle position sensor built-in closed (with built-in closed throttle position switch)
Seite 14 GENERAL - Sensor Location Vehicle speed sensor Steering wheel angle speed sensor TSB Revision...
Seite 15 GENERAL - Sensor Location Interior temperature sensor...
Seite 16 GENERAL - Control Unit Location Symbol Name Symbol Name Engine control module ABS control unit ETACS control unit Active exhaust control module cup to 1994 models> Air conditioning compressor lock controller Light automatic shut-off unit Air conditioning control unit Motor antenna control unit SRS diagnosis unit Sunroof control unit 00004239...
Seite 17 GENERAL - Control Unit Location Electronic d&trbl control unit...
Seite 18 GENERAL - Solenoid, Solenoid Valve Location to 1995 models for California Revision...
Seite 19 GENERAL - Diode Location Name Symbol Name Symbol Diode (ABS circuit) <Up to models> 1995 Diode (Theft-alarm circuit) Diode (MFI circuit) Diode (4WS fluid level warning light circuit) Diode (Seat belt warning circuit) 00002703 Diode (ABS circuit) (MFI c?uit)
Seite 20 GENERAL - Junction Block HROOMOOAA Remarks (1) Alphabets assigned to the connectors are keyed to those assigned to connectors on P.19 (2) Terminals of the harness side connector are indicated in parentheses ( ). TSB Revision...
Seite 21 GENERAL wiring harness To roof wiring - harness instrument panel wiring harness To body wiring harness alarm horn relay 00002704 TSB Revision...
Seite 22 GENERAL FUSIBLE LINK (Relay box in engine compartment) Rated capacity Housing color Generator circuit Wine red Pop-up motor circuit (Up to 1993 models) Pink Lighting circuit Green Ignition switch circuit Pink Green Radiator fan motor and condenser fan motor circuit Junction block (Multipurpose fuse (l), (6), (14), (16), (17), (19)) Green ABS circuit...
Seite 23 GENERAL - Centralized Junction DEDICATED FUSE Rated capacity Power supply circuit Housing color Circuit Battery Yellow MFI circuit Tailliaht relav Horn circuit Fusible link (6) Fusible link (3) Fog light circuit Headlight relay Upper beam circuit Hazard light circuit Battery ABS circuit Yellow Sunroof circuit...
Seite 24: Multi-Purpose Fuse (In Junction Block)
GENERAL - Centralized Junction MULTI-PURPOSE FUSE (In junction block) Power supply circuit Rated capacity (A) Battery Ignition switch Battery Ignition switch IG2 ACC 9 Ignition switch Battery Battery Battery Ignition switch NOTE Multi-purpose fuse TSB Revision...
Seite 25 GENERAL CENTRALIZED RELAY Name Classification Name Classification Relay box in A-01X Headlight relay Air condition- A-31X Condenser fan motor relay engine ing relay box engine A-02X ABS power relay (vehicles compart- A-32X Radiator fan motor control ment produced up to Oct. 1993) relay (Up to 1993 models) ment Fog light relay...
Seite 26 GENERAL ess connector CONNECTOR CONTINUITY AND VOLTAGE TEST When checking continuity and/or voltage at the waterproof connectors, follow the steps below to avoid poor connector contact and/or reduced waterproof performance of connectors. (1) When checking is performed with the circuit in the state of continuity, be sure to use the special tool (harness connector).
Seite 27 GENERAL (2) Insert harness of terminal to be rectified deep into connec- tor from harness side and hold it there. (3) Insert tip of screwdriver [1.4 mm (.06 in.) width] into connec- tor in a manner as shown in the figure, raise housing Housing lance lance slightly with it and pull out harness.
Seite 28 GENERAL - Harness Connector Inspection RECTANGULAR WATERPROOF CONNECTOR (1) Disengage front holder by using a screwdriver and remove Front holder (2) Inset-t tip of screwdriver [*0.8 mm (.03 in.) width] into con- nector in a manner as shown in the figure, push it lightly to raise housing lance and pull out harness.
Seite 29: Troubleshooting Steps
GENERAL - How to Diagnose The most important point in troubleshooting is to determine “Probable Causes”. Once the probable causes are determined, parts to be checked can be limited to those associated with such probable causes. Therefore unnecessary checks can be eliminated. The determination of the probable causes must be based on a theory and be supported by facts and must not be based on intuition only.
Seite 30 GENERAL - to Diagnose INSPECTION 1. Visual and aural checks Check relay operation, blower motor rotation, light illumina- tion, etc. visually or aurally. The flow of current is invisible but can be checked by the operation of the parts. 2. Simple checks For example, if a headlight does not come on and a faulty fuse or poor grounding is suspected, replace the fuse with a new one or ground the light to the body by a jumper...
Seite 31 GENERAL 3. Jumper wire A jumper wire is used to close an open circuit. Never use one to connect a power supply directly to a load. 4. Voltmeter A voltmeter is used to measure the circuit voltage. Normally, the positive (red lead) probe is applied to the point of voltage measurement and the negative (black lead) probe to the body ground.
Seite 32 GENERAL 2. SWITCH CONNECTION This figure illustrates a complex switch. The continuity between terminals at each position is as indicated in the table below. 5 4 3 2 4th stage CHECKING RELAYS Cover 1. When current flows through the coil of a relay, its core Spring Coil is magnetized to attract the iron piece, closing (ON) the...
Seite 33: Cautions In Event Of Blown Fuse
GENERAL When a normal close type relay as illustrated here is Normal close (NC) type checked, there should be continuity between terminals Deenergized state Energized state (1) and (2) and between terminals 3 and 4 when the relay is deenergized, and the continuity should be lost between terminals 3 and 4 when the battery voltage is applied to the terminals 1 and 2.
Seite 34 GENERAL - How to Diaanose CHECKING CABLES AND WIRES 1. Check connections for looseness, rust and stains. 2. Check terminals and wires for corrosion by battery electro- lyte, etc. 3. Check terminals and wires for open circuit or impending open circuit. 4.
Seite 35: Voltage Check
GENERAL GENERAL ELECTRICAL SYSTEM CHECKS Power supply A circuit consists of the power supply, switch, relay, load ground, etc. There are various methods to check a circui; Fuse including an overall check, voltage check, short circuit check and continuity check. Each of these methods is briefly de- scribed in the following.
Seite 36: Continuity Check
GENERAL - How to Diagnose 2. SHORT-CIRCUITS CHECK A blown fuse indicates that a circuit is shorted. The circuit responsible can be determined by the following procedures. Remove the blown fuse and connect a test light in its place (Switch is in the OFF position) Test light comes on Turn on the switch (Test light comes on but the illumination light does not come on)
Seite 37 C O N T E N T S _ Instrument Panel and Floor Console ..54 Dash Panel ....... . 50 Interior..
Seite 38 CONFIGURATION DIAGRAMS Roof wiring Instrument panel wiring harness Door wiring* harness Front wiring Body wiring harness harness (LH) <CONVERTIBLE> Roof wiring Body wiring harness (RH) Instrument panel wiring harness Control wiring harness Door wiring* harness Front wiring 00002733 harness (LH) harness NOTE (1) This illustration shows only the major wiring harness.
Seite 39 CONFIGURATION DIAGRAMS The wiring harness diagrams clearly show the connector locations and harness routings at each site on actual vehicles. Denotes connector No. The same connector No. is used throughout the circuit dia- grams to facilitate connector location searches. The first al- phabetical symbol indicates the location site of the connector and a number that follows in the unique number.
Seite 40: Engine Compartment
CONFIGURATION DIAGRAMS Connector symbol A-14 A-15 A-16A:174-18 A-79 q-20 A:21 4-22 A-12 A-13 A-21 A-20 A-22 Generator relay Headlight relay A-02X IOD or Storage connector ABS power relay ABS front speed sensor (RH) A-03X Fog light relay A-12 A-13 ECS front shock absorber (RH) A-04X Radiator fan motor relay (LO) A-14...
Seite 41 CONFIGURATION DIAGRAMS - Engine Compartment A-26 A-27 A-23 A-24 A-25 A-l 9 Front washer motor A-27 Theft-alarm horn A-20 Evaporative emission purge solenoid A-26 Auto-cruise vacuum pump A-21 EGR solenoid (Vehicles for California) A-29 ABS front speed sensor (LH) A-22 EGR temperature sensor A-30 4WS fluid level sensor <Turbo>...
Seite 42 CONFIGURATION DIAGRAMS - Engine Compartment A-70 A-69 A - 6 7 + A-72 A-71 A-47 A-48 A-49 A-50 A-45 Condenser fan motor Dual pressure switch A-35 Condenser fan motor A-46 A-36 Air conditioning relay box Horn A-47 A-37 Air conditioning relay box A-48 Horn A-38...
Seite 43 CONFIGURATION DIAGRAMS - Engine Compartment A-73 A-42 A-46 A-45 A-44 A-56 Engine coolant level sensor A-66 Hood switch A-57 Active aero front venturi skirt A-67 Front wiring harness and control wiring harness A-58 Fog light (RH) combination Pop-up motor (RH) A-59 A-66 Diode (for ABS circuit)
Seite 44 CONFIGURATION DIAGRAMS - Engine Compartment A-12 A - 1 3 A-14A-15 A - 1 7 thru A-20 A-21 A-22 NOTE IOD or Storage connector Headlight relay A-12 ABS front speed sensor (RH) A-02X ABS power relay ECS front shock absorber (RH)* A-13 A-03X Fog light relay...
Seite 45 CONFIGURATION DIAGRAMS - Engine Compartment A-23 A-24 A-25 A-26 A-27 A-30 A-31X A-32X A-33X 00004253 A-20 Evaporative emission purge solenoid A-26 Theft-alarm horn A-21 EGR solenoid A-27 Theft-alarm horn A-28 Auto-cruise vacuum pump California and from 1996 models)> A-29 ABS front speed sensor (LH) A-22 EGR temperature sensor* A-30...
Seite 46 CONFIGURATION DIAGRAMS - Engine Compartment Connector symbol thru <Turbo> A 6g A-70 A-67 A-71 A-72 A-64 --+py> A-77 A-49 A-50 NOTE Horn A 47 Dual pressure switch A-35 Horn A 48 Air conditioning relay box A-36 Horn A 49 Air conditioning relay box A-37 Horn A 50...
Seite 47 CONFIGURATION DIAGRAMS ENGINE HOOD A-58 Fog light (RH) Resistor <Turbo> Headlight (LO, RH) Turbocharger waste gate solenoid <Turbo> Front combination light (RH) Fuel pressure solenoid <Turbo> Control wiring harness and solenoid valve ABS hydraulic unit harness combination ABS hydraulic unit Inspection light Hood switch Headlight (Hi, LH)
Seite 48 CONFIGURATION DIAGRAMS Connector symbol Front View B-12 B-06 B-07 B-08 B-02 ------+ B-01 B-30 \ 7 B-29 B-23 B-:4 B-25 <Turbo> B-25 NOTE Variable induction servo motor B-10 B-01 Engine coolant temperature gauge unit (with intake control valve position sensor) Engine coolant temperature sensor B-02 <Non-Turbo>...
Seite 49 CONFIGURATION DIAGRAMS Rear View B-32 B-33 B-23 Starter motor B-34 Speed sensor <Turbo> B-24 Starter motor B-35 Idle air control motor (stepper motor) B-25 Back-up light switch B-36 Oil pressure gauge unit B-28 Fuel pump relay <Turbo> B-37 Oil pressure switch B-29 Volume air flow sensor (with intake air B-38...
Seite 50 CONFIGURATION DIAGRAMS - Ennine and Transaxle <A/T> Front View B-06 B-07 B-06 * B-05 B-03 - B-02 B-01 - B-30 - B-20 B-29 B-24 NOTE 1994, 1995 models for California and from 1996 models (4) *4: From 1996 models B-10 Variable induction servo motor B-01 Engine coolant temperature gauge unit...
Seite 51 CONFIGURATION DIAGRAMS - Engine and Transaxle <A/T> Rear View B-35 Idle air control motor (stepper motor) B-22 Power transistor B-36 Oil pressure gauge unit B-23 Starter motor B-37 Oil pressure switch B-24 Starter motor Power steering pressure switch B-26 Inhibitor switch B-38 B-40 Camshaft position sensor*2...
Seite 52: Dash Panel
CONFIGURATION DIAGRAMS Connector symbol thru NOTE Accelerator pedal switch*’ c-13 Body wiring harness (LH) Control wiring harness and instrument panel c-14 and front wiring harness combination wiring harness combination Body wiring harness (LH) Body wiring harness (LH) and instrument panel and front wiring harness combination wiring harness combination Body wiring harness (LH)
Seite 53 CONFIGURATION DIAGRAMS C-32 c-33 c-34 Body wiring harness (LH) and body wiring Air conditioning control unit C-25 harness (RH) combination c-35 Foot light (RH) Air conditioning control unit*2 C-26 C-36 Body wiring harness (RH) and control wiring <Manual air conditioning> harness combination C-27 Air-inlet sensor <Full-auto air conditioning>...
Seite 54 CONFIGURATION DIAGRAMS JUNCTION BLOCK <Front side> C-68 C-69 Junction C-76 C-64 C-63 C-63 C-61 ( QC-58 C-57 C-60 Turbo> , C-80 NOTE models 1993 models 1994 models 1996 models c-59 Ignition switch ELC-4 AA control module C-46 Steering wheel angle speed sensor C-60 ELC-4 A/T control module c-47...
Seite 55 CONFIGURATION DIAGRAMS c-88’3 c-71 Adapter wiring harness and junction block C-83 Body wiring harness (LH) and junction block combination combination C-72 Theft-alarm horn relay C-84 Auto-cruise relay c-73 Blower motor relay C-85 Spare connector (Hand free microphone) c-74 Roof wiring harness and junction block C-86 Passenger’s air bag module*3 combination...
Seite 56 CONFIGURATION DIAGRAMS Connector symbol D-03 D-02 D-49 D-36 I - -’ D-41 NOTE (3) *3: 1996 models From Instrument panel wiring harness and body D-01 Pop-up switch and fog light switch D-l 6 wiring harness (RH) combination D-02 Front speaker (LH) D-03 Combination meter D-17...
Seite 57 CONFIGURATION DIAGRAMS - Instrument Panel and Floor Console D-13 D-14 D-15 D-17 D-46 D-23 D-24 0 0 0 0 4 2 6 9 D-26 D-25*’ D-29 Active aero switch <Hatchback> D-43 Instrument panel wiring harness and body D-30 Accessory socket wiring harness (LH) combination D-31 Accessory socket...
Seite 58 CONFIGURATION DIAGRAMS E-08 E-07 E-06 E-04 E - 2 5 1 E-i4 / E:22/ E-21 1 E-27 E-30 E-29 E - 2 6 E - 3 9 *2 E - 2 3 EJJ, E-28 NOTE *: From 1994 models E-14 Front seat belt solenoid (RH) E-01 Body wiring harness (RH) and door wiring...
Seite 59 CONFIGURATION DIAGRAMS - Interior E-45 E-46 E-47 E-48 E-19 E-28 ECS G sensor E-41 Jumper connector A (LH) <Convertible> E-29 Door speaker E-42 Jumper connector B <Convertible> E-30 Turn signal and hazard flasher unit E-43 Body wiring harness (RH) and door wiring E-31 Diode (for MFI circuit) harness (RH) combination <Convertible>...
Seite 60 CONFIGURATION DIAGRAMS <HATCHBACK> F-11 F-12 F-13 F-14 F-15 F-16 F-34 NOTE ‘: From 1993 mod F-01 Interior temperature sensor F-21 License plate light (LH) F-02 F-22 Luggage compartment light switch Defogger (+) F-03 Rear wiper motor F-23 F-04 High-mounted stop light or active aero rear F-24 spoiler F-25...
Seite 61 CONFIGURATION DIAGRAMS.- Luggage Compartment <CONVERTIBLE> 1995 models F-42 F;43 F-41 F-45 F-30 Back-up light (LH) F-25 F-05 Defogger (-) Rear combination light (LH) F-30 F-06 Rear speaker (RH) F-32 ECS rear shock absorber (LH) F-07 ECS rear shock absorber (RH) F-33 Rear speaker (LH) F-08...
Seite 62 CONFIGURATION DIAGRAMS <CONVERTIBLE> From 1996 models Connector symbol F-51 F-48 F-l 0 Rear combination light (RH) F-25 Back-up light (LH) F-11 Back-up light (RH) F-30 Rear combination light (LH) F-14 Rear wiring harness (RH) and fuel tank wiring Body wiring harness (RH) and rear wiring F-44 harness combination harness combination...
Seite 63 CONTENTS Active Aero Circuit ......428 ,239 Heater Circuit ......Active Exhaust System Circuit .
Seite 64 CIRCUIT DIAGRAMS - How to Read Circuit Diagrams The circuit of each system from the fuse (or fusible link) to ground is shown. The power supply is shown at the top and the ground at the bottom to facilitate understanding of how the current flows. Indicates connector No.
Seite 65 CIRCUIT DIAGRAMS - How to Read Circuit Diagrams from control unit (current flow Output output input A broken line indicates thatthese Indicates that the diagram comes from v in the same circuit. Indicates current flow downward or upward as controlled by the indicates harnessjunction where wire diameter or color changes.
Seite 66 CIRCUIT DIAGRAMS CONNECTOR / GROUNDING INDICATIONS (c-35) Revision...
Seite 67 CIRCUIT DIAGRAMS Item Connector / Grounding Symbol Contents C o n n e c t o r 1 Male terminal For the terminal symbols, the con- and termi- male terminal, and the receptacle ter- minal is indicated as the female termi- Male connector The connector in which the male ter- minal is assembles is indicated as the...
Seite 68 CIRCUIT DIAGRAMS - How to Read Circuit Diagrams COLOR CODES WIRE Wire colors are identified by the following color codes. Code Wire color Code Wire color Brown Green Sky blue Violet Gray Light green Yellow Orange If a cable has two colors, the first of the two color code 1.25 5-E Example: e+ characters indicates the basic color (color of the cable coating)
Seite 69: Circuit Diagrams
CIRCUIT DIAGRAMS COMPONENT LOCATION Dedicated fuse No. 1 to No. 7 A., 1 Fusible link Dedicated fuse No. 10 LJJ- se No. 8 and No. 9 Defogger relay TSB Revision...
Seite 70 CIRCUIT DIAGRAMS - Power Distribution Circuit GENERATOR RELAY TSB Revision...
Seite 71 CIRCUIT DIAGRAMS - Power Distribution Circuit GENERATOR RADIATOR FAN MOTOR LIGHTING SWITCH AUTOMATIC HEADLIGHT . #;HNG CONDENSER COMBINATION TURN SIGNAL MFI RELAY CONDITIONING FAN MOTOR LIGHT AND HAZARD FLASHER UNIT...
Seite 72 CIRCUIT DIAGRAMS - Power Distribution Circuit POWER DISTRIBUTION CIRCUIT (UP TO 1993 MODELS) (CONTINUED) SEAT BELT CONTROL PANEL SOLENOID STOP LIGHT HORN RELAY POWER RELAY 1 POWER RELAY 2 CONTROL UNIT CONTROL UNIT CONTROL UNIT PLATE LIGHT PLAYER CONTROL UNIT NATION SHUT-OFF UNIT ILLUMINATION...
Seite 73 CIRCUIT DIAGRAMS CONTROL MODULE 'REMOTE CONTROLLED MIRROR TRANSISTOR TRANSAXLE INTERMITTENT WIPER RELAY CONTROL UNIT SHUT-OFF UNIT CONTROL UNIT CONTROL UNIT CONNECTOR POWER RELAY MAIN SWITCH COMPRESSOR LOCK CONTROLLER SUSPENSION CONTROL UNIT CONTROL UNIT *RADIATOR FAN MOTOR RELAY AND HAZARD FLASHER UNIT CONTROL UNIT REMARK THE ABOVE CIRCUIT DIAGRAM SHOWS THE CURRENT FLOW AT THE...
Seite 74 CIRCUIT DIAGRAMS ACTIVE MODULE ------- . %F" ON,;-OFF WINDOWS RELAY DEFOGGER NOTE RELAY TSB Revision...
Seite 75 CIRCUIT DIAGRAMS - Power Distribution Circuit RADIATOR FAN MOTOR AUTOMATIC HEADLIGHT SHUT-OFF UNIT COMBINATION TURN SIGNAL MFI RELAY CONDITIONING F; LIGHT AND HAZARD FLASHER UNIT TSB Revision...
Seite 76 CIRCUIT DIAGRAMS POWER DISTRIBUTION CIRCUIT (1994 MODELS) (CONTINUED) AMPLIFIER SEAT BELT SOLENOID CONTROL PANEL STOP LIGHT HORN RELAY CONTROL UNIT PLATE LIGHT COMBINATION CONTROL UNIT LIGHT *DATA LINK CONNECTOR SHUT-OFF UNIT ILLUMINATION COMPARTMENT LIGHT LIGHT *TRANSAXLE CONTROL MODULE TAPE PLAYER SUSPENSION CONTROL UNIT CONTROL MODULE...
Seite 77 CIRCUIT DIAGRAMS - Power Distribution Circuit GENERATOR RELAY CONTROL MODULE CONTROLLED MIRROR TRANSISTOR TRANSAXLE INTERMITTENT CONTROL UNIT WIPER RELAY SHUT-OFF UNIT CONTROL UNIT TAPE PLAYER CONTROL UNIT CONNECTOR POWER RELAY (UP TO 1993 October) MAIN SWITCH COMPRESSOR LOCK CONTROLLER CONTROL UNIT AND HAZARD FLASHER UNIT CONTROL UNIT...
Seite 78 CIRCUIT DIAGRAMS BATTERY ‘GENERATOR’ NOTE link Convertible link H a t c h b a c k N o . MULTI-PURPOSE -- - FUSE @ DEFOGGER B-R B-R TSB Revision...
Seite 79 CIRCUIT DIAGRAMS - Power Distribution Circuit FUSIBLE LINK GENERATOR LIGHT LIGHT AUTOMATIC RADIATOR AUTOMATIC FAN MOTOR SHUT-OFF UNIT "4 (R-Y) LIGHTING SWITCH NOTE LIGHT AUTOMATIC HEADLIGHT LIGHTING SWITCH CONDENSER COMBINATION TURN SIGNAL MFI RELAY LIGHT AND HAZARD FLASHER UNIT TSB Revision...
Seite 80 CIRCUIT DIAGRAMS POWER DISTRIBUTION CIRCUIT (1995 MODELS) (CONTINUED) AMPLIFIER SEAT BELT W&T-ALARM CONTROL PANEL SOLENOID STOP LIGHT HORN RELAY CONTROL UNIT' CONTROL UNIT CYLINDER ILLUMINATION COMBINATION LIGHT LIGHT CONTROL UNIT ILLUMINATION SHUT-OFF UNIT LIGHT COMPARTMENT LIGHT CONTROL MODULE *RADIO AND TAPE PLAYER SUSPENSION CONTROL UNIT...
Seite 81 CIRCUIT DIAGRAMS - Power Distribution Circuit CONTROL MODULE CONTROLLED MIRROR TRANSISTOR MODULE l-----l INTERMITTENT CONTROL UNIT WIPER RELAY CONTROL UNIT TAPE PLAYER CONTROL UNIT: R CONDITIONING CONTROL UNIT FAN MOTOR RELAY MAIN SWITCH R CONDITIONING SUSPENSION CONTROL UNIT AND HAZARD FLASHER UNIT NOTE THE ABOVE CIRCUIT DIAGRAM SHOWS THE CURRENT FLOW AT THE...
Seite 82 CIRCUIT DIAGRAMS ‘GENERATOR’ NOTE UNIT DEFOGGER...
Seite 83 CIRCUIT DIAGRAMS - Power Distribution Circuit GENERATOR RADIATOR FAN MOTOR LIGHTING SWITCH NOTE HEADLIGHT CONDENSER COMBINATION TURN SIGNAL MFI RELAY CONDITIONING FAN MOTOR LIGHT AND HAZARD FLASHER UNIT HRO lM03AB...
Seite 84 CIRCUIT DIAGRAMS - Power Distribution Circuit POWER DISTRIBUTION CIRCUIT (FROM 1996 MODELS) (CONTINUED) AMPLIFIER SEAT BELT SOLENOID CONTROL PANEL STOP LIGHT ILLUMINATION HORN RELAY LIGHT *ACTIVE AERO CONTROL UNIT' CONT *AIR COMDITIONING CONTROL UNIT CONTROL UNIT PLATE LIGHT CYLINDER *REAR ILLUMINATION LIGHT CONTROL UNIT...
Seite 85 CIRCUIT DIAGRAMS CONTROL MODULE CONTROLLED MIRROR TRANSISTOR INTERMITTENT CONTROL UNIT WIPER RELAY SHUT-OFF UNIT CONTROL UNIT TAPE PLAYER UNIT CONTROL UNIT CONTROL UNIT COMPRESSOR LOCK CONTROLLER MAIN SWITCH CONTROL UNIT SUSPENSION *TURN SIGNAL CONTROL UNIT AND HAZARD FLASHER UNIT THE ABOVE CIRCUIT DIAGRAM SHOWS THE CURRENT FLOW AT THE IGNITION KEY POSITION "ACC", "ON"...
Seite 86 CIRCUIT DIAGRAMS - MFI Circuit <NON TURBO> <NON TURBO> ‘ION...
Seite 87 CIRCUIT DIAGRAMS TSB Revision...
Seite 88 CIRCUIT DIAGRAMS - MFI Circuit <NON TURBO> MFI CIRCUIT (1992 MODEL) <NON TURBO> (CONTINUED) CRANKSHAFT AND CAMSHAFT FLOW SENSOR "4 R-W 1.25B G-Y 0 0.85R L-Y 61 64 G-Y BR-R1.258 RELAY B 0.85R W/ B I 1 . 25: B 1.25B ENGINE THROTTLE (B-05)
Seite 89 CIRCUIT DIAGRAMS RELAY 1.251 1. 251 IDLE AIR CONTROL MOTOR I I I I G-W 1 G-B 1 B-L 2 ---_ ------ VARIABLE INDUCTION KNOCK TEMPERATURE CONTROL MOTOR SENSOR SENSOR (~-22) TSB Revision...
Seite 90 CIRCUIT DIAGRAMS MULTI-PURPOSE IGHT FUSE@ WITH WITHOUT DEDICATED FUSE OFF - 0~ DIODE E-31 (c-52) AIR CONDITIONING ENGINE COOLANT POWER TRANSISTOR TEMPERATURE SWITCH UNIT TSB Revision...
Seite 91 RELAY 'ROL SOLENOID (A-21) BR-L (c-79) TA LINK TION NNECTOR ECTOR POWER STEERING PRESSURE SWITCH TSB Revision...
Seite 92 CIRCUIT DIAGRAMS <TURBO> 1 ------------- IOD OR STORAGE CONNECTOR RELAY (c-44) 1. 25 71 _-----...
Seite 93 FUEL PUMP RELAY (B-28) COMBINATION METER SPEED SENSOR 1.258 06 . - - - - - - - - - - - _ ENGINE CONTROL MODULE Revision...
Seite 94 CIRCUIT DIAGRAMS MFI CIRCUIT (1992 MODEL) <TURBO> (CONTINUED) CRANKSHAFT AND CAMSHAFT (B-04) 0.8s FLOW SENSOR (B-29) I N T A K E A I R "7 R-W 1.25B G-Y 0 65 -__-------. MODULE G-Y BR-Rl. Y -R ------ ------ RELAY B 0.85R W;...
Seite 95 CIRCUIT DIAGRAMS RELAY RESISTOR N J E C T O R LG-B HEATED OXYGEN (~-19)
Seite 96 CIRCUIT DIAGRAMS MULTI-PURPOSE ACTIVE CONTRO r---- (c-52) (c-54) 6 _------- ------- ---------- POWER TRiNSISTOR UNIT RELAY (c-61)
Seite 97 CIRCUIT DIAGRAMS - MFI Circuit <TURBO> RELAY TURBOCHARGER FUEL PRESSURE EMISSION PURGE SOLENOID SOLENOID SOLENOID "1 (A-20) LG-B ------- TIMING ADJUSTMENT CONNECTOR CONDITIONING ENGINE COOLANT POWER STEERING PRESSURE SWITCH (B-38) TSB Revision...
Seite 98 CIRCUIT DIAGRAMS <NON TURBO> IGNITION FUSIBLE LINK@ "1 IOD OR STORAGE CONNECTOR WITHOUT RELAY OFF-ION 1.25 (F) M/T A/T e B-R 1.25R 1. 25 1.25 71 ------ (c-53: TSB Revision...
Seite 99 CIRCUIT DIAGRAMS 1. 25B-I 1.258-F CONNECTOR COMBINATION METER r----- ----- SPEED (REED ITCH) (F-16) 1.258 ENGINE CONTROL MODULE TSB Revision...
Seite 100 CIRCUIT DIAGRAMS FLOW SENSOR "7 "5 "1 '(2 "4 (B-40) “1 "2 (B-41)"1 " G-Y (F>O 0.85R L-Y RELAY ENGINE HEATED THROTTLE (B-40) mm (c-52) (c-53) 1 2 3 4 TSB Revision...
Seite 101: Idle Speed
CIRCUIT DIAGRAMS - MFI Circuit <NON TURBO> RELAY 25R 1 IDLE SPEED (B-35) r r” ------ ---___ 0. 85G-' 3 --------_-___- ------- -_-___ ------- ----- -------- Y 111 m 2 d ,1 (B-08) VARIABLE INDUCTION CONTROL MOTOR TEMPERATURE SENSOR (A-P~) SENSOR ) CFm TSB Revision...
Seite 102 CIRCUIT DIAGRAMS - MFI Circuit <NON TURBO> MFI CIRCUIT (1993 MODELS) <NON TURBO> (CONTINUED) MULTI-PURPOSE CLUTCH DEDICATED FUSE DIODE E-31 R-G,, 19 (c-29) (c-52) R-G 24 BR-R AIR CONDITIONING ENGINE COOLANT TEMPERATURE SWITCH IGNITION POWER TRANSISTOR UNIT TSB Revision...
Seite 103 CIRCUIT DIAGRAMS RELAY TRANSAXLE EVAPORATIVE SOLENOID EMISSION VALVE PURGE SOLENOID BR-L (B-06) POWER STEERING PRESSURE SWITCH TSB Revision...
Seite 104 CIRCUIT DIAGRAMS <TURBO> FUSIBLE LINK@ IOD OR STORAGE CONNECTOR RELAY 1. 2 1. 25 1. 251 71 ------ (c-53: (c-29) (c-31) (c-44) (c-52) TSB Revision...
Seite 105 CIRCUIT DIAGRAMS RELAY '6 (c-71) FUEL --FUEL PUMP PUMP (D-44) RELAY RESISTOR (B-28) COMBINATION M E T E R CONNECTOR FUEL PUMP (F-16) ENGINE CONTROL MODULE (F-16) TSB Revision...
Seite 106 CIRCUIT DIAGRAMS FLOW SENSOR (B-29) "7 "6 "1 "2 "4 - - - - - - - - - - - - (c-52) 26 61 y64 72 CONTROL MODULE G-Y BR-R1.258 Y-R (B-05) (B-05) TSB Revision...
Seite 107 CIRCUIT DIAGRAMS RELAY RESISTOR IDLE , 1 "3 "4 "6 2 I\ 9E l(B-08) HEATED OXYGEN (~-19) KNOCK SENSOR SENSOR (A-69) TSB Revision...
Seite 108 CIRCUIT DIAGRAMS MFI CIRCUIT (1993 MODELS) <TURBO> (CONTINUED) ACTIVE CONTRO r - - - - G " DIODE E-31 Y (c-52) (c-54) ---- B-W BR-f (F>\ IGNITION POWER TRANSISTOR UNIT RELAY (c-61)
Seite 109 CIRCUIT DIAGRAMS RELAY PRESSURE SOLENOID "1 (A-71) DATA LINK CONNECTOR CONDITIONING ENGINE COOLANT POWER STEER PRESSURE SW TSB Revision...
Seite 110 CIRCUIT DIAGRAMS <NON TURBO> IGNITION 3 . -------------- (c-71) M/T I 1.250-W 1.258 "2 "3 "6 "5 1. 25 B-R 1.25R 1. 25 1. 25 ___ 120 TSB Revision...
Seite 111 CIRCUIT DIAGRAMS 1.250 (c-71) FUEL PUMP CHECK CONNECTOR 1.25B- COMBINATION METER r - - - - - - - . FUEL PUMP (F-16) 1. 25: 1. 251 ENGINE CONTROL MODULE...
Seite 112 CIRCUIT DIAGRAMS VOLUME VOLUME AIR FLOW SENSOR (B-29) I N T A K E A I R (c-53): ------ ----- --------_------ -______-_ -------------- ENGINE ' CONTROL: MODULE ; TSB Revision...
Seite 113 1 1 1 CIRCUIT DIAGRAMS THROTTLE CONTROL MOTOR (CALIFORNIA> ----- ENGINE NOTE TSB Revision...
Seite 114 CIRCUIT DIAGRAMS MFI CIRCUIT MODELS) <NON TURBO> (CONTINUED) (1994 MFI RELAY KNOCK SENSOR 1 ! 1 5MOTOR _____ -___- ----- ----. ------ ENGINE 26 (c-52) 1.258 NOTE...
Seite 115 CIRCUIT DIAGRAMS RIGHT BANK LEFT BANK RIGHT BANK LEFT BANK HEATED OXYGEN HEATED OXYGEN HEATED OXYGEN HEATED OXYGEN SENSORCREAR) (CALIFORNIA> (CALIFORNIA> (CALIFORNIA> INJECTOR (B-3. -- 3 _---__ 6 _--_ 15 ----_ ---- ------ ---_ ENGINE CONTROL MODULE NOTE TSB Revision...
Seite 116 CIRCUIT DIAGRAMS - MFI Circuit <NON TURBO> MFI CIRCUIT (1994 MODELS) <NON TURBO> (CONTINUED) MULTI-PURPOSE DIODE E-31 19 (c-29) ENGINE r----- -_- ___-- --- '2 I------------- (c-54):' RADIATOR RADIATOR IGNITION POWER TRANSISTOR FAN MOTOR TSB Revision...
Seite 117: Data Link Connector
CIRCUIT DIAGRAMS RELAY NTROL EVAPORATIVE EMISSION PURGE SOLENOID (A-21) LG-R BR-L POWER STEERING DATA LINK CONNECTOR IGNITION NOTE TIMING OFF - ON CONNECTOR ) e=zi) (c-79) FRONT SIDE TSB Revision...
Seite 118 CIRCUIT DIAGRAMS <TURBO> BAT’ FUSIBLE LINK@ 11 -------------- IOD OR MFI RELAY 1. 2!
Seite 119 CIRCUIT DIAGRAMS - MFI Circuit IGNI SWIT FUEL PUMP RELAY CIRCUIT RESISTOR 0.858-h 258-L COMBINATION GAUGE CONNECTOR 1.25B-R r - - - - - ---_-. (D-03) COMB METE METER) FUEL , PUMP 1 -------_ (F-16) 1.258 3 _-_--__--------___ ENGINE CONTROL MODULE...
Seite 120 CIRCUIT DIAGRAMS - MFI Circuit MFI CIRCUIT (1994 MODELS) <TURBO> (CONTINUED) (B-02) VOLUME ENGINE COOLANT (B-29) I N T A K E A I R (c-52) 2 -------. 30 -------_--. ENGINE CONTROL MODULE +(j...
Seite 121 CIRCUIT DIAGRAMS KNOCK THROTTLE SENSOR (CALIFORNIA) ENGINE CONTROL MODULE (A-22) (B-05)
Seite 122 CIRCUIT DIAGRAMS MFI CIRCUIT (1994 MODELS) <TURBO> (CONTINUED) MFI RELAY RESISTOR (A-69) 0. 85 0. 8: 6 _---- 1.25 1.25 (B-33: 0. 05 0. 85 3 .---- 0. 85 0. 8E 3 :--- 5 ._---_ 18 -- 3 ----- 16 _---. 14 (C-52) TSB Revision...
Seite 123 CIRCUIT DIAGRAMS RIGHT BANK LEFT BANK RIGHT BANK LEFT BANK HEATED OXYGEN HEATED OXYGEN HEATED OXYGEN HEATED OXYGEN (CALIFORNIA) (CALIFORNIA> (CALIFORNIA) (B-44) (B-45) --- 7 -- -_ TSB Revision...
Seite 124 CIRCUIT DIAGRAMS MULTI-PURPOSE DEDICATED 3B-R FUSE 0. 85G 1 r--- DIODE E-31 IL 12 (C-29) , MODULE 24 (c- 7 ----- 6 _------ AIR ' CONDITIONING CONTROL UNIT RADIATOR ROL & IGNITION POWER TRANSIST;OR TSB Revision...
Seite 125 CIRCUIT DIAGRAMS RELAY r---- 2 TURBOCHARGER 32 (c-53) ENGINE (A-18) DATA Lib IGNITION TIMING ADJUSTMENT CONNECTOR...
Seite 126 CIRCUIT DIAGRAMS - MFI Circuit <NON TURBO> <NON TURBO> (FEDERAL) IGNIT BATTERY FUSIBLE LINK0 CONTROL SUSPENSION HEADLIGHT DOME LIGHT. FOOT LIGHT AND IGNITION KEY CYLINDEE ILLUMINATION LIGHT “2 “3 “6 “5 “1 1.25 B-R 1.25R 1. 25 108 (c-54)
Seite 127 CIRCUIT DIAGRAMS - MFI Circuit <NON TURBO> IGNITION (D-44) FUEL PUMP CHECK CONNECTOR 1.25B- TURN-SIGNAL LIGHT AND HAZARD LIGHT COMBINATION METER WARNING WARNING LIGHT LIGHT COMBINATION G-I G-I FUEL Y - W PUMP 7 ------ ---- (F-16) IGNITION IGNITION TSB Revision...
Seite 128 CIRCUIT DIAGRAMS (B-02) VOLUME NGINE OOLANT VOLUME ATMOSPHERIC I N T A K E A I R - 13 26 (c-52)
Seite 129 CIRCUIT DIAGRAMS - MFI Circuit <NON TURBO> VARIABLE INDUCTION THROTTLE CONTROL MOTOR -a%- .----_. B-10) 03 ----_ 09 ------ ENGINE CONTROL MODULE...
Seite 130 CIRCUIT DIAGRAMS MFI RELAY B-13) 3 SENSOR 5 MOTOR 2 _ - ENGINE CONTROL MODULE Revision...
Seite 131 1 2 9 CIRCUIT DIAGRAMS LEFT BANK HEATED OXYGEN 1. 25( KNOCK SENSOR (B-31 0.8581 3 -----_ (c-53) 15 ----- ENGINE CONTROL MODULE 1 2 3 4...
Seite 132 CIRCUIT DIAGRAMS MFI CIRCUIT (1995 MODELS) <NON TURBO> (FEDERAL) (CONTINUED) MULTI-PURPOSE WITH STOP LIGHT SWITCH O F F 1 ON CONTROLLED MIRROR G I lnIfli-lF 19 (c-29) ENGINE '2 1------------- ---------------- ------------------------------. 1 3 0 (G-R) METER AND 11 (c-29) GAUGES RADIATOR IGNITION POWER TRANSISTO;...
Seite 133: Data Link Connector
CIRCUIT DIAGRAMS - MFI Circuit <NON TURBO> RELAY TROL M EVAPORATIVE SOLENOID '(c-53) ------ SUSPENSION B P R-B (Y) 16 7 DATA LINK CONNECTOR IGNITION TIMING ADJUSTMENT CONNECTOR 9 ~10j11~~12~13/14/15~16)171118/19 (c-79) FRONT SIDE TSB Revision...
Seite 134 CIRCUIT DIAGRAMS - MFI Circuit -<NON TLhBO> <NON TURBO> (CALIFORNIA) IGNITION BATTERY FUSIBLE LINK@ HORN 'OOT LIGHT ILLUMINATION FLOW 7 (R-B) 1 M> O N ? - O F F "5 "1 ( c - 5 4) 1.25 (c-54) 91 ------ TSB Revision...
Seite 135 CIRCUIT DIAGRAMS - Circuit RELAY CHARGING (D-44) FUEL PUMP CHECK CONNECTOR 1.25B-1 i TURN-SIGNAL LIGHT AND HAZARD LIGHT 1. 25 'B-R r - - - - - - (D-03) COMBINATION METER FUEL PUMP IGNITION Y - W 1. : METER AND GAUGES ( c - 3 4 )
Seite 136 CIRCUIT DIAGRAMS MFI CIRCUIT (1995 MODELS) <NON TURBO> (CALIFORNIA) (CONTINUED) VOLUME 'OOLANT “1 0 .---- ---- -- - 13 13 1.250 1.250 TSB Revision...
Seite 137 CIRCUIT DIAGRAMS 1 3 5 VARIABLE INDUCTION THROTTLE CONTROL MOTOR I--- ----_ CONTROL MODULE...
Seite 138 CIRCUIT DIAGRAMS - MFI Circuit MFI CIRCUIT (1995 MODELS) <NON TURBO> (CALIFORNIA) (CONTINUED) MFI RELAY ------ ENG I NE CONTROL MODULE...
Seite 139 CIRCUIT DIAGRAMS RIGHT BANK LEFT BANK HEATED OXYGEN LEFT BANK RIGHT BANK HEATED OXYGEN ~~~~~~ HEATED OXYGEN HEATED OXYGEN (B-16) (B-19) 1.25 4 “I '3 INJECTOR (B-33: (B-07) 3 L----. 2 1 .-J '7 ---. ENGINE TSB Revision.
Seite 140 CIRCUIT DIAGRAMS - Circuit MULTI-PURPOSE A-36) REAR WINDOW DEFOGGER DIODE E-31 19 (c-29) ENGINE (G-R) 11 (c-29) AGNE' LUTC! IGNITION POWER TRANSISTOR NOTE...
Seite 141 CIRCUIT DIAGRAMS 1 3 9 RELAY TRANSAXLE C TROL k EVAPORATIVE EMISSION PURGE SOLENOID (A-21) 37 (C-53) (c-29) yf-----y (B-06) ,,2 SUSPENSION (B-38) TIMING DATA LINK CONNECTOR ADJUSTMENT CONNECTOR TSB Revision...
Seite 142 CIRCUIT DIAGRAMS - MFI Circuit <TURBO> <TURBO> BATTERY FUSIBLE LINK@ HORN IOD OR STORAGE CONNECTOR SUPPLEMENTAL LUGGAGE LIGHT, IGNITION CYLINDER MFI RELAY LIGHT --------- . . 25B-‘ 1 2 3 4 ( c - 7 7 ) ( c - 8 3 ) ( D - 1 5 ) ( D - 4 4 ) TSB Revision...
Seite 143 CIRCUIT DIAGRAMS TION RELAY CHARGING FUEL PUMP '6 (c-71) RELAY CIRCUIT RESISTOR (B-28) TURN-SIGNAL LIGHT AND HAZARD LIGH COMBINATION GAUGE CONNECTOR 1.25B-F WARNING LIGHT COMB METE FUEL PUMP (F-16) (F-14) L - - 6 .---- ----- ------ --. 36 (c-54) ENGINE CONTROL MODULE...
Seite 144 CIRCUIT DIAGRAMS - MFI Circuit <TURBO> VOLUME ENGINE COOLANT I N T A K E A I R 32 ------- '2 .----___ 1 ---_ 33 -------------- ENGINE CONTROL MODULE...
Seite 145 CIRCUIT DIAGRAMS - MFI Circuit <TURBO> KNOCK THROTTLE SENSOR (CALIFORNIA> BR-R 78 cc-54) ENGINE CONTROL MODULE 1.250 (A-22) (B-05) (B-08)(=)
Seite 146 CIRCUIT DIAGRAMS MFI CIRCUIT (1995 MODELS) <TURBO> (CONTINUED) MFI RELAY RESISTOR (A-69) 0. 8E INJECTOR 1. 25 “3 “4 (‘6 1. 25( 0. 8E 0. a5 3 .---- GR-L :F)G-I 0. 85 0. 85 3 ---- 16 ----- 1 ---- 2 ----.
Seite 147 CIRCUIT DIAGRAMS RIGHT BANK LEFT BANK RIGHT BANK LEFT BANK HEATED OXYGEN HEATED OXYGEN HEATED OXYGEN HEATED OXYGEN (CALIFORNIA) (CALIFORNIA> (CALIFORNIA> (B-16) (B-44) (B-19) "2 '2 --- . 25E (c-54) TSB Revision...
Seite 148 CIRCUIT DIAGRAMS - MFI Circuit <TURBO> MFI CIRCUIT (1995 MODELS) <TURBO> (CONTINUED) MULTI-PURPOSE DEFOGGER REAR WINDOW DEFOGGER MODULE ----- 7 ----- 1 L-- (A-67) METER AND GAUGES (A-36) NOTE ETIC L RADIATOR FAN MOTOR IGNITION POWER TRANSISTOR RELAY...
Seite 149 CIRCUIT DIAGRAMS RELAY TURBOCHARGER WASTE GATE SOLENOID 7 _-___--__-_--_ 3 _-_-___-_------_ 32 (c-53) ENGINE (A-67) (B-06) (B-38) ,,l DATA LINK CONNECTOR IGNITION TIMING ADJUSTMENT CONNECTOR (c-52) Revision...
Seite 150 CIRCUIT DIAGRAMS <NON TURBO> STARTER RELAY ---- (c-83) ‘il "7 (A-67) CONNECTOR WITH . WITHOUT DOME LIGHT, SWITCH FOOT LIGHT AND IGNITION KEY CYLINDER c-29) VOLUME AIR FLOW SENSOR O N '-OFF W-R 2 1.25B-L 'I TSB Revision...
Seite 151 CHARGING 1.25 1.25 CONNECTOR AND HAZARD LIGHT COMBINATION METER 1. 251 r - - - - - - COMBINATION 1. 25F METER (SPEEDOMETER) FUEL PUMP IGNITION 1. ; 1 . : NOTE TSB Revision...
Seite 152 CIRCUIT DIAGRAMS - MFI Circuit <NON TURBO> MFI CIRCUIT (FROM 1996 MODELS) <NON TURBO> (CONTINUED) VOLUME ENGINE (B-29)
Seite 153 CIRCUIT DIAGRAMS - Circuit VARIABLE INDUCTION MANIFOLD THROTTLE CONTROL MOTOR DIFFERENTIAL (B-05) BR-R ENG I NE CONTROL MODULE TSB Revision...
Seite 154 CIRCUIT DIAGRAMS MFI RELAY KNOCK SENSOR 1 r 1 3 SENSOR INJECTOR i ----- ----- ----- ----_ ENGINE CONTROL MODULE 1.258...
Seite 155 CIRCUIT DIAGRAMS RIGHT BANK LEFT BANK HEATED OXYGEN LEFT BANK RIGHT BANK HEATED OXYGEN x$:5$ HEATED OXYGEN HEATED OXYGEN 1 *- ---- -__-_--_--_ (B-45) 1.25 1.25 INJECTOR 2 I I (B-33 (B-3; (B-31 L -_I 4 .----_ 3 ---_i- ---- ENGINE CONTROL MODULE...
Seite 156 CIRCUIT DIAGRAMS MULTI-PURPOSE REAR WINDOW DEFOGGER DEFOGGER 'REMOTE DIODE E-31 19 (c-29) ENGINE 58 (c-92) I - - - - - - - - - - - - - -------- ----. ---- RADIATOR MAGNETIC CONDITIONING CLUTCH IGNITION POWER TRANSISTO; CONTROL UNIT...
Seite 157 CIRCUIT DIAGRAMS RELAY EVAPORATIVE SOLENOID VALVE SOLENOID (A-21) W-I. LG-R 46 (c-53) ENGINE CONTROL MODULE (B-06) IGNITION TIMING ADJUSTMENT CONNECTOR (c-79) FRONT SIDE (c-92)
Seite 158 CIRCUIT DIAGRAMS - Circuit <TURBO> FUSIBLE LINK0 HORN IOD OR STORAGE CONNECTOR SUPPLEMENTAL ARNING LIGHT AUTO-CRUISE CONTROL FULL AUTO A/C LUGGAGE DOME LIGHT, IGNITION CYLINDER ILLUMINATIC LIGHT HEADLIGHT “1 2 MFI RELAY 38 (c-53) TSB Revision...
Seite 159 CIRCUIT DIAGRAMS IGNI ‘ON RELAY CHARGING FUEL FUEL PUMP PUMP RELAY CIRCUIT RESISTOR (B-28) ! 1. 258-l COMBINATION COMBINATION GAUGE CONNECTOR r - - - - - - - - - _ 1.258-L FUEL PUMP 7 .__-_--___-__-__--- (F-161 (F-14) GAUGES (A-17) (A-5(- TSB Revision...
Seite 160 CIRCUIT DIAGRAMS - MFI Circuit <TURBO> MFI CIRCUIT (FROM 1996 MODELS) <TURBO> (CONTINUED) VOLUME VOLUME AIR FLOW SENSOR (B-29) I N T A K E A I R 32 --_---_ - - - -----. ENGINE CONTROL MODULE...
Seite 161 CIRCUIT DIAGRAMS MANIFOLD KNOCK THROTTLE DIFFERENT SENSOR I - - (c-541 ENGINE CONTROL MODULE (A-22) (B-05) (B-08) (B-46) (c-52)
Seite 162 CIRCUIT DIAGRAMS - MFI Circuit <TURBO> MFI CIRCUIT (FROM 1996 MODELS) <TURBO> (CONTINUED) MFI RELAY RESISTOR (A-69) 0. 82 MOTOR 2 0,,5 6 _---- 1. 25 (B-13: 1. 25C (B-32: (B-33 0. 85 0. 85 0. 85 3 _---- 2 _---- GR-L (F)G-\I 0.
Seite 163 CIRCUIT DIAGRAMS LEFT BANK LEFT BANK RIGHT BANK RIGHT BANK HEATED OXYGEN HEATED OXYGEN HEATED OXYGEN HEATED OXYGEN (B-16) (B-19) '1 "3 '1 "3 & 34 (c-53:...
Seite 164 CIRCUIT DIAGRAMS MFI CIRCUIT (FROM 1996 MODELS) <TURBO> (CONTINUED) MULTI-PURPOSE IGHT DEDICATED 3B-R FUSE STOP LIGHT SWITCH REAR WINDOW DEFOGGER DEFOGGER DIODE E-31 ENGINE ------ ------. ‘1 (c-52 (A-67) (G-B) (A-36) RADIATOR UNIT...
Seite 165 CIRCUIT DIAGRAMS RELAY TURBOCHARGER SOLENOID WASTE GATE PURGE SOLENOID SOLENOID 9 _____-____-__--- 32 (c-53) ENGINE CONTROL MODULE (A-67) (B-06) FULL AUTO P R-B (Y) POWER STEERING DATA LINK CONNECTOR IGNITION TIMING ADJUSTMENT CONNECTOR TSB Revision...
Seite 166: Component Location
CIRCUIT DIAGRAMS COMPONENT LOCATION Up to 1993 models and 1994, 1995 models Non Turbo (Federal) Symbol Name Name Ignition coil (ignition power transistor) Air conditioning relay Air conditioning switch Ignition timing adjusting terminal Injector Camshaft position sensor Check engine/malfunction indicator lamp Crankshaft position sensor Data link connector EGR solenoid <California - Non Turbo, Turbo>...
Seite 167 CIRCUIT DIAGRAMS (with built-in intake air temperature sensor and barometric pressure sensor) temperature sensor built-in closed throttle position switch) Heated oxygen sensor...
Seite 168 CIRCUIT DIAGRAMS Vehicle speed sensor (DC motor) (with built-in induction Injector control valve position sensor) , ./...
Seite 169 CIRCUIT DIAGRAMS Check engine/malfunction Engine control module W 16FO297 TSB Revision...
Seite 170 CIRCUIT DIAGRAMS - MFI Circuit Revision...
Seite 171 CIRCUIT DIAGRAMS 1 994, 1995 models except Non Turbo (Federal) and from 1996 models Symbol models for Federal -Turbo> Evaporative emission purge solenoid Turbocharger waste gate solenoid <Turbo> Fuel pressure solenoid <Turbo> Variable induction control motor (DC motor) (with built-in induction control valve position sensor) Heated oxygen sensor Idle air control motor (stepper motor) Vehicle speed sensor...
Seite 172 CIRCUIT DIAGRAMS Volume air flow sensor” ’ (with built-in intake air temperature sensor and barometric pressure sensor) Vehicle speed sensor (reed switch) Vehicle speed sensor I TSB Revision...
Seite 173 CIRCUIT DIAGRAMS - MFI Circuit Injector...
Seite 174 1 7 2 CIRCUIT DIAGRAMS - MFI Circuit pressure sensor TSB Revision...
Seite 175 CIRCUIT DIAGRAMS TSB Revision...
Seite 176 NOTES...
Seite 177 CIRCUIT DIAGRAMS - Cooling Circuit COOLING COMPONENT LOCATION Name Symbol Name Symbol Air conditioning compressor lock controller Radiator fan motor control relay (up to 1993 models) Air conditioning control unit Radiator fan motor relay (HI) Condenser fan motor relay (Hi) Radiator fan motor relay (LO) Condenser fan motor relay (LO) 00002185...
Seite 178 CIRCUIT DIAGRAMS COOLING CIRCUIT (UP TO 1993 MODELS) IGNIT IGNITION FUSIBLE LINK@ L-RI ------- ENGINE COOLANT R E S I S T O R LEVEL SENSOR OFF - RADIATOR FAN ASSEMBLY (A-55) TSB Revision...
Seite 179 CIRCUIT DIAGRAMS - Cooling Circuit 9 _--__-__----___---__---~~~---~~---- (A-36) TSB Revision...
Seite 180 CIRCUIT DIAGRAMS - Cooling Circuit COOLING CIRCUIT (1994, 1995 MODELS) <NON TURBO> (FEDERAL) FUSIB E IGNI: IGNITION LINK 2 .-_______--____ METER AND GAUGES TURN-SIGNAL LIGHT AND RADIATOR HAZARD LIGHT L-Y 7 ENGINE 11 --- VEHICLE ASSEMBLY : (RESISTOR) . (A-55): Revision...
Seite 181 CIRCUIT DIAGRAMS DUAL AIR CONDITIONING IGNITION COMPRESSOR LOCK CONTROLLER I - - - - - - - DEDICATED FUSE CONDENSER ------- ------- ( H I ) (LO) OFF-,? "3 (A-34X) “L '4 (A-31X) 4 .---__ CONNECTION TSB Revision...
Seite 182 CIRCUIT DIAGRAMS COOLING CIRCUIT (1994, 1995 MODELS) <TURBO, NON TURBO (CALIFORNIA)> CHARGING ASSEMBLY RADIATOR LIGHT FAN MOTOR ) METER AND I LIGHT AND HAZARD LIGHT RADIATOR 11 --------------------------- L-Y f ENGINE VEHICLE COOLANT ASSEMBLY (RESISTOR) TSB Revision...
Seite 183: Air Conditioning
CIRCUIT DIAGRAMS - Cooling Circuit DUAL AIR CONDITIONING FUSIB E IGNITION COMPRESSOR LOCK CONTROLLER CONNECTION (A-36) [CONDENSER TSB Revision...
Seite 184 CIRCUIT DIAGRAMS - Cooling Circuit COOLING CIRCUIT (FROM 1996 MODELS) IGNITION IGNITION 'FULL-AUTO J/B @ AIR CONDITIONING (c-69) METER AND GAUGES TURN-SIGNAL LIGHT AND RADIATOR HAZARD LIGHT r - b - - - ENGINE VEHICLE COOLANT METER AND @;R GAUGES Revision...
Seite 185: Cooling Circuit
CIRCUIT DIAGRAMS DUAL AIR CONDITIONING IGNITI COMPRESSOR LOCK 20A C "4 (A-31X) L---- CONNECTION TSB Revision...
Seite 186: Troubleshooting Hints
CIRCUIT DIAGRAMS - Cooling Circuit TROUBLESHOOTING HINTS 1. Neither the radiator fan nor condenser Check the radiator fan motor relay (LO) fan rotate at all. and condenser fan motor relay (LO). Check the therm0 sensor (for radiator Check fusible link No. 5 fan).
Seite 187 CIRCUIT DIAGRAMS OPERATION The engine control module controls the power NOTE transistors (high speed and low speed) in the module In the event of faulty water temperature sensor, to provide radiator fan motor and condenser fan the engine control module commands the fan motors motor rotation controls in accordance with the engine (for both radiator and condenser) to rotate at high coolant temperature and vehicle speed.
Seite 188 CIRCUIT DIAGRAMS ELC-4 A/T CIRCUIT (1992 MODEL) IGNITION IGNITION WITH ALARM PARK/NEUTRAL STARTER Y-E? (R-G) ,,3 (R-G) (R-G) (D-03) B-Y _ (B-Y) RHEOSTAT...
Seite 189 CIRCUIT DIAGRAMS SWITC TAILLIGHT RELAY OVERDRI VE SWITCH MODULE (R-G) R-W A (B-Y) CONTROL UNIT (c-37) Revision...
Seite 190 CIRCUIT DIAGRAMS - EL(=-4 A/T Circuit ELC-4 A/T CIRCUIT (1992 MODEL) (CONTINUED) A/T FLUID AIR CONDITIONING COMPRESSOR LOCK ENGINE CONTROL MODULE 1 CONTROLLER (HOT) (c-29) (G-R IOD OR STORAGE CONNECTOR m^ (DOHC-Non-Turbo> (Y-W) ------- IGNITION POWER TRANSISTOR (Y-R) SWITCH SPEED (c-13) SENSOR O F F - O N...
Seite 191 CIRCUIT DIAGRAMS PULSE ENGINE CONTROL MODULE GENERATOR B &%iATDR A (A-54) 59 _---_ 05 lm 62 TSB Revision...
Seite 192 CIRCUIT DIAGRAMS ELC-4 A/T CIRCUIT (1993 MODELS) IGNITION IGNITION (A-67) 5---- WITHOUT WITH PARK/NEUTRAL ------------- -----_______ 9 lllJ12 2 4 STARTER (D-03) RHEOSTAT (c-14) TSB Revision...
Seite 193 CIRCUIT DIAGRAMS - ELCQ E\TT Circuit TAILLIGHT RELAY (L-R OVERDRIVE TSB Revision...
Seite 194 CIRCUIT DIAGRAMS ELC-4 W CIRCUIT (1993 MODELS) (CONTINUED) ENGINE CONTROL MODULE (c-52: (c-54 (G-R IOD OR STORAGE 7 ------. 3 - ----- ‘4 L_----------------------- ------- _----- (Y-R' IGNITION POWER TRANSISTOR (Y-R SWITCH (B-42)
Seite 195 CIRCUIT DIAGRAMS PULSE ENGINE CONTROL MODULE GENERATOR B k%:ATOR A - --__ I --. 4 - - - -. THROTTLE ) ---- G N D G N D - - - J SOLENOID VALVE TSB Revision...
Seite 196 CIRCUIT DIAGRAMS ELC-4 AIT CIRCUIT (1994, 1995 MODELS) (FEDERAL) SWITC CHARGING 5 ----------- WITH ALARM SYSTEM (L-R) PARK/NEUTRAL SYSTEM STARTING TSB Revision...
Seite 197 CIRCUIT DIAGRAMS - ELC4 A/T Circuit OVERDRIVE AND PARK/NEUTRAL CRUISE CONTROL UNIT (R-G SUSPENSION VANITY MIRROR LiGHT AND INSPECTION LIGHT (G-W) DEFOGGER AND INSF (c-14) $:--$:4 ILLUMINATION LIGHT (R-G) G-Y (B-Y) COMBINATION COMBINATION' '\ /\ METER METER (D-03) (D-03) RHEOSTAT...
Seite 198: Data Link Connector
CIRCUIT DIAGRAMS - ELC-4 A/T Circuit ELC-4 A/T CIRCUIT (1994, 1995 MODELS) (FEDERAL) (CONTINUED) AIR CONDITIONING A/T FLUID COMPRESSOR LOCK CONTROLLER SENSOR (c-54 (A-67) G-Y B-1 R-B 8 MFI SYSTEM IOD OR STORAGE CONNECTOR DOOR LIGHT AND LUGGAGE DOME LIGHT, FOOT LIGHT AND IGNITION KEY CYLINDER...
Seite 199 CIRCUIT DIAGRAMS ENGINE CONTROL MODULE PULSE GENERATOR B :k%ATOR A --- ----_ (c-47) (A-54) (B-05) iB-27)(- TSB Revision...
Seite 200 CIRCUIT DIAGRAMS A/T Circuit ELC-4 A/T CIRCUIT (1994, 1995 MODELS) (CALIFORNIA) IGNITION CHARGING WITH ALARM MFI SYSTEM (L-R) PARK/NEUTRAL MFI SYSTEM STARTING SUPPLEMENTAL...
Seite 201 CIRCUIT DIAGRAMS - ELC-4 A/T Circuit OVERDRIVE AND TAILLIGHT RELAY MULTI-PURPOSE OVERDRIVE AND r - - - - ------_ WITHOUT PARK/NEUTRAL NOTE (R-G METER AND SUSPENSION GAUGES VANITY MIRROR LIGHT AND INSRECTION LIGHT GLOVE BOX LIGHT, VANITY MIRROR LIGHT DEFOGGER (G-W) AND INSPECTION *TURN-SIGNAL LIGHT...
Seite 202 CIRCUIT DIAGRAMS - ELC-4 A/T Circuit ELC-4 A/T CIRCUIT (1994, 1995 MODELS) (CALIFORNIA) (CONTINUED) AIR CONDiTIONING COMPRESSOR LOCK ENGINE CONTROL MODULE CONTROLLER I loAO I R R-Y (F>R- (R-B) IOD OR STORAGE CONNECTOR MFI SYSTEM 1 DOOR LIGHT AND LUGGAGE COMPARTMENT LIGHT - - - - - - - - - - - -...
Seite 203 CIRCUIT DIAGRAMS - ELC-4 A/T Circuit ENGINE CONTROL MODULE PULSE PULSE GENERATOR B GENERATOR A (A-54) , _-- THROTTLE 12 .--_- SOLENOID VALVE Revision...
Seite 204 CIRCUIT DIAGRAMS - A/T Circuit ELC-4 A/T CIRCUIT (FROM 1996 MODELS) IGNITION IGNITION IGNITION ' CHARGING (c-77) WITHOUT WITH SYSTEM (L-R) PARK/NEUTRAL/ 1.258-W SYSTEM 0.850-R STARTING SUPPLEMENTAL Revision...
Seite 205 CIRCUIT DIAGRAMS - ELC4 A/T Circuit r - - - - WITHOUT PARK/NEUTRAL (R-G GAUGES INSPECTION LIGHT REAR WINDOW DEFOGGER TURN-SIGNAL LIGHT(G-W) #&B~~R~&HL'~GHT AND HAZARD LIGHT AND INSPECTION LIGHT (c-14) ILLUMINATION LIGHT (R-G 8 OVERDRIVE ANC CONTROL MODULE (B-Y) COMBINATION METER (D-03)
Seite 206 CIRCUIT DIAGRAMS ELC-4 A/T CIRCUIT (FROM 1996 MODELS) (CONTINUED) (c-53 (c-9; IOD OR STORAGE CONNECTOR 4 .-----_ 7 -----__ DOOR LIGHT AND LUGGAGE (Y-R ------- SPEED SENSOR DATA LINK CONNECTOR SWITCH (B-42) TSB Revision...
Seite 207 CIRCUIT DIAGRAMS - ELC-4 A/T Circuit ENGINE CONTROL MODULE PULSE GENERATOR B #i%ATOR A I L. SOLENOID VALVE TSB Revision...
Seite 208: Component Location
CIRCUIT DIAGRAMS COMPONENT LOCATION switch S C S V - B S C S V - A T C C s o l e n o i d d a t a Iin%:,, Y 16FC498...
Seite 209 CIRCUIT DIAGRAMS TSB Revision...
Seite 210 CIRCUIT DIAGRAMS BUZZER CIRCUIT (UP TO 1993 MODELS) E LINK@ IGNITION SWITCH(IG1) 20-w 1 "2 IOD OR STORAGE CONNECTOR WHEN IS RE DIODE C-08 Y-B 3 DOOR SWITCH (LH) THEFT-ALARM SYSTEM THEFT-ALARM SYSTEM...
Seite 211 CIRCUIT DIAGRAMS BUZZER CIRCUIT (FROM 1994 MODELS) FUSIBLE LINK@ IGNITION SWITCH(IG1) 0 . 8 5 IOD OR STORAGE CONNECTOR HEN KEY 1081 S REM@vFn DOOR LIGHT AND LUGGAGE COMPARTMENT LIGHT DOOR LIGHT AND LUGGAGE COMPARTMENT LIGHT RADIO AND TAPE PLAYER - - - TIMER CIRCUIT PULSE CIRCUIT...
Seite 212 CIRCUIT DIAGRAMS COMPONENT LOCATION Name Symbol Name Symbol Buzzer ETACS unit TSB Revision...
Seite 213 CIRCUIT DIAGRAMS OPERATION <Key-reminder warning> Battery positive voltage is continuously applied to the key-reminder switch. If the driver’s door is opened (door switch ON) with the key inserted in the ignition switch (key-reminder switch ON), the buzzer sounds to warn that the key has been left in the switch. When the ignition switch is turned on, the timer circuit and pulse circuit will flicker the seat belt warning light for approx.
Seite 214 CIRCUIT DIAGRAMS POWER WINDOW CIRCUIT (UP TO 1993 MODELS) LINK 9 POWER WINDOW MAIN SWITCH (E-34) ONE-TOUCH DOWN CIRCUIT 16 (E-32) (E-01) 6 - - - - 11 - - - POWER WINDOW MOTOR (E-34) (E-35) TSB Revision...
Seite 215: Door Switch
CIRCUIT DIAGRAMS - Power Window Circuit IGNI ---- R-Y 1' R ‘(c-65) (c-66) r - - - - - - - - ETACS j. UNIT / TIMER CIRCUIT -----_ (E-15) (E-21) DATA LINK CONNECTOR NOTE DOOR SWITCH TSB Revision...
Seite 216 CIRCUIT DIAGRAMS - Power Window Circuit POWER WINDOW CIRCUIT (1994 MODELS) POWER WINDOW MAIN SWITCH (E-34) ONE-TOUCH DOWN CIRCUIT ETACS UNIT I RUP (E-06) POWER WINDOW MOTOR (E-35) (E-34) TSB Revision...
Seite 217 CIRCUIT DIAGRAMS - Power -Window Circuit IOD OR STORAGE CONNECTOR TIMER CIRCUIT 6 :I (E-21) (E-15) DATA LINK CONNECTOR NOTE (c-79) FRONT SIDE (c-80) Revision...
Seite 218 CIRCUIT DIAGRAMS - Power Window Circuit POWER WINDOW- CIRCUIT (1995 MODELS) POWER WINDOW MAIN SWITCH (E-34) ONE-TOUCH DOWN CIRCUIT 1 6 ( E - 3 2 ) POWER WINDOW MOTOR (E-35) (E-06) (E-34) TSB Revision...
Seite 219 CIRCUIT DIAGRAMS IGNI CHARGING HORN *TENSION-REDUCER TYPE SEAT BELT STORAGE CONNECTOR 8 :1 MARKER LIGHT AND LICENSE PLATE LIGHT DOOR LIGHT AND COMPARTMENT LIGHT DATA LINK GHT AND LICENSE CONNECTOR *DOME LIGHTSFOOT LIGHT AND IGNITION KEY CYLINDER ILLUMINATION LIGHT NOTE DOOR SWITCH 1 2 3 4 Revision...
Seite 220 CIRCUIT DIAGRAMS POWER WINDOW CIRCUIT (FROM 1996 MODELS) NOTE POWER WINDOW MAIN SWITCH iE-34) ONE-TOUCH DOWN CLRCUIT "6 16 (E-32) ---------- ----A (E-O’ ---- -__ POWER WINDOW MOTOR TSB Revision...
Seite 221 CIRCUIT DIAGRAMS POWER WINDOWS IGNITI RELAY CHARGING TYPE SEAT BELT STORAGE (c-66) CONNECTOR TIMER CIRCUIT FOG LIGHT HEADLIGHT MARKER LIGHT AND LICENSE PLATE LIGHT DOOR LIGHT AND LUGGAGE COMPARTMENT LIGHT DOOR LIGHT LIGHT DATA LINK MARKER LIGHT AND LICENSE CONNECTOR PLATE LIGHT AND IGNITION KEY CYLINDER...
Seite 222 CIRCUIT DIAGRAMS COMPONENT LOCATION Name Symbol Name Symbol Data link connector (up to 1993 models) ETACS unit Data link connector (from 1994 models) Power window relay Revision...
Seite 223 CIRCUIT DIAGRAMS - Power Window Circuit OPERATION Turn on the ignition switch, and the transistor Tr will be turned on by the timer circuit. This will turn on the power window relay allowing the power window to be opened and closed. Turn the ignition switch from on to off, and the timer circuit will be activated to keep transistor Tr on for 30 seconds allowing the power window to be opened and closed.
Seite 224 CIRCUIT DIAGRAMS - Central Door .Locking Circuit CENTRAL DOOR LOCKING CIRCUIT (UP TO 1993 MODELS) (Vehicles without keyless entry system) BR 2-B - - - - - - - - - - - - - - - - _ ----_ -- L-B L-I L-R 2-B DOOR LOCK "...
Seite 225 CIRCUIT DIAGRAMS DOOR POWEF DATA LINK CONNECTOR BR-L E T A C : A-~------- IOD OR STORAGE CONNECTOR WITHOUT WITH WHEN KEY IS REMOVED (c-34: WITHOUT WITH @ & A L A R M 2 Y-W R-G ( (E-15) NOTE DOOR SWITCH TSB Revision...
Seite 226 CIRCUIT DIAGRAMS CENTRAL DOOR LOCKING CIRCUIT (UP TO 1993 MODELS) (Vehicles with keyless entry system) R-B R-B DOOR LOCK DOOR LOCK POWER RELAY 2 POWER RELAY 1 (E-38) B L-R 1 BR-W BR-L BR-Y (E-32) !I 1_8- 17 Ill 20 19 15 ----- -----, (E-01)
Seite 227 CIRCUIT DIAGRAMS - Central Door Locking Circuit J/B/ ' (c-74) DOME LIDHT ( A - - VEHICLES WITH C-67 THEFT-ALARM BR-W BR-L FEEDER R-B ' ANTENNA TRANSMITTER...
Seite 228 CIRCUIT DIAGRAMS - Central Door Locking Circuit CENTRAL DOOR LOCKING CIRCUIT (UP TO 1993 models) (Vehicles with keyless entry system) (CONTINUED) DATA LINK CONNECTOR ETACS UNIT TIMER CIRCUIT CONSTANT VOLTAGE 5V , R-c DOOR SWITCH (E-37) NOTE TSB Revision...
Seite 229 NOTES TSB Revision...
Seite 230: Control Unit
CIRCUIT DIAGRAMS - Central Door Locking Circuit CENTRAL DOOR LOCKING CIRCUIT (1994, 1995 MODELS) 12 (c-78) DOOR LOCK UNLOCK+ UNLOCK ( , LOCK , LOCK BR-W BR-I BR-L BR-V BR-L BR-L BR-W CONTROL UNIT TSB Revision...
Seite 231 CIRCUIT DIAGRAMS DOOR LOCK DOOR LOCK DOOR LOCK POWER RELAY 1 POWER RELAY 2 POWER RELAY 1 --- ---- L-B BR-Y LOCK LOCK DOOR LOCK --------- NOTE ETACS UNIT TSB Revision...
Seite 232 CIRCUIT DIAGRAMS CENTRAL DOOR LOCKING CIRCUIT (1994, 1995 MODELS) (CONTINUED) FUSIBLE LINK@ ACC) HORN J/B I 11 12 c-35 IOD OR STORAGE CONNECTOR LIGHT AND IGNITION KEY CYLINDER ILLUMINATION LIGHT NOTE TRANSMITTER :3 ( E - 3 7 ) TSB Revision...
Seite 233 CIRCUIT DIAGRAMS FUSIBLE LINKa DOOR LOCK ETACS UNIT IOD OR STORAGE CONNECTOR -------- LUGGAGE COMPARTMENT LIGHT G - Y VEHICLES WITHOUT THEFT-ALARM CONTROL UNIT OFF ‘1 TSB Revision...
Seite 234 CIRCUIT DIAGRAMS - Central Door Locking Circuit CENTRAL DOOR LOCKING CIRCUIT (FROM 1996 MODELS) FUSIBLE LINK@ 12 (c-78) DOOR LOCK "5 BR-W BR-I BR-L BR-L BR-W...
Seite 235 CIRCUIT DIAGRAMS DOOR LOCK DOOR LOCK DOOR LOCK POWER RELAY 1 POWER RELAY 2 POWER RELAY 1 17 ------_ 17 -----__ - - - - - - - ----- ----_ (E-32) (E-01) LOCK (E-06) BR-Y (E-10) (E-32) ------- LG-W CONTROL UNIT (E-37) NOTE ETACS UNIT...
Seite 236 CIRCUIT DIAGRAMS - Central Door Locking Circuit CENTRAL DOOR LOCKING CIRCUIT (FROM 1996 MODELS) (CONTINUED) SWITCH (ACC) J/B l R R-Y DOME LIGHT - c-35 IOD OR STORAGE CONNECTOR KEY REMINDER BUZZER DOME LIGHT.FOOT VEHICLES WITH LIGHT AND IGNITION THEFT-ALARM KEY CYLINDER ILLUMINATION LIGHT NOTE...
Seite 237 CIRCUIT DIAGRAMS FUSIBLE LINK0 ETACS UNIT (c-66) 51 STORAGE CONNECTOR LUGGAGE COMPARTMENT LIGHT R-G 1 OFF - ON - ON KEY REMINDER SWITCH THEFT-ALARM GND GND (c-58) B DATA LINK CONNI DOOR SWITCH (LH) TSB Revision...
Seite 238 CIRCUIT DIAGRAMS COMPONENT LOCATION Name Symbol Name Symbol Data link connector (from 1994 models) Door lock power relay 2 (Concerning the ve- equipped with keyless entry system.) Data link connector (up to 1993 models) ETACS unit Door lock actuator Door lock power relay 1 actuator lay2...
Seite 239 CIRCUIT DIAGRAMS - Central Door Locking Circuit OPERATION <Vehicles without keyless entry system> When the door lock switch is set to the LOCK lock knob) is locked with the key inserted in side (or UNLOCK side), the LOCK side (or the ignition switch, the ETACS unit grounds the UNLOCK side) of the door lock relay is turned unlock side circuit of the door lock relay to unlock...
Seite 240 CIRCUIT .DIAGRAMS The indicator does not blink after pressing the R.H. and L.H. doors can be locked and unlocked transmission switch of the transmitter. by the transmitter but the dome light and foot 1) Check or replace the battery. (Refer to light do not blink or come on.
Seite 241 CIRCUIT DIAGRAMS HEATER CIRCUIT (UP TO 1995 MODELS) FUSIB E IGNI LINK NOTE CHARGING 3L yEBa TAIL LIGHT, PARKING/SIDE MARKER LIGHT REAR WINDOW DEFOGGER CONTROL PANEL ILLUMINATION LIGHT BLOWER RESISTOR BLOWER RHEOSTAT MOTOR...
Seite 242 CIRCUIT DIAGRAMS - Heater Circuit HEATER CIRCUIT (FROM 1996 MODELS) IGNI SWIT (c-82) TAIL LIGHT. PARKING/SIDE MARKER LIGHT REAR WINI: low CONTROL PANEL DEFOGGER ILLUMINATION LIGHT RHEOSTAT W-B ' 2B 5 A/C SWITCH (c-19) (c-2o)(m~(c-38)~c-68)(mgl 00 [c-83) TSB Revision...
Seite 243 CIRCUIT DIAGRAMS COMPONENT LOCATION Name Symbol Name Symbol Blower motor relay Blower resistor Blower motor relay (HI) (Up to 1995 models) Revision...
Seite 244 CIRCUIT DIAGRAMS MANUAL AIR CONDITIONING CIRCUIT (1992 MODEL) FUSIBLE LINK @ IGNITION SWITCH(IG2) ASSEMBLY (A-55) "5 OFF-,> ASSEMBLY TSB Revision...
Seite 245 CIRCUIT DIAGRAMS AIR COb TIONING RADIATOR FAN MOTOR RELAYCLO) DEDICATED FUSE CONDENSER (A-36)
Seite 246 CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit MANUAL AIR CONDITIONING CIRCUIT (1992 MODEL) (CONTINUED) G-O 2 ON-OFF DUAL OFF-ON ON-OFF (A-35) COMPARISON COMPRESSOR SPEED THERMOSTAT' OPERATION CIRCUIT ON-OFF OFF-ON (B-20) G-R“3 (Y-G r----- (A-67) (G-R) RELAY AIR CONDITIONING ENGINE COOLANT ON-OFF OFF-ON -------...
Seite 247 CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit CONDITIONING COMPRESSOR LOCK CONTROLLER CIRCUIT COMBINATION (W-B Revision...
Seite 248 CIRCUIT DIAGRAMS MANUAL AIR CONDITIONING CIRCUIT (1992 MODEL) (CONTINUED) IGNI (c-19) IOFF\----------/ (c-19) (c=m (c-38) (c-39) (C-68) (c-73) FE) (C-83)
Seite 249: Air Conditioning
CIRCUIT DIAGRAMS AIR CONDITIONING COMPRESSOR LOCK BL CONTROLLER DEDICATED FUSE "2 "4 (B-R) B-Y RHEOSTAT TSB Revision...
Seite 250 CIRCUIT DIAGRAMS MANUAL AIR CONDITIONING CIRCUIT (1993 MODELS) IGNITION SWITCH(IG2) ASSEMBLY RADIATOR FAN MOTOR J (A-55) ------- ASSEMBLY TSB Revision...
Seite 251 CIRCUIT DIAGRAMS RADIATOR FAN MOTOR RELAYCLO) L -G (LO) "4 (A-31X) TSB Revision...
Seite 252 CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit MANUAL AIR CONDITIONING CIRCUIT (1993 MODELS) (CONTINUED) ON-OFF OFF-ON ON-OFF COMPARISON COMPRESSOR SPEED THERMOSTAT OPERATION CIRCUIT ON-OFF OFF-ON (Y-F 3 -------. : - - - (A-67) 3 ---_ (G-R) F )G-E MODULE AIR CONDITION ENGINE COOLAN ON-OFF --------...
Seite 253 CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit MULTI-PURPOSE FUSE @ CONDITIONING (B-R) COMPRESSOR LOCK CONTROLLER ENGINE SI COMBINATION (W-B IGNITION POWER TRANSISTOR TSB Revision...
Seite 254 CIRCUIT DIAGRAMS MANUAL AIR CONDITIONING CIRCUIT (1993 MODELS) (CONTINUED) ITCH BLOWER RESISTOR BLOWER MOTOR ----------...
Seite 255 CIRCUIT DIAGRAMS - Manual Air Conditionina Circuit CONDITIONING COMPRESSOR LOCK g6' CONTROLLER G-WI (G-Y RHEOSTAT...
Seite 256 CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit MANUAL AIR COiDlTlONlNG CIRCUIT (1994, 1995 MODELS) <NON TURBO> (FEDERAL) J/B @ REAR WINDOW DEFOGGER RADIATOR - x., 11 .-------------------------- 11 -------. ASSEMBLY (RESISTOR) (A-55) MFI SYSTEM '2 ---- ENGINE CONTROL MODULE...
Seite 257 CIRCUIT DIAGRAMS AIR CONDITIONING ULTI JRPOSE COMPRESSOR LOCK FUSE ( CONTROLLER r---- 1 WATED 1 -_--____--_______ (A-37) (A-45) (A-46) TSB Revision...
Seite 258 CIRCUIT DIAGRAMS MANUAL AIR CONDITIONING CIRCUIT (1994, 1995 MODELS) <NON TURBO> (FEDERAL) (CONTINUED) G-O 2 ON-OFF CONDITIONING OFF-ON COMPARISON COMPRESSOR SPEED THERMOSTAT OPERATION CIRCUIT ON-OFF OFF-ON (Y-R (Y-G: (A-67) (F> L-------- (B-20) (B-20) (c-02) TSB Revision...
Seite 259 CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit CONDITIONING MULTI-PURPOSE FUSE @ SWITCH (B-R) CONDITIONING COMPRESSOR LOCK CONTROLLER IRCUIT 10 @KJ (G-Y: COMBINATION IGNITION POWER TRANSISTOR HR 12M03BB...
Seite 260 CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit MANUAL AIR CONDITIONING CIRCUIT (1994, 1995 MODELS) <NON TURBO> (FEDERAL) (CONTINUED) REAR WINDOW DEFOGGER BLOWER RESISTOR “ 4 2 B ’ W-B ' TSB Revision...
Seite 261 CIRCUIT DIAGRAMS AIR CONDITIONING DEDICATED MULTI-PURPOSE FUSE FUSE 0 CONDITIONING SWITCH MARKER AND LI( IGHT RHEOSTAT...
Seite 262 CIRCUIT DIAGRAMS MANUAL AIR CONDITIONING CIRCUIT (1994, 1995 MODELS) <TURBO, NON TURBO (CALIFORNIA)> SWITC (c-69) RADIATOR ---------- ENGINE COOLANT 12 (c-31) 1.258 ASSEMBLY (RESISTOR) I---- (A-55) MFI SYSTEM ENGINE CONTROL MODULE TSB Revision...
Seite 263 CIRCUIT DIAGRAMS ONING JRPOSE LOCK FUSE ( ---- CONDENSER ------- ----------------- .------...
Seite 264 CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit MANUAL AIR CONDITIONING CIRCUIT (1994, 1995 MODELS) <TURBO, NON TURBO (CALIFORNIA)> (CONTINUED) THERMOSTAT ION CIRCUIT ON-OFF OFF-ON 110’ (Y-R (Y-G 3 ---- (G-R) ENGINE CONTROL MODULE TSB Revision...
Seite 265 CIRCUIT DIAGRAMS MULTI-PURPOSE FUSE @ AIR CONDITIONING COMPRESSOR LOCK CONTROLLER CIRCUIT 10 (c-40) (W-B (G-k (D-42) COMBINATION (D-15) IGNITION POWER TRANSISTOR...
Seite 266 CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit MANUAL AIR CONDITIONING CIRCUIT (1994, 1995 MODELS) <TURBO, NON TURBO (CALIFORNIA)> (CONTINUED) FUSIB E IGNI LINK 6 b REAR WINDOW DEFOGGER BLOWER MOTOR (c-39)
Seite 267 CIRCUIT DIAGRAMS IONING CONTROL: MULTI FUSE ( (G-Y TAIL LIGHT, PARKING/SIDE MARKER LIGHT AND LICENSE PLATE LIGHT "2 "4 (B-R) (G-Y CIGARETTE LIGHTER RHEOSTAT TSB Revision...
Seite 268 CIRCUIT DIAGRAMS MANUAL AIR CONDITIONING CIRCUIT (FROM 1996 MODELS) IGNITION (c-69) ASSEMBLY RADIATOR FAN MOTCR ) REAR WINDOW ENGINE COOLANT 11 ~-~----------------~______ SENSOR 11 -------. RADIATOR 1.256 ASSEMBLY (RESISTOR) (A-55) MFI SYSTEM 2 ---- ----------- TSB Revision...
Seite 269 CIRCUIT DIAGRAMS ULT: JRPOSE FUSE CONDENSER --------------- (Hi) (LO) OFF-&IN "4 (A-31X) (A-361 TSB Revision...
Seite 270 CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit MANUAL AIR CONDITIONING CIRCUIT (FROM 1996 MODELS) (CONTINUED) ON-OFF DUAL CONDITIONING OFF-ON COMPRESSOR LOCK ON-OFF 5 CONTROLLER OFF-ON COMPARISON (Y-R: (Y-G: 10 _-_-- (B-20) (G-R) ------- ENGINE (A-67)
Seite 271 CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit MULTI-PURPOSE FUSE @ (B-R) CONDITIONING COMPRESSOR LOCK CONTROLLER CIRCUIT ENGINE Si (W-E (G-k COMBINATION (W-B IGNITION POWER TRANSISTOR...
Seite 272 CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit MANUAL AIR CONDITIONING CIRCUIT (FROM 1996 MODELS) (CONTINUED) IGNI' HORN REAR WINDOW DEFOGGER BLOWER RESISTOR (c-19) rFjr-.--------a...
Seite 273 CIRCUIT DIAGRAMS TAIL LIGHT. PARKING/SIDE MARKER LIGHT AND LICENSE PLATE LIGHT ILLUMINATION LIGHT CIGARETTE LIGHTER RHEOSTAT TSB Revision...
Seite 274 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (1992 MODEL) IGNITION SWITCH(IG2) ------- RESISTOR ASSEMBLY...
Seite 275 CIRCUIT. DIAGRAMS CONDITIONING COMPRESSOR LOCK RADIATOR FAN CONTROLLER MOTOR RELAYCLO) L---- / 2L-F ------- ( L O ) ---------------- (A-36) TSB Revision...
Seite 276 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (1992 MODEL) (CONTINUED) G - O 2 ON-OFF OFF-ON COMPARISON THERMOSTAT ON ( G-R 3 (Y-R: (Y-G G-R I -------- (A-36) > (G-R) TRANSAXLE CONDITIONING REVOLUTION SENSOR TSB Revision...
Seite 277 CIRCUIT DIAGRAMS MULTI-PURPOSE FUSE @ CONDITIONING COMPRESSOR LOCK CONTROLLER (W-B (G-Y: COMBINATION POWER TRANSISTOR TSB Revision...
Seite 278: Control Unit
CIRCUIT DIAGRAMS - Full Auto Air Conditioning Circuit FULL AUTO AIR CONDITIONING CIRCUIT (1992 MODEL) (CONTINUED) IGNITION RELAY '3 (c-83) IOD OR STORAGE CONNECTOR 1 k?! E R c-23) "2 "4 (c-51) AIR CONDITIONING CONTROL UNIT...
Seite 279 CIRCUIT DIAGRAMS CONDITIONING PHOTO CONTROL. PANEL SENSOR (Y-C 10 .---_ (Y-G CONTROL UNIT DATA LINK AIR SELECTION CONNECTOR TSB Revision...
Seite 280 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (1992 MODEL) (CONTINUED) CONDITIONING TAILLIGHT RELAY CONTROL PANEL :---- (R-B (W-E (L-B: "5 (c-83) 10 ---- 7 .---_ (Y-R) OFF-ON: B (Y-E...
Seite 281 CIRCUIT DIAGRAMS INTERIOR (F-01 (Y-L 56 (c-17) (F-34: (W-R: (B-W (Y-L AIR CONDITIONING ---- ---- CONTROL UNIT ------ ---- B-W (L-W) (W-L R-G 1 B-W j(L-W) (W-l CONTROL MOTOR MOTOR (c-51) TSB Revision...
Seite 282 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (1993 MODELS) IGNITION SWITCH(IG2) ASSEMBLY LL ------- ASSEMBLY...
Seite 283 CIRCUIT DIAGRAMS CONDITIONING COMPRESSOR LOCK CONTROLLER RADIATOR CONDENSER RELAY (HI) (Lo) "4 (A-31X) (A-34X) "4 " 5 ---------------- TSB Revision...
Seite 284 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (1993 MODELS) (CONTINUED) COMPARISON . 2 9 (Y-R (Y-G: G-R 3 10 .---- ----- Y-I; (G-R) ------- -- MODULE AIR CONDITIONING , , ENGINE COOLANT "1 "5 OFF ' ON-OFF OFF-ON TSB Revision...
Seite 285 CIRCUIT DIAGRAMS POWER SOURCE 10 (c-40) (W-E (G-Y COMBINATION IGNITION POWER TRANSISTOR (G-Y 36 (c-51) UNIT TSB Revision...
Seite 286 CIRCUIT DIAGRAMS - Full Auto Air Conditioning Circuit FULL AUTO AIR CONDITIONING CIRCUIT (1993 MODELS) (CONTINUED) IGNITION RELAY IOD OR STORAGE CONNECTOR .--- CONDITIONING CONTROL UNIT...
Seite 287 CIRCUIT DIAGRAMS CONDITIONING PHOTO CONTROL PANEL SENSOR (Y-W) (Y-G) (Y-W) (Y-G) T UNIT AIR SELECTION DATA LINK CONNECTOR (c-28) TSB Revision...
Seite 288 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (1993 MODELS) (CONTINUED) AIR CONDITIONING CONTROL PANEL TAILLIGHT RELAY ---- ---- (R-B (W-E (L-E (L-Y 7 ---------- ---- (Y-R) RHEOSTAT ENGINE COOLANT OFF-ON: (c-43)
Seite 289 CIRCUIT DIAGRAMS INTERIOR DISPLAY 1 (L-W ---- 56 (c- (F-34 (W-R (B-G: (B-R (B-W (Y-L (L-W 1 - - CONDITIONING 6 .---- 15 ---- (c-49: ------- ---- CONTROL UNIT ---- ----- ----------_- (L-G) (L-G) CONTROL MOTOR MOTOR (c-17) (c-51) (F-01) F-TZ)
Seite 290 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (1994, 1995 MODELS) <NON TURBO> (FEDERAL) IGNITION FUSIB E LINK Q J/B @ ENGINE COOLANT SENSOR ASSEMBLY (RESISTOR) (A-55) MFI SYSTEM...
Seite 291 CIRCUIT DIAGRAMS ULTI JRPOSE FUSE ( CONTROL r---- CONDENSER ------- _---_------------ .-----_ (A-36) I TSB Revision...
Seite 292 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (1994, MODELS) <NON TURBO> (FEDERAL) (CONTINUED) ON-OFF DUAL CONDITIONING OFF-ON COMPRESSOR LOCK ON-OFF OFF-ON COMPARISON THERMOSTAT ON-OFF OFF-ON (Y-R (Y-G: 3 ---- (A-67) (G-R) MAGNET CLUTCH RELAY (B-20) (c-5: ENGINE CONTROL MODULE TSB Revision...
Seite 293: Air Conditioning
CIRCUIT DIAGRAMS MULTI-PURPOSE FUSE @ AIR CONDITIONING COMPRESSOR LOCK CONTROLLER 1 0 (c-40) (W-E (G-Y COMBINATION IGNITION POWER TRANSISTOR 8 .-----_ UNIT TSB Revision...
Seite 294 CIRCUIT DIAGRAMS - Full Auto Air Conditioning Circuit FULL AUTO AIR CONDITIONING CIRCUIT (1994, 1995 MODELS) <NON TURBO> (FEDERAL) (CONTINUED) RELAY "3 "3 (c-82) R-Y R IOD OR STORAGE CONNECTOR REAR WINDOW DEFOGGER POWER TRANSISTOR ,.3 "1 (c-51) 101 ------- -- CONDITIONING CONTROL UNIT (c-68) (c-70) (c-73) (c-77)
Seite 295 CIRCUIT DIAGRAMS CONDITIONING PHOTO CONTROL PANEL (c-17) SENSOR 54 "57 ( Y - h 10 -_-. (R-h G-R) (G-B (Y-G 6 9 (c-49) 3 --_ 1 --- 2 --- 13 --- 70 ---- --------- ----_-_ CONDITIONING MFI SYSTEM DOOR LIGHT AND DATA LINK AIR SELECTION CONNECTOR...
Seite 296 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (1994, 1995 MODELS) <NON TURBO> (FEDERAL) (CONTINUED) AIR CONDITIONING TAILLIGHT RELAY CONTROL PANEL AIR CONDITIONING GRAPHIC ----- --___ (c-16) (R-B) (W-B) (L-B: 19 .--- 20 --. 9 --. ----- ---- ----- ----_ TAIL LIGHT.PARKING/SIDE MARKER LIGHT AND LICENSE PLATE LIGHT 67 AIR...
Seite 297 CIRCUIT DIAGRAMS INTERIOR AIR CONDITIONING CONTROL PANEL DISPLAY NOTE (Y-L (Y-L) (B-R (B-W (L-W (Y-L (Y-L) (c-49) ----- ---- ------ B-W (L-h (W-L) (L-G R-Y [ G-L 1 MOTOR...
Seite 298 CIRCUIT DIAGRAMS - Full Auto Air Conditioning Circuit FULL AUTO AIR CONDITIONING CIRCUIT (1994, 1995 MODELS) <TURBO, NON TURBO (CALIFORNIA)> IGNI'I SWITC J/B @ (c-69) RADIATOR A - - - - ENGINE COOLANT 11 --------------------------- SENSOR 11 --___--. ASSEMBLY (RESISTOR) (A-55) MFI SYSTEM Revision...
Seite 299 CIRCUIT DIAGRAMS ULTI JRPOSE FUSE ( CONTROL: ---- - CONDENSER ------- "4 CONNECTION 3 -- (A-36) TSB Revision...
Seite 300 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (1994, MODELS) 1995 <TURBO, NON TURBO (CALIFORNIA)> (CONTINUED) COMPARISON THERMOSTAT ION C ON-OFF OFF-ON (B-20) (Y-R (Y-G: 10 ----- r---- (A-67) DEDICATED FUSE (G-R) RELAY ENGINE CONTROL MODULE TSB Revision...
Seite 301 CIRCUIT DIAGRAMS IGNITION POWER TRANSISTOR TSB Revision...
Seite 302 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (1994, 1995 MODELS) <TURBO, NON TURBO (CALIFORNIA)> (CONTINUED) HORN REAR WINDOW DEFOGGER MFI SYSTEM...
Seite 303 CIRCUIT DIAGRAMS 69 (c-49) MFI SYSTEM DOOR LIGHT AND TSB Revision...
Seite 304 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (1994, 1995 MODELS) <TURBO, NON TURBO (CALIFORNIA)> (CONTINUED) ---- 7 -____-_-__ (c-15 MARKER LIGHT AND LICENSE PLATE LIGHT (c-43) NOTE...
Seite 305 CIRCUIT DIAGRAMS NOTE 5 ---- 111 60 TSB Revision...
Seite 306 CIRCUIT DIAGRAMS MFI SYSTEM...
Seite 307 CIRCUIT DIAGRAMS (A-36) TSB Revision...
Seite 308 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (FROM 1996 MODELS) (CONTINUED) ON-OFF OFF-ON ON-OFF ON-OFF OFF-ON ( B - 2 0 ) TSB Revision...
Seite 309 CIRCUIT DIAGRAMS IGNITION POWER TRANSISTOR TSB Revision...
Seite 310 CIRCUIT DIAGRAMS FULL AUTO AIR CONDITIONING CIRCUIT (FROM 1996 MODELS) (CONTINUED) HORN REAR WiNDOW DEFOGGER MFI SYSTEM...
Seite 311 CIRCUIT DIAGRAMS MFI SYSTEM DOOR LIGHT AND...
Seite 312 CIRCUIT DIAGRAMS - Full Auto Air Conditioning Circuit FULL AUTO AIR CONDITIONING CIRCUIT (FROM 1996 MODELS) (CONTINUED) "5 (c-83) TAIL LIGHT,PARKING/SIDE MARKER LIGHT AND LICENSE PLATE LIGHT NOTE TSB Revision...
Seite 313 CIRCUIT DIAGRAMS ( E - 4 9 ) - - - - - - ------ NOTE TSB Revision...
Seite 314 CIRCUIT DIAGRAMS COMPONENT LOCATION Name Symbol Name Symbol Air conditioning compressor lock controller I Dual pressure switch Air conditioning control unit Engine control module Air-inlet sensor Engine coolant temperature sensor Engine coolant temperature switch* Blower motor relay Interior temperature sensor Blower motor relay (HI) Magnetic clutch relay Condenser fan motor relay (HI)
Seite 315 CIRCUIT DIAGRAMS - Full Auto Air Conditioning Circuit control module control module Xl 6FO292...
Seite 316: Component Location
CIRCUIT DIAGRAMS Interior temperature sensor COMPONENT LOCATION Data link connector TSB Revision...
Seite 317: Troubleshooting Hints
CIRCUIT DIAGRAMS OPERATION <Auto wiper stop> When the wipe: switch is placed in the OFF <Low-speed (and high-speed) wiper> position, the cam contacts of wiper motor causes When the wiper switch is placed in the LO current to flow through the auto wiper stop position with the ignition switch in the ACC or circuit, allowing the wiper blades to cycle before ON position, wipers operate continuously at low...
Seite 318 CIRCUIT DIAGRAMS HORN 15Ab NOTE THEFT-ALARM SYSTEM LIGHTER WASHER SWITCH 1 WIPER RELAY WIPER SWITCH TSB Revision...
Seite 319 CIRCUIT DIAGRAlViS CHARGING DOOR LIGHT AND LUGGAGE TURN-SIGNAL LIGHT AND HAZARD LIGHT NOTE THEFT-ALARM SYSTEM g THEFT-ALARM SYSTEM 2 NOTE DATE LINK POWER SOURCE CIRCUIT AND GROUND CIRCUIT ARE APPLICABLE FROM 1994 MODELS Revision...
Seite 320 CIRCUIT DIAGRAMS ( c - 8 2 ) GLOVE BOX LIGHT RHEOSTAT TSB Revision...
Seite 321 CIRCUIT DIAGRAMS COMPONENT LOCATION OPERATION TROUBLESHOOTING HINTS <Auto wiper stop> <Intermittent wiper>...
Seite 322 CIRCUIT DIAGRAMS - Remote Controlled Mirror Circuit MFI SiSTEM "7 "8 "2 j‘9 L - - - - - - - - - - _ _ _ _ _ “r12 “13 ( D - 4 3 ) ‘g------ (E-01) HEATER...
Seite 323 CIRCUIT DIAGRAMS - Remote Controlled Mirror Circuit TROUBLESHOOTING HINTS OPERATION...
Seite 324 CIRCUIT DIAGRAMS TSB Revision...
Seite 325 CIRCUIT DIAGRAMS 3 :---------------- (D-45)
Seite 326: Speed Sensor
CIRCUIT DIAGRAMS ANTI-LOCK BRAKING SYSTEM (ABS) CIRCUIT (UP TO OCTOBER, 1993) 1 ------. NOTE...
Seite 328 CIRCUIT DIAGRAMS SOLENOID VALVE - - - - - - - - - - - - - - -...
Seite 329 CIRCUIT DIAGRAMS HORN - - - - - - - - - - - - - - TURN-SIGNAL B- LIGHT AND STOP LIGHT LUGGAGE SUSPENSION (D-16) NOTE CONTROL SYSTEM. CRUISE CONTROL SYSTEM. STOP LIGHT...
Seite 330 CIRCUIT DIAGRAMS ANTI-LOCK BRAKING SYSTEM (ABS) CIRCUIT (FROM NOVEMBER, 1993) SUSPENSION NOTE 1 [ 2 13 14 15 16 17 j 6 [ 9 ~10(11~12~13~14~15(16(17(18...
Seite 331 NOTES TSB Revision...
Seite 332 CIRCUIT DIAGRAMS D VA1.VE OFF‘ ----- - - - - 11 ----- 1. 25G-I...
Seite 333 CIRCUIT DIAGRAMS r 63 CHARGING TURN-SIGNAL STOP LIGHT LIGHT (F-46) LUGGAGE COMPARTMENT LIGHT STOP LIGHT (D-16) (F-44) SUSPENSION...
Seite 334 CIRCUIT DIAGRAMS ANTI-LOCK BRAKING SYSTEM (ABS) CIRCUIT (1995 MODELS) 1 mm (E-12) SUSPENSION ------...
Seite 335 TSB Revision...
Seite 336 CIRCUIT DIAGRAMS SOLENOID VALVE / I TSB Revision...
Seite 337: Stop Light
CIRCUIT DIAGRAMS ( L - R ) (c-69) (D-45) (D-16)
Seite 338 CIRCUIT DIAGRAMS ANTI-LOCK BRAKING SYSTEM (ABS) CIRCUIT (UP TO OCTOBER, 1993) NOTE...
Seite 339 NOTES...
Seite 340 CIRCUIT DIAGRAMS SOLENOID VALVE OWER SUPPLY...
Seite 341 CIRCUIT DIAGRAMS TURN-SIGNAL WARNING LIGHT AND LIGHT ( c - 6 2 ) STOP LIGHT 0.85 LUGGAGE (D-16) NOTE CONTROL SYSTEM. CRUISE CONTROL SYSTEM. SUSPENSION STOP LIGHT...
Seite 342 CIRCUIT DIAGRAMS ANTI-LOCK BRAKING SYSTEM (ABS) CIRCUIT (FROM NOVEMBER, 1993) (A-29) (A-12) (E-16) MFI SYSTEM NOTE TSB Revision...
Seite 343 NOTES TSB Revision...
Seite 344 Anti-lock Braking System (ABS) CIRCUIT DIAGRAMS (c-69) TSB Revision...
Seite 345 Anti-lock Braking System (ABS) CIRCUIT DIAGRAMS TURN-SIGNAL LIGHT AND (F-46) LUGGAGE COMPARTMENT LIGHT (D-16) (F-44) SUSPENSION 2 3 4 5 6 7 B 9 101112131415161716 ‘ 1 TSB Revision...
Seite 346 CIRCUIT DIAGRAMS ANTI-LOCK BRAKING SYSTEM (ABS) CIRCUIT (1995 MODELS) <AWD> (CONVERTIBLE) (CONTINUED) (A-29) (A-12) 6 ----- (c-33) 2---- SUSPENSION . Ev- A"To MFI SYSTEM (F-44)
Seite 347 NOTES...
Seite 348 CIRCUIT DIAGRAMS - - - - - - - - - (A-64) TSB Revision...
Seite 349 CIRCUIT DIAGRAMS - Anti-lock Braking System (ABS) Circuit CHARGING HORN r : c TURN-SIGNAL B- LIGHT (c-61) DOOR LIGHT LUGGAGE COMPARTMENT LIGHT NOTE CONTROL SYSTEM. CRUISE CONTROL SYSTEM.
Seite 350 CIRCUIT DIAGRAMS ANTI-LOCK BRAKING SYSTEM (ABS) CIRCUIT (FROM 1996 MODELS) (CONTINUED) TSB Revision...
Seite 351 CIRCUIT DIAGRAMS COMPONENT LOCATION 00002666 Revision...
Seite 352 CIRCUIT DIAGRAMS Diode (ABS circuit) Data link connedtor” TSB Revision...
Seite 353 NOTES...
Seite 354 CIRCUIT DIAGRAMS (F-13) - - - - - - - - - - - - - - - - - - - - - - - ---------------------------- ------ ,,6 W-O 1o W-B 11...
Seite 355 CIRCUIT DIAGRAMS ------------- -------------- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - TSB Revision...
Seite 356: Control Unit
CIRCUIT DlAGRAMS ELECTRONIC CONTROL SUSPENSION (ECS) CIRCUIT (UP TO 1993 MODELS) (CONTINUED) 6 ---_ (A-13) , ,2 - - - - 15 .---_ 13 ---- 4 ---- 2 ---- Revision...
Seite 357 TSB Revision...
Seite 358 CIRCUIT DIAGRAMS - Electronic Control Suspension (ECS) Circuit (1994 MODELS) 9 ~10~11~12~13j14/15~16 (D-06) (D-41) ( D - 4 4 ) (F-20)
Seite 359 CIRCUIT DIAGRAMS - Electronic Control Suspension (ECS) Circuit ---- --2 TSB Revision...
Seite 360 CIRCUIT DIAGRAMS - Electronic Control Suspension (ECS) Circuit ELECTRONIC CONTROL SUSPENSION (ECS) CIRCUIT (1994 MODELS) (CONTINUED) 6 --- 4 ----- (A-13) ---- ---- 13 _---- 15 ---- 14 (F-20) <ON TSB Revision...
Seite 361 NOTES...
Seite 362 CIRCUIT DIAGRAMS MFI SYSTEM (F-13) (D-44) AND HAZARD LIGHT SYSTEM ( D - 0 6 ) ( D - 1 6 ) ( D - 4 1 ) ( F - 1 2 ) ( F - 2 0 ) TSB Revision...
Seite 363 CIRCUIT DIAGRAMS NOTE FEDERAL) FOR CALIFORNIA) MFI SYSTEM (c-83: REAR WINDOW DEFOGGER COMPART- MENT LIGHI MFI SYSTEM TSB Revision...
Seite 364 CIRCUIT DIAGRAMS ELECTRONIC CONTROL SUSPENSION (ECS) CIRCUIT (1995 MODELS) <HATCHBACK> (CONTINUED) (A-25) (A-13) 6 ---. ----- 52 (F-13) 14 (F-20) 1 ----- 2 ----...
Seite 365 NOTES TSB Revision...
Seite 366 CIRCUIT DIAGRAMS <CONVERTIBLE> (F-13) 62 ---------------------------- -----_ “14 (F-44) 14 13 . TURN-SIGNAL LIGHT (F-48) t+--:+---J AND HAZARD LIGHT METER AND GAUGES SYSTEM SIDE TSB Revision...
Seite 367 NOTE FEDERAL) FOR CALIFORNIA) WITH AUTO-CRUISE MFI SYSTEM (c-83; ( B - 0 5 ) REAR WINDOW DEFOGGER MFI SYSTEM r------ STOP LIGHT 19 (F-48) COMPART- MENT LIGHT METER AND GAUGES ( c - 1 4 ) ::6...
Seite 368 CIRCUIT DIAGRAMS - Electronic Control Suspension (ECS) Circuit ELECTRONIC CONTROL SUSPENSION (ECS) CIRCUIT (1995 MODELS) <CONVERTIBLE> (CONTINUED) (A-13) Revision...
Seite 369 CIRCUIT DIAGRAMS COMPONENT LOCATION Name Symbol Name Symbol Data link connector (from 1994 models) G sensor Data link connector (up to 1993 models) Steering wheel angle speed sensor ECS control unit Throttle position sensor Engine control module 00002609 Steering wheel sensor angle speed module...
Seite 370 CIRCUIT DIAGRAMS...
Seite 371 CIRCUIT DIAGRAMS Name Symbol Name Symbol Active exhaust control unit Engine control module Actuator assembly Power window relay 00002666 module...
Seite 372 CIRCUIT DIAGRAMS SPOR ( D - 3 8 ) OFF -TON Revision...
Seite 373 CIRCUIT DIAGRAMS 3 4 5 6 5 6 7 9 9 TSB Revision...
Seite 374 CIRCUIT DIAGRAMS (c-71) (D-44) SPOR OFF ‘TON ‘OUR Revision...
Seite 375 CIRCUIT DIAGRAMS - Active Exhaust System Circuit CONTROL TSB Revision...
Seite 376 CIRCUIT DIAGRAMS SAFING (D-25 0.85 0. 85' 0.851 ----- 0. 851 (A-38)
Seite 377 CIRCUIT DIAGRAMS (c-77) to GROUP 52B- TSB Revision...
Seite 378 CIRCUIT DIAGRAMS LUGGAGE COMPARTMENT LIGHT WITH WITHOUT . Ef~#NG TSB Revision...
Seite 379 CIRCUIT DIAGRAMS 0 - w TURN-SIGNAL LIGHT AND HAZARD LIGHT (c-82) (c-82) (D-04) (D-05) SIDE TSB Revision...
Seite 380 CIRCUIT DIAGRAMS COMPONENT LOCATION Name Name Data link connector (from 1994 models) Front impact sensor Data link connector (up to 1993 models) SRS diagnosis unit TSB Revision...
Seite 381: Component Location
CIRCUIT DIAGRAMS COMPONENT LOCATION Name Symbol Name Symbol Auto-cruise control unit Data link connector (up to 1993 models) Auto-cruise relay Engine control module Data link connector (from 1994 models) Throttle position sensor control unit Data linkconnector J TSB Revision...
Seite 382 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <M/T> <M/T> TSB Revision...
Seite 383 CIRCUIT DIAGRAMS IGHT IGNITION LINK @ 1. 25R-ii DEDICATED FUSE IOD OR STORAGE CONNECTOR (A-11X) AUTO-CRUISE CONTROL UNIT (c-37) MAIN SWITCH (D-32) "4 "1 RHEOSTAT (c-37) (c-77) TSB Revision...
Seite 384 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <M/T> AUTO-CRUISE CONTROL CIRCI IIT (UP TO 1993 MODELS) <M/T> (CONTINUED) MULTI-PURPOSE MULTI-PURPOSE FUSE@ LG-R LG-B LG-B ------------ ,,14 (c-02) LG-B (D-41) VACUUM PUMP (A-28) STOP LIGHT LG-B --- ------ ------ LG-I AUTO-CRUISE CONTROL UNIT (D-05) TSB Revision...
Seite 385 NOTES...
Seite 386 CIRCUIT DIAGRAMS <M/T> NON TURBO (FEDERAL) 1 EEzL IGNITION THROTTLE (B-05) IOD OR STORAGE CONNECTOR RADIO AND BR-R 13 TAPE PLAYER BR-R 5 AUTO-CRUISE CONTROL UNIT PEDAL SWITCH OF;-"ON CLOCK SPRING...
Seite 387 CIRCUIT DIAGRAMS FUSIBLE LINK@ HORN - - - - - - ---- (c-83) (c-71) "7 (c-77) R-B R-Y i R G-WI B-WI CONNECTOR m AUTO-CRUISE CONTROL UNIT DDOR LIGHT AND LUGGAGE SUSPENSION TAPE PLAYER RHEOSTAT 2B SPEED SENSOR TSB Revision...
Seite 388 CIRCUIT DIAGRAMS AUTO-CRUISE CONTROL CIRCUIT (1994, 1995 MODELS) <M/T> NON TURBO (FEDERAL) (CONTINUED) MAIN MULTI-PURPOSE MULTI-PURPOSE FUSE@ SWITCH L - B TURN-SIGNAL LIGHT AND HAZARD LIGHT (D-42) LG-R LG-B LG-B SYSTEM (D-41) LG-B AUTO-CRUISE CONTROL UNIT (D-05) (D-42)
Seite 389 NOTES TSB Revision...
Seite 390 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit d/T> J/B &, THROTTLE (B-05) CONNECTOR BR-R 13 RADIO AND TAPE PLAYER BR-R AUTO-CRUISE CONTROL UNIT -------- CLOCK SPRING (c-29)
Seite 391 CIRCUIT DIAGRAMS FUSIBLE LINKQ NOTE HORN . MFI SYSTEM . FULL AUTO A/C CONNECTOR (A-11x) ELECTRONIC CONTROL SUSPENSION AUTO-CRUISE CONTROL UNIT MAIN SWITCH DOOR LIGHT AND LUGGAGE COMPARTMENT LIGHT MANUAL A/C (c-15: MFI SYSTEM RADIO AND TAPE PLAYER . E;$W$;TE DATA S P E E D SENSOR...
Seite 392 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit 4Vb AUTO-CRUISE CONTROL CIRCUIT (1994, 1995 MODELS) <M/T> TURBO, NON TURBO (CALIFORNIA) (CONTINUED) MULTI-PI JRPOSE 13 L-R TURN-SIGNAL LIGHT AND HAZARD LIGHT r -P (D-42) LG-R (D-05) OFF ‘J,[ ---- SYSTEM (D-41) LG-B AUTO-CRUISE CONTROL UNIT (D-05) TSB Revision...
Seite 393 NOTES TSB Revision...
Seite 394 CIRCUIT DIAGRAMS IGNITION THROTTLE IOD OR STORAGE CONNECTOR BR-R 13 RADIO AND TAPE PLAYER BR-R 5 AUTO-CRUISE CONTROL UNIT (c-37) G N D SWITCH TSB Revision...
Seite 395 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit 4/T> IGNITION FUSIBLE LINKa 2R-W: NOTE HORN J/B [ 'HEATER CONNECTOR (A-11X) AUTO-CRUISE CONTROL UNIT METER AND GAUGES B-1 . COOLING . MANUAL A/C (c-15 . MFI SYSTEM . RADIO AND TAPE PLAYER . E;;/WiE;TE RHEOSTAT 2B SPEED SENSOR...
Seite 396 CIRCUIT DIAGRAMS AUTO-CRUISE CONTROL CIRCUIT (FROM 1996 MODELS) <M/T> (CONTINUED) MAIN MULTI-PURPOSE MULTI-PI JRPOSE SWITCH (D-42) LG-R (D-05) LG-B LG-B "4 LG-B AUTO-CRUISE CONTROL UNIT TSB Revision...
Seite 397 NOTES TSB Revision...
Seite 398 CIRCUIT DIAGRAMS CONTROL MODULE BR-R G-Y 1.25B - - - - THROTTLE 2L 1 BR-R 2Y-R IOD OR STORAGE CONNECTOR AUTO-CRUISE CONTROL UNIT SWITCH CONNEC TSB Revision...
Seite 399 CIRCUIT DIAGRAMS IGNITION FUSIBLE LINK a (c-83: R-Y r' R CONNECTOR (A-11X) AUTO-CRUISE CONTROL UNIT O F F - ON (c-15) RHEOSTAT SPEED SENSOR...
Seite 400 CIRCUIT DIAGRAMS AUTO-CRUISE CONTROL CIRCUIT (1992 MODEL) <m> (CONTINUED) MAIN MULTI' -PURPOSE MULTI-PURPOSE MULTI-PI JRPOSE SWITCH FUSEq 3 FUSE@ RELAY (D-42) LG-R (D-05) COMBINATION _________ METER OFF -*ON LG-B (D-41) STOP LIGHT LG-B LG-R (c-37) AUTO-CRUISE CONTROL UNIT (D-05) (A-28) TSB Revision...
Seite 401 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit CA/T> IGNITION 20-Y PARK/NEUTRAL (B-26) 3 .------ BR-R AUTO-CRUISE CONTROL UNIT (c-37) TSB Revision...
Seite 402 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit c/VT> IGNITION THROTTLE 10 (c-83) IOD OR STORAGE CONNECTOR BR-R l3 BR-R Y-I: AUTO-CRUISE'CONTROL UNIT "6 -------- 4 (c-57) CLOCK SPRING Y-B W-R SWITCH CONNECTOR (c-53) (c-57) TSB Revision...
Seite 403 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <Ah FUSIBLE LINKa DEDICATED FUSE IOD OR STORAGE CONNECTOR (A-11X) O F F - DN COMBINATION...
Seite 404 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit dW> AUTO-CRUISE CONTROL CIRCUIT (1993 MODELS) <A/T> (CONTINUED) MULTI-PURPOSE MULTI-PURPOSE MULTI-PI FUSE@ r 0 2 9 0 LG-R (D-05) STOP COMBINATION METER ----------- O F F ‘ O N LG-B (D-41) VACUUM LG-R PUMP (A-28) STOP LIGHT...
Seite 405 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <A/T> MODULE BATTERY 11 (B-30) 15 .-- STARTER A‘ AUTO-CRUISE CONTROL UNIT (c-37) TSB Revision...
Seite 406 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit c/Vi’> IGNITION "lo (c-83) " 4 2L 1 2L IOD OR STORAGE CONNECTOR RADIO AND TAPE PLAYER BR-R 20 (c-37) AUTO-CRUISE CONTROL UNIT 1 2 3 4...
Seite 407 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <A/T> IGNITION FUSIBLE LINKa HORN I O-GE CONNECTOR (A-11X) 'MANUAL A/C SUSPENSION AUTO-CRUISE CONTROL UNIT 5" MAIN SWITCH (D-32) SUSPENSION LUGGAGE "4 METER AND GAUGES B - Y MANUAL A/C FULL AUTO A/C RADIO AND TAPE PLAYER RHEOSTAT 2B SPEED...
Seite 408 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <AiT> AUTO-C MAIN SWITCH TURN-SIGNAL LIGHT AND HAZARD LIGHT RELAY (D-42) (D-05) COMBINATION METER 5’ ---- CONNECTION SYSTEM (D-41) LG-B LIGHT SUSPENSION AUTO-CRUISE CONTROL UNIT TSB Revision...
Seite 409 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <A/T> IGNI TION (c-47) L-I; "lo (c-29) PARK/ NEUTRAL OVER DRIVE AND POWER/ OFF ‘00 L-I; 15 ---____---_ SYSTEM SUPPLEMENTAL AUTO-CRUISE CONTROL UNIT TSB Revision...
Seite 410 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <AIT> IGNITION ENGINE CONTROL MODULE MFI SYSTEM 10 (c-83) THROTTLE IOD OR STORAGE "2 "3 CONNECTOR RADIO AND TAPE PLAYER AUTO-CRUISE CONTROL UNIT SWITCH 1 2 3 4 TSB Revision...
Seite 411 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <Mb FUSIBLE LINK@ NOTE - - - - - - (c-71) . MFI SYSTEM IOD OR STORAGE . FULL AUTO A/C HEATER . ELECTRONIC MANUAL A/C CONTROL FULL AUTO A/C SUSPENSION AUTO-CRUISE CONTROL UNIT (c-37) LUGGAGE .
Seite 412 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <A/T> AUTO-CRUISE CONTROL CIRCUIT (1994, 1995 MODELS) <A/T> (CALIFORNIA) (CONTINUED) MULTI-PURPOSE MAIN MULTI-PURPOSE MULTI-PI JRPOSE SWITCH 0. 05B--W AND HAZARD LIGHT (D-42) LG-R (D-05) LG-B LG-B MFI' SYSTEM LG-B (D-41) VACUUM 213 LG-,R PUMP "4 "3 LIGHT...
Seite 413 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <A/T> IGNITION TRANSAXLE CONTROL MODULE STARTING SYSTEM (c-41) (c-es) L-R L-R c PARK/ NEUTRAL OVER DRIVE AND POWER/ I - - (c-45) L-F; (c-29) SUPPLEMENTAL STARTER AUTO-CRUISE CONTROL UNIT TSB Revision...
Seite 414 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <Ah IGNITION MFI SYSTEM THROTTLE (B-05) IOD OR STORAGE CONNECTOR RADIO AND TAPE PLAYER AUTO-CRUISE CONTROL UNIT SWITCH 9 ~10~11~~12~13~14~15~16~17~~1S~19 TSB Revision...
Seite 415 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <A IGNITION FUSIBLE LINK@ - - - - - - - - - - R-B R-Y r' R G-W B- IOD OR STORAGE CONNECTOR IA-11X) 'MANUAL A/C AUTO-CRUISE CONTROL UNIT (D-42) la LUGGAGE "6 "4 “1 COMPARTMENT...
Seite 416 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <A/T> AUTO-CRUISE CONTROL CIRCUIT (FROM 1996 MODELS) JRPOSE TURN-SIGNAL LIGHT AND HAZARD LIGHT (D-05) STOP COMBINATION METER SWITCH ,,N (c-61) \y LG-B (c-62) LG-B ------------ , 14 SYSTEM LG-B LG-B STOP LIGHT LG-R AUTO-CRUISE CONTROL UNIT TSB Revision...
Seite 417 CIRCUIT DIAGRAMS - Auto-cruise Control Circuit <A/T> MODULE MFI SYSTEM STARTING 10 (C-29) PARK/ NEUTRAL OVER DRIVE AND POWER/ (B-26) 5 :~--------- SYSTEM SUPPLEMENTAL AUTO-CRUISE CONTROL UNIT (c-37)
Seite 418 CIRCUIT DIAGRAMS - Power Seat Circuit SWIT LUMBAR SUPPORT (D-21) POWER SEAT ASSEMBLY (E-27) 1. 25 SIDE SUPPORT MOTOR (E-27) TSB Revision...
Seite 419 CIRCUIT DIAGRAMS - Power Seat Circuit POWER SEAT SWITCH ( SLIDE FRONT HEIGHT REAR HEIGHT FRONT - - - - - - - - FRONT REAR SLIDE MOTOR HEIGHT MOTOR LIMIT SWITCH LIMIT SWITCH TSB Revision...
Seite 420 CIRCUIT DIAGRAMS - Power Seat Circuit CHARGING SIDE SUPPORT LUMBAR SUPPORT (D-21) R E L E A S E C L O S E POWER SEAT ASSEMBLY (E-27) 4 ---- SIDE LUMBAR SUPPORT MOTOR THEFT ALARM SYSTEM THEFT ALARM SYSTEM...
Seite 421 CIRCUIT DIAGRAMS - Power Seat Circuit POWER SEAT SWITCH (4) SLIDE FRONT HEIGHT REAR HEIGHT DOWN FRONT - - - - - - - - - - - - - - - - - - LIMIT SWITCH . ,I...
Seite 422 CIRCUIT DIAGRAMS - Power Seat Circuit 1 5 A POWER WINDOW 2B 2Y-\N POWER SEAT ASSEMBLY ( E - 2 7 ) 1.25 1.25 2 --,,1, NOTE THEFT ALARM SYSTEM SIDE LUMBAR THEFT ALARM SYSTEM TSB Revision...
Seite 423 CIRCUIT DIAGRAMS - Power Seat Circuit POWER SEAT SWITCH (4) FRONT HEIGHT REAR HEIGHT SLIDE MOTOR...
Seite 424: Component Location
CIRCUIT DIAGRAMS - Power Seat Circuit COMPONENT LOCATION Junction block TSB Revision...
Seite 425 CIRCUIT DIAGRAMS - Tension-reducer Type Seat Belt Circuit FUSIBLE LINK@ FRONT SEAT BELT SWITCH IOD OR STORAGE (E-24) CONNECTOR FRONT SEAT (c-34) TIMER CIRCUIT R-G Y (E-21) (E-15) THEFT-ALARM SYSTEM THEFT-ALARM SYSTEM DOOR SWITCH (c-66) :1 (c-66) :2 FRONT SIDE...
Seite 426 CIRCUIT DIAGRAMS - Tension-reducer Type Seat Belt Circuit IGNI FUSIBLE LINK@ 'CH (IGl) HORN CHARGING 1 0 A ------ 11 (c-83) "4 (c-80) "2 (c-70) IOD OR r--- STORAGE CONNECTOR FRONT SEAT BELT SWITCH OFF 'TON (E-26) oFF I( RADIO AND TAPE PLAYER POWER WINDOW L-y...
Seite 427 CIRCUIT DIAGRAMS - Tension-reducer Type Seat Belt Circuit MULTI. - - - - - - - - - - - - - - - - - - - r Q ( c - 3 4 ) OMPARTMENT LIGHT COMPARTMENT LIGHT BUZZER .
Seite 428 CIRCUIT DIAGRAMS - Tension-reducer TvDe Seat Belt Circuit COMPONENT LOCATION Note: * indicates that this component is used on the right side as well. lock Front (inside the retractor)
Seite 429: Troubleshooting Hints
CIRCUIT DIAGRAMS - Tension-reducer Type Seat Belt Circuit OPERATION If the driver fastens the seat belt with the ignition switch placed in the “ON” position, the seat belt switch in the seat belt buckle is turned “ON” to operate the seat belt solenoid in the retractor. This will reduce the seat belt rewinding torqe to minimize a sense of oppression given by the belt.
Seite 430 CIRCUIT DIAGRAMS - Active Aero Circuit TAI LL: IGNITION REL AY FUSIBLE LINK@ J/B 1 A R-B S I - - IOD OR STORAGE CONNECTOR WHEN KEY IS REMOVED B-L R-B (F-27) Y-B (R-L) (L-W) SWITCH (D-29) DATA LINK CONNECTOR (c-79) RHEOSTAT SPEED...
Seite 431 CIRCUIT DIAGRAMS - Active Aero Circuit MULTI-PURPOSE FRONT VENTURI SKIRT (A-57) FUSIBL LINK 0 COMBINATION METER (Y-B) 4 ------- 56 ------ a .------. 11 .------. ------------ --------__ (F-28) 54 ACTIVE AERO CONTROL UNIT BR-R (F-34) - - - - - - - O F F REAR SPOILER (~-04)
Seite 432 CIRCUIT DIAGRAMS - Active Aero Circuit <HATCHBACK> IGNITION CHARGING 1 5 A 1 5 A . MANUAL A/C . MANUAL A/C TAPE PLAYER SWITCH (D-29) AUTO2 I L L RHEOSTAT (F-27) (F-28) TSB Revision...
Seite 433: Data Link Connector
CIRCUIT DIAGRAMS - Active Aero Circuit FUSIB E JRPOSE LINK 6 b ---- (Y-B IOD OR STORAGE CONNECTOR BUZZER IS REMOVED DOME LIGHT. FOOT LIGHT AND (Y-B IGNITION KEY CYLINDER ILLUMINATION L I G H T SIDE MARKER LIGHT CONTROLNIC S U S P E N S I O N MFI SYSTEM DATA LINK CONNECTOR...
Seite 434 CIRCUIT DIAGRAMS - Active Aero Circuit ACTIVE AERO CIRCUIT (FROM 1994 MODELS) (CONTINUED) FUSIBLE LINK 0 _ DOWN "4 "1 “2 13 _-----_ 4 ------ ------ ,,5 (c-03) 56 ------ ------ ------- -____-_ ACTIVE AERO CONTROL UNIT - - - - - - - - - - - - - - - REAR...
Seite 435 CIRCUIT DIAGRAMS - Active Aero Circuit COMPONENT LOCATION Symbol Name Symbol Name Data link connector (from 1994 models) Active aero control unit Data link connector (up to 1993 models) Active aero front venturi skirt Active aero rear spoiler 0 0 0 0 2 6 9 4 <From 1994 models>...
Seite 436 CIRCUIT DIAGRAMS - Active Aero Circuit...
Seite 437 CIRCUIT DIAGRAMS - Car Telephone Circuit (VEHICLES HARNESS WITHOUT TELEPHONE COMPONENT) SWITC DOOR ‘1 (E-04) 1 5 A (E-01) IOD OR RADIO AND TAPE PLAYER (D-35) 3 "4 (D-34) (F-37) SPARE CONNECTOR WIRELESS TELEHONE UNIT > SPARE CONNECTOR (HAND FREE MICROPHONE) (c-85) (F-38) SPARE CONNECTOR (HAND FREE CONTROLLER)
Seite 438 CIRCUIT DIAGRAMS - Car Telephone Circuit (VEHICLES HARNESS WITHOUT TELEPHONE COMPONENT) IGNI: DOOR D-46 " 1 1 ( c - 8 3 ) (E-01) F-36 RADIO AND TAPE PLAYER SPARE CONNECTOR WIRELESS TELEHONE UNIT ) SPARE CONNECTOR (HAND FREE MICROPHONE) (c-85) ' $- (F-38) SPARE CONNECTOR...
Seite 439 NOTES TSB Revision...
Seite 440 CIRCUIT DIAGRAMS - Top Stack Circuit <CONVERTIBLE> TOP SWITCH IGNITION SWITCH(IG2) SPEE 2 ---. 3 ----_ 4 .---- 3. 851 METER AND 18 (D-42) GAUGES 3. 851 0. 85\ 11 .---- 3 .---- 3. 853 TOP STACK HARNESS DATA LINK CONNECTOR TSB Revision...
Seite 441 CIRCUIT DIAGRAMS - Top Stack Circuit UMPER FUSIBLE L (E-42: (E-40 1 ---- (F-47 3 .---_ 7 .--- ---- (F-43) (F-41 TOP STACK HARNESS (F-43) Fm (F-49)
Seite 442 CIRCUIT DIAGRAMS - Top Stack Circuit <CONVERTIBLE> IGNI IGNITION (D-48) TOP SWITC REAR HARNESS (F-48)
Seite 443 CIRCUIT DIAGRAMS - TOD Stack Circuit *BACK-UP IGNITION LIGHT SWITCH POSITION SWITCH (Y-W) ELC 4-SPEED 10A AUTOMATIC TRANSAXLE &i ---- ::, 0. B! IOD OR STRAGE CONNECTOR COMBINATION METER NOTE REAR HARNESS REAR HARNESS REAR HARNESS (D-53) (F-47) HEADER HARNESS TSB Revision...
Seite 444 CIRCUIT DIAGRAMS - Sunroof Circuit <HATCHBACK> IGNITION FUSIBLE LINK 0 16 (c-77) (E-46) R-W 3 U N I T "15 LG-Y Y-0 ?.25R-L 1 1.25R-Y 1 SUNROOF CIRCUIT MOTOR BREAKER (E-48) LIMIT MOTOR SWITCH " a TSB Revision...
Seite 445 CIRCUIT DIAGRAMS - Sunroof Circuit C P U INPUT SIGNAL (E-47) 1 OPq&B / DOOR SWITCH (E-21) TSB Revision...
Seite 446 NOTES...
Seite 447: Inhaltsverzeichnis
CONTENTS Crankshaft Position Sensor CHARGING SYSTEM ....2 Check . . _ ..Refer to GROUP 13A (ON-VEHICLE INSPECTION GENERATOR ..*.....-..12 OF MFI COMPONENTS) Ignition Primary Voltage Wave-form ON-VEHICLE SERVICE .
Seite 448: Charging System
ENGINE ELECTRICAL - Charging Svstem GENERAL SPECIFICATIONS GENERATOR From 1996 models Up to 1995 models Items Battery voltage sensing Battery voltage sensing Rated output SERVICE SPECIFICATIONS GENERATOR Items Ambient temp. at voltage 20°C (68°F) 60°C (140°F) 13.4-14.6 mm (in.) Field coil resistance / 70% of nominal output current TSB Revision...
Seite 449: Circuit Diagram
ENGINE ELECTRICAL - Charging System CIRCUIT DIAGRAM IGNI: 0. a5 5 9 (D-04) COMBINATION 10 (D-45) ‘(B-18) GENEARATOR TSB Revision...
Seite 450 ENGINE ELECTRICAL - Charging System CIRCUIT DIAGRAM IGNITION (c-82) --COMBINATION METER AND GAUGES TURN-SIGNAL LIGHT AND HAZARD LIGHT ----- -------. COIL GENEARATOR TSB Revision...
Seite 451: Troubleshooting Hints
ENGINE ELECTRICAL - Charging System OPERATION TROUBLESHOOTING HINTS When engine is stopped 1. Charging warning light does not go on when the ignition switch is turned to “ON”, before the When the ignition switch is switched to the “ON” engine starts. position, electricity flows from the ‘I”...
Seite 452: On-Vehicle Service
ENGINE ELECTRICAL - Charging System GENERATOR OUTPUT LINE VOLTAGE DROP TEST Voltmeter Battery This test determines whether the wiring from the generator “B” terminal to the battery (+) terminal output wire.) (including the fusible link) is in a good condition NOTE or not.
Seite 453: Output Current Test
ENGINE ELECTRICAL - Charging System (6) Connect a tachometer. (For the procedure for is 30A. Take a reading of the value displayed connecting the tachometer, refer to GROUP on the voltmeter at this time. (11) If the value displayed on the voltmeter is above (7) kkconnect the negative battery cable.
Seite 454 ENGINE ELECTRICAL - Charging System This test determines whether the generator outputs the headlights, start the engine. normal current. (1) Before the test, always be sure to check the beam and turning the heater blower switch to following. the high revolution position, increase the engine Generator installation speed to 2,500 r/min and read the maximum Battery (Refer to GROUP 54 - Battery.)
Seite 455: Regulated Voltage Test
ENGINE ELECTRICAL - Charging Svstem REGULATED VOLTAGE TEST Generator Ammeter This test determines whether the voltage regulator (9) Turn the ignition switch to the ON position and is correctly controlling the generator output voltage. check that the reading on the voltmeter is equal to the battery voltage.
Seite 456: Wave-Form Check Using An Analyzer
ENGINE ELECTRICAL WAVE-FORM CHECK USING AN ANALYZER MEASUREMENT METHOD Connect the analyzer special patterns pick-up to the generator B terminal. STANDARD WAVE-FORM Observation Conditions FUNCTION VARIABLE Adjust while viewing the wave- Engine speed Curb idle speed Voltage at g e n e r a t o r 0 p7r-\fTfTfi/\AJ\ I+ h A fi 4 n r B terminal -0.2 -0.4...
Seite 457 ENGINE ELECTRICAL - Charging System ABNORMAL WAVE-FORMS EXAMPLES NOTE 1. The size of the wave-form patterns differs largely depending on the adjustment of the variable knob on the analyzer. 2. Identification of abnormal wave-forms is easier when there is a large output current (regulator is not operating).
Seite 458: Removal And Installation
ENGINE ELECTRICAL - Charging System REMOVAL AND INSTALLATION Pre-removal and Post-installation Operation Removal and Installation of Right Bank Warm Up Three-Way Catalytic Converter (Refer to GROUP 15-Exhaust Pipe, Main Muffler and Catalytic Converter.) 24 Nm 7-9 ft.lbs. Removal steps 5. Generator connector 6.
Seite 459: Disassembly And Reassembly
ENGINE ELECTRICAL - Charging System DISASSEMBLY AND REASSEMBLY (Up to 1995 models) Disassembly steps 8. Insulator 1. Generator pulley 9. Plate 10. Reaulator and brush holder 3. Rear bearing 11. Slinlger 4. Bearing retainer 12. Rectifier 5. Front bearing 13. Brush 6.
Seite 460 ENGINE ELECTRICAL - Charging System (From 1996 models) Disassembly steps 8. Plate 9. Regulator and brush holder 3. Rear bearing 10. Brush 11. Slinger 4. Bearing retainer 5. Front bearing 12. Rectifier assembly 6. Front bracket 13. Rear bracket 7. Stator assembly DISASSEMBLY SERVICE POINT Remove the bolts.
Seite 461 ENGINE ELECTRICAL - Charging System (3) Clamp the rotor in a vise with soft jaws. (4) After removing the nut, remove the pulley and front bracket from the rotor. REMOVAL (1) When removing the stator, unsolder stator lead wire from the main diode of the rectifier. (2) When removing the brush holder, unsolder it from the rectifier.
Seite 462 ENGINE ELECTRICAL - Charging System INSPECTION ROTOR (1) Check field coil for continuity. Check to ensure that there is continuity between slip rings. If resistance is extremely small, it means that there is a short. If there is no continuity or if there is short circuit, replace rotor assembly.
Seite 463: Brush Replacement
ENGINE ELECTRICAL - Charging System (2) Negative Rectifier Test Check for continuity between negative rectifier and stator coil lead connection terminal. If there is continuity in both directions, diode is shorted, and rectifier assembly must be replaced. (3) Diode Trio Test Check three diodes for continuity by connecting an amme- ter to both ends of each diode.
Seite 464 ENGINE ELECTRICAL - Charging System (5) Solder pigtail to brush holder as shown in the illustration. Soldered BRUSH REPLACEMENT <From 1996 models> (1) Replace brush by the following procedures if it has been Limit line worn to limit line. (2) Unsolder pigtail and remove old brush and spring. (3) When installing a new brush, push the brush in the brush holder as shown in the illustration, and solder the lead wire.
Seite 465: Starting System
ENGINE ELECTRICAL - Starting System GENERAL SPECIFICATIONS STARTER MOTOR Specifications Items Reduction drive (with planetary gear) Rated output kW/V No. of pinion teeth SERVICE SPECIFICATIONS STARTER MOTOR Standard value Limit Items running Terminal voltage V Free characteristics Current A 90 or less Speed r/min 3,000 or more Pinion gap mm (in.)
Seite 466: Troubleshooting
ENGINE ELECTRICAL - Starting System CIRCUIT DIAGRAM <VEHICLES WITHOUT THEFT-ALARM SYSTEM> IGNI BA - TTI (c-31 MFI SYSTEM AUTO-CRUISE CONTROL STARTER RELAY ------- PARK/NEUTRAL (B-26) (A-67 SUPPLEMENTAL SYSTEM 2B- WARNING LIGHT (B-30: NOTE STARTER MOTOR STARTER MOTOR (c-31) Revision...
Seite 467 ENGINE ELECTRICAL - Starting System <VEHICLES ‘WITH THEFT-ALARM SYSTEM (M/T)> FUSIBLE LINK@ IGNITION (c-31: IOD OR STORAGE CONNECTOR G-313 I - - - - - - . BUZZER . MFI SYSTEM . fl@+NG PEDAL LIGHT AND IGNITION KEY CYLINDER ILLUMINATION LIGHT LG-B WHEN KEY IS...
Seite 468 ENGINE ELECTRICAL - Starting System <VEHICLES WITH THEFT-ALARM SYSTEM (AK)> FUSIBLE LINK@ IGNITION (c-31: 11 1 STARTER RELAY IOD OR STORAGE CONNECTOR PARK/ 'BUZZER COMPARTMENT . f~[f,\6[!?.+~~ [#~f#hI LIGHT CYLINDER ILLUMINATION (B-26) NOTE BATTERY MFI SYSTEM (B-30) 208-R WHEN KEY IS SUPPLEMENTAL REMOVED (B-24)
Seite 469: Starter Motor
ENGINE ELECTRICAL - Starting System TROUBLESHOOTING HINTS OPERATION The starter motor does not operate at all. For models equipped with the M/T, the clutch pedal position switch contact is switched OFF Check the starter (coil). when the clutch pedal is depressed; when the Check for poor contact at the battery terminals and starter.
Seite 470: Magnetic Switch Pull-In Test
ENGINE ELECTRICAL - Starting System (5) If pinion gap is out of specification, adjust by adding or removing gaskets between magnetic switch and front bracket. MAGNETIC SWITCH PULL-IN TEST (1) Disconnect field coil wire from M-terminal of magnetic switch. (2) Connect a 12 V battery between S-terminal and M-terminal. Caution This test must be performed quickly (in less than 10 seconds) to prevent coil from burning.
Seite 471: Starter Relay
ENGINE ELECTRICAL - Starting System MAGNETIC SWITCH RETURN TEST (1) Disconnect field coil wire from M-terminal of magnetic switch. (2) Connect a 12 V battery between M-terminal and body. Caution This test must be performed quickly (in less than 10 seconds) to prevent coil from burning.
Seite 472 ENGINE ELECTRICAL - Starting System DISASSEMBLY AND REASSEMBLY <EXCEPT FROM 1994 CALIFORNIA VERSION> Disassembly steps 12. Packing A 1. Screw 13. Packing B 14. Plate 5. Rear bracket 6. Brush holder 18. Stop ring 7. Brush 19. Overrunning clutch 8. Rear bearing 20.
Seite 473 ENGINE ELECTRICAL - Starting System <FROM 1994 CALIFORNIA VERSION> Disassembly steps 12. Packing A 1. Screw 13. Packing B 2. Magnetic switch 14. Plate 3. Screw 15. Planetary gear 4. Starter cover 16. Lever 5. Rear bracket 6. Brush holder 7.
Seite 474 ENGINE ELECTRICAL - Starting System (1) Press the stop ring, by using an appropriate socket, wrench, to the snap ring side. Stop ring (2) After removing the snap ring (by using snap-ring pliers), remove the stop ring and the overrunning clutch. STARTER MOTOR PARTS CLEANING 1.
Seite 475 ENGINE ELECTRICAL - Starting System (2) Check the outer diameter of the commutator. Standard value: 29.4 mm (1.158 in.) Limit: 28.4 mm (1.118 in.) (3) Check the depth of the undercut between segments. Undercut Standard value: 0.5 mm (.020 in.) BRUSH HOLDER Check for continuity between brush holder plate and brush holder.
Seite 476 ENGINE ELECTRICAL - Starting System BRUSHES AND SPRINGS REPLACEMENT Brushes that are worn beyond wear limit line, or oil-soaked, should be replaced. 2. When replacing field coil brushes, crush worn brush with pliers, being careful not to damage pigtail. Sand pigtail end with sandpaper to ensure good soldering. New brush Insert pigtail into hole provided in new brush and solder Make sure that pigtail and excess solder do not come...
Seite 477: Ignition System
ENGINE ELECTRICAL - Ignition System GENERAL SPECIFICATIONS CRANK ANGLE SENSOR cup to 1992 model> Items Specifications Contact pointless type Identification No. Part No. MD1 53464 Advance mechanism Controlled by engine control unit l - 2 - 3 - 4 - 5 - 6 Firing order IGNITION COIL Items...
Seite 478 ENGINE ELECTRICAL - lanition Svstem CIRCUIT DIAGRAM IGNITION DETECTION CONNECTOR (D-44) (B-14) (D-15) 1. 25L-Y 1. 25 CAPACITOR (B-15) IGNITION IGNITION COIL 1-4 COIL 2-5 IGNITION I POWER TRANSISTOR! (D-15) SPARK PLUG S W I T C H POSITION SE ENGINE CONTROL MODULE POSITION SENSOR';#$;~L;oc *ENGINE COOL...
Seite 479: Circuit Diagram
ENGINE ELECTRICAL - Ignition Svstem CIRCUIT DIAGRAM IGNITION SWITCH(IG1) CHARGING 1 5 A DETECTION CONNECTOR CAPACITOR (B-15) ----- ----- ,,ll (B-22) r----- -------- IGNITION IGNITION IGNITION COIL 3-6 COIL 2-5 _---- ----- '1 (8-21) _____ ------ ----- INPUT SIGNAL . (CTP) SWITCH POSITION SENSOR 1.
Seite 480 ENGINE ELECTRICAL - Ignition System CIRCUIT DIAGRAM IGNITION SWITCH(IG1) CHARGING DETECTION CONNECTOR (B-14) ------ ---__ ,,11 (8-22) IGNITION IGNITION IGNITION COIL l-4 COIL 2-5 COIL 3-6 IGNITION / POWER TRANSISTOR; - - - - - - - - - - - - - - - - - - - - - - - - (F)'...
Seite 481 ENGINE ELECTRICAL - Ignition System OPERATION TROUBLESHOOTING HINTS Turn ignition switch to .“ON”position, and battery 1. Engine cranks, but does not start. (1) Spark is insufficient or does not occur at voltage will be applied to primary winding of ignition coil. all (on spark plug).
Seite 482: On-Vehicle Service
ENGINE ELECTRICAL - Ignition System SPARK PLUG CABLE TEST (1) Disconnect, one at a time, each of the spark plug cables while the engine is idling to check whether the engine’s running performance changes or not. Caution Wear rubber gloves while doing so. (2) If the engine performance does not change, check the resistance of the spark plug cable, and check the spark plug itself.
Seite 483: Measurement Method
ENGINE ELECTRICAL - lanition Svstem IGNITION SECONDARY VOLTAGE WAVE-FORM CHECK MEASUREMENT METHOD (1) Clamp SECONDARY PICKUP around spark plug cable. NOTE 1. The ignition voltage peak appears reversely between when the spark plug cables of the cylinders No.4, No. 5 and No. 6 are clamped and when those of the cylinders No.
Seite 484 ENGINE ELECTRICAL - Ignition System STANDARD WAVE-FORM Observation Conditions FUNCTION SECONDARY HIGH (or LOW) PATTERN HEIGHT RASTER PATTERN SELECTOR Engine revolutions Curb idle speed Spark line (Point A) Ignition voltage (Point D) Wave damping reduction section (Point B) ignition Dwell section voltage wave-form Time...
Seite 485 ENGINE ELECTRICAL - Ignition System Wave-form Observation Points Point A: The height, length and slope~of the spark line (refer to abnormal wave-form examples 1, 2, 3 and 4) show the following ‘trends. Spark line Condition of Compression Concentration Ignition timing Spark electrode force of air mixture...
Seite 486 ENGINE ELECTRICAL - Ignition System EXAMPLES OF ABNORMAL WAVE-FORMS off. (Causing a dual ignition) and abnormal wave-form exam- TSB Revision...
Seite 487 ENGINE ELECTRICAL - lanition Svstem IGNITION PRIMARY VOLTAGE WAVE-FORM Analyzer CHECK MEASUREMENT METHOD (1) Remove the ignition coil connector and connect the special tool (harness connector: MD998464) in between. (2) When observing the No. 1 - No. 4 cylinder group, connect the primary pickup of the analyzer probe to the ignition coil side connector terminal No.
Seite 488 ENGINE ELECTRICAL Observation conditions (Only PAlTERN SELECTOR below changes from the above conditions.) PATTERN SELECTOR DISPLAY No. 2 (or No. 5) No. 1 (or No. 4) cylinder cylinder cylinder cylinder cylinder 100 - ignition noise ignition noise ignition noise ignition noise Neutral section Primary...
Seite 489 ENGINE ELECTRICAL Wave-form Observation Points Point A: The height, length and slope of the spark line (refer to abnormal wave-form examples 1, 2, 3 and 4) show the following trends. Spark line Condition of Compression Ignition timing High tension electrode force tion of air mix- cable...
Seite 490 ENGINE ELECTRICAL - Ignition System EXAMPLES OF ABNORMAL WAVE-FORMS Abnormal wave-form Wave characteristics Cause of problem Example 1 Spark line is high and short. Spark plug gap is too large. Example 2 Spark line is low and long, and is Spark plug gap is too small.
Seite 491: Removal And Installation
ENGINE ELECTRICAL - Ignition System REMOVAL AND INSTALLATION 13 Nm 12 Nm 9 ft.lbs. 22 Nm 9 Nm 7 ft.lbs. 00662527 Removal steps 7. O-ring cl992 models> Intake manifold plenum (Refer to 8. Clamp <From 1993 models> GROUP 1.5 - Intake Manifold.) Camshaft position sensor, Crankshaft 1.
Seite 492 ENGINE ELECTRICAL INSTALLATION SERVICE POINTS (1) Turn the crankshaft so that the No. 1 cylinder is at compression top dead center. Caution Be careful not to turn it to the No. 4 cylinder com- pression top dead center by mistake. (2) Install, lining up the matchmarks on the crankshaft position sensor housing and the coupling.
Seite 493 ENGINE ELECTRICAL - Ignition System Spark plug cable No. 1 cable No. 2 Spark plug Approx. Spark plug 60 mm Approx. 80 mm (3.15 in.) TSB Revision...
Seite 494 ENGINE ELECTRICAL - lanition Svstem INSPECTION SPARK PLUG Check the plug gap and replace if the limit is exceeded. Standard value: 1.0-l .l mm (.039-.043 in.) Limit: 1.3 mm (.051 in.) Caution Do not attempt to adjust the gap of the platinum plug. 2.
Seite 495: Ignition Coil
ENGINE ELECTRICAL Terminal 12 and terminal 4 Connected Continuitv Unconnected No continuitv (2) Replace the ignition power transistor if there is a malfunc- tion. No. ~-NO. 6 coil side (1) Connect the negative (-) terminal of the 1.5 V power supply to terminal (4) of the ignition power transistor;...
Seite 496 NOTES...
Seite 497 CONTENTS AERO PARTS (ACTIVE ..Refer to GROUP 51 CRUISE CONTROL SYSTEM ..Refer to GROUP 17 ANTI-LOCK BRAKING SYSTEM ..Refer to GROUP 35 DOOR GLASS AND REGULATOR (POWER WINDOWS) .
Seite 498: Special Tools
IGNITION SWITCH* ........6 REAR WINDOW DEFOGGER ..... . 192 IGNITION SWITCH .
Seite 499: Specifications
CHASSIS ELECTRICAL - Battery GENERAL SPECIFICATIONS models models Up to From Items 1993 1994 Ampere hours (5HR) Ah Cranking rating [at Reserve capacity min. NOTES is the current a battery can deliver for 30 seconds and maintain a terminal voltage of CRANKING RATING volts or greater at a specified temperature.
Seite 500 CHASSIS ELECTRICAL - Battery 4. Clean top of battery with same solutions as described in step (3). 5. Inspect battery case and cover for cracks. If cracks are present, battery must be replaced. 6. Clean the battery post with a suitable battery post cleaning 7.
Seite 501 CHASSIS ELECTRICAL - Battery BATTERY TESTING PROCEDURE TEST STEP Clean terminals and clamps. (1) Remove hold-downs and shields. (2) Check for broken/cracked case or cover. (1) Turn headlights on for 15 seconds. (2) Turn headlights off for 2 minutes to allow battery voltage to stabilize.
Seite 502: Ignition Switch
CHASSIS ELECTRICAL - Ignition Switch Tool Tool number and name Supersession Application General service tool Removal of steering wheel MB990803 Steering wheel puller REMOVAL AND INSTALLATION 40 Nm 6 Nm Ignition switch segment removal Steering lock cylinder removal steps steps 1.
Seite 503 CHASSIS ELECTRICAL - Ignition Switch REMOVAL SERVICE POINTS Remove the steering wheel by using the special tool. Caution Do not hammer on the steering wheel to remove it; doing so may damage the collapsible mechanism. Front of vehicles UPPER REMOVAL After the screws have been removed, remove the covers, while making sure not to break the grippers.
Seite 504 CHASSIS ELECTRICAL - Ignition Switch INSPECTION IGNITION SWITCH CHECK (1) Remove the knee protector, the column cover lower and the column cover upper. (Refer to GROUP 52A - Instru- ment Panel.) (2) Disconnect the wiring connector from the ignition switch and key reminder switch, and connect an ohmmeter to the switch side connector.
Seite 505: Specifications
CHASSIS ELECTRICAL - Meters and Gauaes GENERAL SPECIFICATIONS METERS AND GAUGES NOTE TSB Revision...
Seite 506 CHASSIS ELECTRICAL - Meters and Gauges INDICATORS AND WARNING LIGHTS Anti-lock brakin NOTE (1) The values in parentheses denote SAE trade numbers. (2) The *I symbol indicates vehicles with theft-alarm system. (3) The symbol indicates vehicles with Electronic Controlled Suspension. (4) The *3 symbol indicates vehicles with Active Exhaust System.
Seite 507: Sealant
CHASSIS ELECTRICAL - Meters and Gauaes SERVICE SPECIFICATIONS Items Standard values Speedometer indicationerror 19-22 38-44 Tachometer indication error rpm 1,000 3,000 5,000 6,000 Fuel gauge unit resistance R Point E Fuel gauge unit float height Point F 18.6-21.6 (.73-.85) mm (in.) Point E Engine coolant temperature gauge unit resistance [at 70°C (158”F)] Q 104 f 13.5...
Seite 508: Troubleshooting
CHASSIS ELECTRICAL METERS AND GAUGES CIRCUIT DIAGRAM <UP TO 1993 MODELS> IGNITION COMBINATION METER TURBO 54 (D-04) IGNI POWE 16 (c-71) (D-05) 51152153154155156157~56 TSB Revision...
Seite 509 CHASSIS ELECTRICAL - Meters and Gauges r - h COMBINATION GAUGE (D-09) CONTROL MODULE (B-OS) COOLANT PRESSURE TEMPERATURE GAUGE UNIT (B-36) TSB Revision...
Seite 510 CHASSIS ELECTRICAL - Meters and Gauaes METERS AND GAUGES CIRCUIT DIAGRAM cl994 MODELS> COMBINATION METER IGNI POWE TRAN STOR MODULE (D-41) - - - - J TSB Revision...
Seite 511 CHASSIS ELECTRICAL and Gauges 1 . , & q - - DEDICATED , 13 --------- (D-09) MODULE (D-15: ENGINE COOLANT TEMPERATURE GAUGE UNIT (B-01) TSB Revision...
Seite 512 CHASSIS ELECTRICAL - Meters and Gauges METERS AND GAUGES CIRCUIT DIAGRAM <FROM 1995 MODELS> IGNITION CHARGING TURN-SIGNAL LIGHT AND HAZARD LIGHT WARNING LIGHT COMBINATION METER 54 (D-04) IGN: ISTOR 16 (c-71) NOTE (F-14) ( D - 4 4 )
Seite 513 CHASSIS ELECTRICAL - Meters and Gauges B-l Iv NOTE ELC 4A/T COMBINATION 1 (C-14) ENGINE CONTROL MODULE RHEOSTAT (D-40) (D-15) TEMPERATURE UNIT TSB Revision...
Seite 514: Troubleshooting Hints
CHASSIS ELECTRICAL - Meters and Gauges OPERATION <Fuel gauge> When the ignition key is at the “ON” position, When the ignition key is at the “ON” position, the oil pressure gauge is activated. the fuel gauge is activated. When oil pressure is high, the internal contacts When there is much fuel, the unit’s resistance is small and the current flowing in the circuit of the gauge unit are kept closed for a longer...
Seite 515 CHASSIS ELECTRICAL - Meters and Gauges COMPONENT LOCATION Engine control module TSB Revision...
Seite 516 CHASSIS ELECTRICAL - Meters and Gauges WARNING LIGHT CIRCUIT DIAGRAM <UP TO 1994 MODELS> SWI' COMBINATION METER FUEL GAUGE UNIT SWITCH OFF - TSB Revision...
Seite 517 CHASSIS ELECTRICAL IGNI SWIT r G 1 5 1 i(D-44) r - - - - I(D-45) (A-67) DIODE (Y-G) D-10 COMBINATION METER (D-04) TSB Revision...
Seite 518 CHASSIS ELECTRICAL - Meters and Gauges WARNING LIGHT CIRCUIT DIAGRAM cl995 MODELS> IGN. CHARGING TURN-SIGNAL LIGHT B- COMBINATION AND HAZARD LIGHT METER METER AND GAUGES 12 (D-03) Y-B I OFF - NOTE...
Seite 519 CHASSIS ELECTRICAL IGNI IGNITION CHARGING (A-67) CLUTCH PEDAL MFI SYSTEM DIODE (Y-G) D-10 METER (D-04) SUPPLEMENTAL TSB Revision...
Seite 520 CHASSIS ELECTRICAL WARNING LIGHT CIRCUIT DIAGRAM <FROM 1996 MODELS> CHARGING (D-44) NOTE TURN-SIGNAL LIGHT AND HAZARD LIGHT METER AND GAUGES METER "9 (D-16) BRAKE FLUID LEVEL SWITCH (D-28) TSB Revision...
Seite 521 CHASSIS ELECTRICAL - Meters and Gauaes IGNI IGNITION (D-44) (A-67) METER AND TURN-SIGNAL LIGHT GAUGES AND HAZARD LIGHT MFI SYSTEM '(D-15) DIODE STARTING (D-04) SUPPLEMENTAL TSB Revision...
Seite 522 CHASSIS ELECTRICAL - Meters and Gauges INSPECTION SPEEDOMETER CHECK (1) Assure tire pressure at standard value. (Refer to GROUP (2) Gt the vehicle on a speedometer tester. (3) Set free rollers securely on the floor according to the wheel- base and rear tread of the vehicle (when rear wheels Free r&Hers - are to be set on free rollers).
Seite 523 CHASSIS ELECTRICAL TACHOMETER CHECK (1) insert paper clip into the engine revolution speed detection terminal provided in the engine compartment, and connect the engine tachometer to the inserted paper clip. Caution As the tachometer is negative grounded, do not con- nect battery conversely to prevent damaging transis- tor and diode.
Seite 524 CHASSIS ELECTRICAL - Meters and Gauges FUEL GAUGE UNIT CHECK To check, remove fuel gauge unit from fuel tank. (Refer to GROUP 13F - Fuel Tank.) Fuel Gauge Unit Resistance (1) Check that resistance value between the fuel gauge termi- nal and ground terminal is at standard value when fuel gauge unit float is at point F (highest) and point E (lowest).
Seite 525 CHASSIS ELECTRICAL - Meters and Gauaes ENGINE COOLANT TEMPERATURE GAUGE SIMPLE CHECK Remove the water temperature gauge unit coupling connector. Connect the harness connector via a test light to the ground. Place the ignition switch in the ON posi- tion. Check the test light and gauge conditions.
Seite 526 CHASSIS ELECTRICAL OIL PRESSURE GAUGE SIMPLE CHECK Remove the oil pressure gauge unit coupling connector. Connect the harness connector via a test light to the ground. Place the ignition switch in the ON posi- Check the test light and gauge conditions. (1) Test light lights.
Seite 527: Removal And Installation
CHASSIS ELECTRICAL - Meters and Gauges REMOVAL AND INSTALLATION NOTE Removal steps 1. Knee protector (Refer G GROUP 52A 6. Adapter* (Mechanical speedometer type) /Washer tank (Refer to GROUP 2. Column 51 - Windshield Wiper and Washer.) cover, lower 3. Column cover, upper 7.
Seite 528 CHASSIS ELECTRICAL DISASSEMBLY AND REASSEMBLY Disassembly steps 1. Trip counter reset knob 5. Fuel gauge 2. Meter glass 6. Tachometer 3. Window plate 7. Printed-circuit board 4. Speedometer 8. Meter case Ground INSPECTION Reed switch REED SWITCH CHECK <Mechanical Speedometer Type> Use circuit tester to check circuit repeats off/on between termi- nals when speedometer shaft turned several times.
Seite 529: Disassembly And Reassembly
CHASSIS ELECTRICAL - Meters and Gauges REMOVAL AND INSTALLATION Removal steps 1. Instrument panel (Refer to GROUP 52A - Instrument [Refer to GROUP 55 - Ventilators Panel.) (Instrument Panel).] 2. Combination gauge DISASSEMBLY AND REASSEMBLY Disassembly steps 1. Gauge bracket 5.
Seite 530 CHASSIS ELECTRICAL - Meters and Gauges INSPECTION PRESSURE GAUGE CHECK <Turbo> Measure resistance between terminals with circuit tester. Standard value: Approx. 72 &2 VOLTAGE GAUGE CHECK <Non-Turbo> Refer to P.54-30 OIL PRESSURE GAUGE CHECK Measure resistance between terminals with circuit tester. Standard value: Approx.
Seite 531: Lighting System
CHASSIS ELECTRICAL - Lighting System GENERAL SPECIFICATIONS Exterior lights Items Specifications Headlight W Fog light W Turn-signal light / side marker light CP Front combination light Rear combination light Turn-signal light / side marker and tail light CP Stop light / side maker and tail light CP Back-up light CP 32 (1156) License plate light CP...
Seite 532: Special Tools
CHASSIS ELECTRICAL - Lighting System Application Tool number and name Supersession MB991 341 C Up to 1993 models Checking the lighting system All models MB991 502 Checking the lighting system MB991 529 From 1994 models MB991 529 Diagnostic trouble code Checking the lighting system using a voltmeter check harness...
Seite 533 CHASSIS ELECTRICAL tact of the pop-up motor U/D (UP/DOWN) switch, the coil of the pop-up motor relay and HEADLIGHT ground, causing the contacts of the pop-up mo- tor relay to close. OPERATION When the contacts of the pop-up motor relay <Headlights ON operation>...
Seite 534 CHASSIS ELECTRICAL TROUBLESHOOTING Check the light aut Refer to P.54-108. headlights is normal. Tail lights are not automati- Check the driver’s side door switch. NOTE (1) *Up to 1993 models (2) For information concerning the theft-alarm system, refer to P.54-222. TSB Revision...
Seite 535 CHASSIS ELECTRICAL - Lighting System Headlight relay/Pop-up motor relay/ Data link connector <From 1994 models> <Vehicles with keyless entry system> Light automatic shut-off unit...
Seite 536 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <VEHICLES WITHOUT THEFT-ALARM SYSTEM (UP TO 1993 MODELS)> (R-Y: DEDICATED FUSE (R-Y (R-Y) TSB Revision...
Seite 537 CHASSIS ELECTRICAL - Lighting System FUSIBLE LINK@ SWITC ( c - 7 7 ) STORAGE CONNECTOR LIGHT AUTOMATIC SHUT-OFF UNIT (E-17) @SWITCH (E-21)
Seite 538 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <VEHICLES WITHOUT THEFT-ALARM SYSTEM (UP TO 1993 MODELS)> ( C O N T I N U E D ) IGNITION LIGHT AUTOMATIC HEADLIGHT HEADLIGHT gWi-i;-OFF RELAY (c-78) 1.251; (R-Y: WITHOUT WITH A C C E S S O R Y (R-Y) (R-Y.
Seite 539 CHASSIS ELECTRICAL DEDICATED FUSE IOD OR STORAGE DATA LINK CONNECTOR RHEOSTAT...
Seite 540 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <VEHICLES WITH THEFT-ALARM SYSTEM (UP TO 1993 MODELS)> ------ (R-Y) (R-Y) r------- HEADLIGHT "1 "2 (A-41) (A-61) "2 "1 COMBINATION METER (R-Y)
Seite 541 CHASSIS ELECTRICAL IGNI' FUSIBLI LINK 8 (R-Y) LIGHT AUTOMATIC (E-17) DOOR SWITCH (E-21)
Seite 542 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <VEHICLES WITH THEFT-ALARM SYSTEM (UP TO 1993 MODELS)> (CONTINUED) IGNITION HEADLIGHT 1. 251 (R-Y) (R-Y) (R-Y) 6 :-_ TSB Revision...
Seite 543 CHASSIS ELECTRICAL IOD OR STORAGE CONNECTOR LIGHT AUTOMATIC SHUT-OFF UNIT (D-42) DATA LINK CONNECTOR L-Y b L-R 1, G-W 3 POP-UP SWITCH RHEOSTAT TSB Revision...
Seite 544 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <VEHICLES WITHOUT THEFT-ALARM SYSTEM (FROM 1994 MODELS)> FOG LIGHT SIDE MARKER LIGHT AND LICENSE PLATE LIGHT FOG LIGHT DEDICATED FUSE (R-Y) (D-45) ,;c'"-, 0. B5E (R-Y) (R-Y)
Seite 545 CHASSIS ELECTRICAL FUSIBLE LINK@ (c-82) CHARGING BACK-UP LIGHT IOD OR STORAGE CONNECTOR DOOR LIGHT AND (R-Y) LIGHT AUTOMATIC SHUT-OFF UNIT ( E - DOOR LIGHT AND TSB Revision...
Seite 546 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <VEHICLES WITHOUT THEFT-ALARM SYSTEM (FROM 1994 MODELS)> (CONTINUED) HEADLIGHT (R-Y) MARKER LIGHT AND LICENSE PLATE LIGHT (R-Y) (R-Y) 3 ------ O N ’ - O F F ‘ - - - - - - - - - - - - - - - - - - - ! - - - - - - - - - - - - 2B '...
Seite 547 NOTES Revision...
Seite 548 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <VEHICLES WITH THEFT-ALARM SYSTEM (FROM 1994 MODELS)> MARKER LIGHT AND LICENSE PLATE LIGHT (R-Y (R-Y FOG LIGHT DEDICATED FUSE 14 .- (A-77) (D-45) 1. 25F (D-04) ;( 0.85 (R-Y (R-Y) TSB Revision...
Seite 549 CHASSIS ELECTRICAL IGNI FUSIBLE LINK@ CHARGING ( c - 7 7 : STORAGE CONNECTOR HEADLIGHT RELAY 0. 8! (R-Y) DOOR LIGHT AND LUGGAGE COMPARTMENT LIGHT LIGHT AUTOMATIC DOOR LIGHT AND LUGGAGE COMPARTMENT LIGHT TSB Revision...
Seite 550 CHASSIS ELECTRICAL - Lighting System CIRCUIT DIAGRAM <VEHICLES WITH THEFT-ALARM SYSTEM (FROM 1994 MODELS)> (CONTINUED) IGNITION HORN (c-82) ,P IOD OR STORAGE CONNECTOR DOME LIGHT, DOOR LIGHT AND LUGGAGE FOOT LIGHT AUTOMATIC AND IGNITION SHUT-OFF KEY CYLINDER ILLUMINATION LIGHT...
Seite 551 CHASSIS ELECTRICAL LIGHT AUTOMATIC HEADLIGHT IGHT s/Y;-OFF SIDE MARKER LIGHT PLATE 0.85 (R-Y (R-Y J/B A TSB Revision...
Seite 552: Input Signal
CHASSIS ELECTRICAL INPUT SIGNAL Data link connector With voltmeter to 1993 models> When using the scan tool (MUT) or voltmeter Using the scan tool or voltmeter, check whether or not the input signals from each switch are being input to the ETACS unit.
Seite 553 NOTES Revision...
Seite 554 CHASSIS ELECTRICAL - Lighting System FOG LIGHT CIRCUIT CIRCUIT DIAGRAM (UP TO 1993 MODELS) IGNIT SWITC c-77) (R-Y AUTOMATIC (R-Y ‘1 "4 LIGHT RELAY "3 "4 TSB Revision...
Seite 555 CHASSIS ELECTRICAL IGHT RELAY (R-Y: (R-Y) DEDICATED FUSE (D-45) (R-Y) FOG LIGHT RHEOSTAT (R-Y) -------- -------- TSB Revision...
Seite 556 CHASSIS ELECTRICAL CIRCUIT DIAGRAM (FROM 1994 MODELS) FUSIBLE LINK@ SIDE MARKER LIGHT IGHT 0. 05 B-W ( DOOR LIGHT AND LIGHT AUTOMATIC (E-17) HEADLIGHT DOOR LIGHT AND LUGGAGE COMPARTMENT IGHT TSB Revision...
Seite 557 CHASSIS ELECTRICAL AUTOMATIC DEDICATED FUSE (R-Y (R-Y MARKER LIGHT AND LICENSE PLATE LIGHT OFF‘ "4 (R-W) RHEOSTAT (R-Y (R-W) J/B A NOTE TSB Revision...
Seite 558: Troubleshooting Hints
CHASSIS ELECTRICAL OPERATION When the fog light switch is placed in the ON position with the lighting switch in the HEAD position and the dimmer switch in the LO position, current flows through the dedicated fuse (4) to the coil of the fog light relay, the fog light switch, the dimmer switch and ground, causing the contacts of the fog light relay to close.
Seite 559 CHASSIS ELECTRICAL COMPONENT LOCATION Light automatic shut-off unit Headlight relay / Foglight relay Light automatic shut-off unit...
Seite 560 CHASSIS ELECTRICAL - Lighting System TAIL LIGHT, PARKING/SIDE MARKER LIGHT AND LICENSE PLATE LIGHT CIRCUIT DIAGRAM (UP TO 1993 MODELS) FUSIBLE LINK@ (c-77) (c-83 R-Y 1 R STORAGE CONNECTOR LIGHT AUTOMATIC (E-17) O F F TSB Revision...
Seite 561 CHASSIS ELECTRICAL J / B - - - - - - "4 4 REAR (F-10) REAR COMBINATION COMBINATION (F-18) B TSB Revision...
Seite 562 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <HATCHBACK> (FROM 1994 MODELS) IGNI FUSIBLE LINK@ FUSIBL LINK@ CHARGING R-Y 1 R IOD OR STORAGE CONNECTOR 1. 25R-1 TAILLIGHT RELAY DOOR LIGHT AND LUGGAGE COMPARTMENT LIGHT AUTOMATIC (E-17) DOOR LIGHT AND TSB Revision...
Seite 563 CHASSIS ELECTRICAL FRONT COMBINATION COMBINATION (A-62) 1 -- TAPE PLAYER COMBINATION G-W 2 (F-21) TSB Revision...
Seite 564 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <CONVERTIBLE> (FROM 1995 MODELS) IGNITION LINK@ FUSIBLE LINK@ CHARGING (c-83: DOOR LIGHT AND LUGGAGE COMPARTMENT LIGHT AUTOMATIC SHUT-OFF UNIT DOOR LIGHT AND...
Seite 565 CHASSIS ELECTRICAL TAIL TAPE PLAYER REAR REAR COMBINATION COMBINATION G-W 2 LIGHT (F-18) TSB Revision...
Seite 566 CHASSIS ELECTRICAL OPERATION TROUBLESHOOTING HINTS When the lighting switch is placed in the TAIL 1. All lights don’t illuminate. or HEAD position, current flows through the (1) The headlights don’t illuminate, either. coil of the tail light relay to the lighting switch Check the fusible link (3).
Seite 567 CHASSIS ELECTRICAL COMPONENT LOCATlON Light automatic shut-off unit Light automatic shut-off unit...
Seite 568 CHASSIS ELECTRICAL DOME LIGHT, FOOT LIGHT AND IGNITION KEY CYLINDER ILLUMINATION LIGHT CIRCUIT DIAGRAM (UP TO 1993 MODELS) IGNITION FUSIBLE LINK@ "3 (c-80) IOD OR STORAGE CONNECTOR LIGHT KEY CYLINDER ILLUMINATION Z-67 CONNECTOR (c-83) ------- ----- J/B r DOOR SWITCH...
Seite 569 CHASSIS ELECTRICAL CIRCUIT DIAGRAM (1994 MODELS) IGNITION FUSIBLE L!NK@ 15A (> (c-74: ‘1 '3 (c-80) (c-77) IOD OR STRAGE CONNECTOR ETACS c-35 CYLINDER ILLUMINATION LIGHT TIMER CIRCUIT '-67 DATA LINK CONNECTOR (c-74 NOTE THOUT THEFT-ALARM SYSTEM TH THEFT-ALARM SYSTEM (c-77) TSB Revision...
Seite 570 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <HATCHBACK> (FROM 1995 MODELS) AND <CONVERTIBLE> (1995 MODELS) (c-8’ IOD OR STRAGE CONNECTOR LUGGAGE DOME LIGHT LUGGAGE COMPARTMENT LIGHT INDER UMINATION C-67 c-35 (c-74 (E-05)
Seite 571: Lighting System
CHASSIS ELECTRICAL IGNITION DATA LINK CONNECTOR (E-15) (E-21) NOTE THEFT-ALARM SYSTEM WITH DOOR SWITCH THEFT-ALARM SYSTEM...
Seite 572 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <CONVERTIBLE> (FROM 1996 MODELS) FUSIBLE LINK@ IOD OR STRAGE DOOR LIGHT CONNECTOR AND UGGAGE COMP RTMENT LIGHT DOOR LIGHT AND LUGGAGE COMPARTMENT LIGHT FOOT IGNITION KEY LIGHT CYLINDER ILLUMINATION LIGHT C-67 C-35 TSB Revision...
Seite 573 CHASSIS ELECTRICAL 52 -------------------------------~ NOT ' DATA LINK CONNECTOR (c-79) ( E - 2 1 ) (c-651 (c-82) (E?(m)
Seite 574 CHASSIS ELECTRICAL OPERATION <Dome light> Battery voltage is always applied to the dome light. When the dome light switch is turned to “ON”, the dome light will remain lit. After either door is opened if the dome light switch is at “DOOR” position, the dome light will come on.
Seite 575 CHASSIS ELECTRICAL Data link connector TSB Revision...
Seite 576: Input Signal
CHASSIS ELECTRICAL INPUT SIGNAL With voltmeter Data link connector When using the scan tool (MUT) or voltmeter Using the scan tool or voltmeter, check whether or not the Ground ETA,CS input signals from each switch are being input to the ETACS unit.
Seite 577: Light Switch
CHASSIS ELECTRICAL - Lighting System DOOR LIGHT AND LUGGAGE COMPARTMENT LIGHT CIRCUIT DIAGRAM <HATCHBACK> FUSIBLE LINK@ 11 (c-83) (c-71) (D-44; . MFI SYSTEM IOD OR METER CONNECTOR FOOT LIGHT AND IGNITION DOOR LIGHT/ (E-09: (D-43) TYPE SEAT 3ELT (E-01) *FOG LIGHT 4 ----- (c-34) R-B"...
Seite 578 CHASSIS ELECTRICAL. CIRCUIT DIAGRAM <CONVERTIBLE> FUSIBLE LINKG HORN (D-44) *DOME LIGHT, FOOT LIGHT AND IGNITION KEY CYLINDER ILLUMINATION 2 _---- LIGHT r - - - - R-f3 DOOR FROM (1995 MODELS) FOG LIGHT HEADLIGHT COMPARTMENT (c-34) CONNECTION DOOR SWITCH (D-04) (D-43)
Seite 579 CHASSIS ELECTRICAL - Lighting System OPERATION Battery voltage is always applied (via sub-fusible When the liftgate is opened, the luggage link No. (6) and multipurpose fuse No. (19)) compartment light switch is switched ON and to the luggage compartment light and door light. the luggage compartment light illuminates.
Seite 580 CHASSIS ELECTRICAL CIRCUIT DIAGRAM TAILLI GH :T RELAY NOTE FUSE (EXCEPT CONVERTIBLE 1996 MODELS> (c-74) . ELEPiDnhll P (G-W) ER AND GAUGES GLOVE BOX ILLUMINAT ARD LIGHT LIGHT o INSPECTION GLOVE BOX LIGHT SWITCH LIGHT SWITCH VANITY MIRROR LIGHT...
Seite 581 CHASSIS ELECTRICAL BACK-UP LIGHT CIRCUIT DIAGRAM CUP TO 1993 MODELS> IGNITION SWITCH(IG1) - _ - - _ _ - _ _ _ _ _ _ _ _ _ _ - _ - r - - - - PARK/NEUTRAL POSITION SWITCH r----- ---__--__-_____ BACK UP NOTE...
Seite 582 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <HATCHBACK> (FROM 1994 MODELS) IGNITION SWITCH(IG1) CHARGING SUPPLEMENTAL TAILLIGHT. PARKING/ SIDE MARKER LIGHT AND BACK UP PARK/NEUTRAL LIGHT POSITION SWITCH SWITCH (B-25) OFF& 3 (c-30) NOTE MODELS...
Seite 583 CHASSIS ELECTRICAL - Lighting System CIRCUIT DIAGRAM <COth/ERTIBLE> (FROM 1995 MODELS) IGNITION SWITCH(IG1) CHARGING - - - - _ _ _ _ _ - - - - - _ _ _ r - - - - - SYSTEM PARKING/ SIDE MARKER PARK/NEUTRAL POSITION SWITCH NOTE...
Seite 584 CHASSIS ELECTRICAL COMPONENT LOCATION Park/Neutral position switch 11 OPERATION When, with the ignition switch at the “ON” posi- tion, the shift lever (or the selector lever) is moved to the “R”position, the backup light switch (M/T) is switched ON (or the park/neutral posi- tion switch (A/T) is switched to the “R”...
Seite 585 CHASSIS ELECTRICAL TURN-SIGNAL LIGHT AND HAZARD LIGHT When the hazard-warning switch is switch- ed to the “ON” position, the relay contact OPERATION of the turn signal and hazard flasher unit is switched ON and OFF repeatedly, in the When the ignition switch is switched to the same manner as for the operation of the ON position, battery voltage is applied (via turn-signal lights, and the left and right turn-...
Seite 586 CHASSIS ELECTRICAL - Lighting System IGNITION BATTERY - - - - - - - - - - - - - - - - - - - - ----\ ‘52 0.85 0.85 I L L COLUMN SWITCH ( D - 0 8 ) B-Y 2 RHEOSTAT TURN SIGNAL...
Seite 587 CHASSIS ELECTRICAL TURN SIGNAL AND HAZARD FLASHER UNIT LG-I GR-L (D-45) COMBINATION FRONT COMBINATION TSB Revision...
Seite 588 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <TYPE 2> (UP TO 1993 MODELS) IGNITION BATTERY (D-41) 0. 85G-C TURN SIGNAL AND HAZARD FLASHER UNIT (E-30) - - - - - -...
Seite 589 CHASSIS ELECTRICAL COLUMN SWITCH 0. 85G-1 0. 85 FRONT COMBINATI COMBINATION TSB Revision...
Seite 590 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <HATCHBACK> (FROM 1995 MODELS) IGNITION BATTERY CHARGING ---- -------- -------- 0.85 B-Y 2 (D-41) RHEOSTAT TURN SIGNAL AND HAZARD FLASHER UNIT NOTE...
Seite 591 CHASSIS ELECTRICAL - Lighting System COLUMN SWITCH 0. 8F G-I; LG-R REAR COMBINATION B 4 (D-04: LG-R (D-41) ( F - 1 9 ) ( F - 3 0 ) TSB Revision...
Seite 592 CHASSIS ELECTRICAL - Lighting System CIRCUIT DIAGRAM <CONVERTIBLE> (FROM 1995 MODELS) IGNITION BATTERY DEDICATED FUSE CHARGING - - - - - - - - - - - - I I & G-R I G-R I 0. 85 . .---- . p!&' (D-06) DEFOGGER (D-41)
Seite 593 CHASSIS ELECTRICAL - Lighting System COLUMN SWITCH CARBURETTOR ASSEMBLY ------ 0.85 LG-R (G-L COMBINATION B 4 LIGHT (LH) 1 .< FRONT COMBINATION COMBINATION (A-39) B\P (D-41) TSB Revision...
Seite 594 CHASSIS ELECTRICAL System STOP LIGHT CIRCUIT DIAGRAM <HATCHBACK> FUSIBLE LINK@ ( c - 8 3 ) WITH WITHOUT AUTO-CRUISE CONTROL (c-61) . &&~EU'SE CONTROL SUSPENSIONz3 REAR COMBINAT HIGH MOUNTED B STOP LIGHT NOTE ACTIVE AERO WITH ACTIVE AERO TSB Revision...
Seite 595 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <CONVERTIBLE> L I N K @ FUSIBLE, . ANTI-LOCK BRAKING SYSTEM CONTROL SUSPENSION: REAR REAR COMBINATION COMBINATION NOTE TSB Revision...
Seite 596 CHASSIS ELECTRICAL HEADLIGHT AIMING PRE-AIMING INSTRUCTIONS (Up to 1993 models) 2. Observe operation of high beam light mounted in instru- ment cluster. Unit A: other 3. Inspect for badly rusted or faulty headlight assemblies. Must be These conditions must be corrected before a satisfactory used at rear tire adjustment can be made.
Seite 597 CHASSIS ELECTRICAL VERTICAL ADJUSTING Adjust the vertical angle with the vertical adjusting gear so that the bubble of the vertical angle gauge is aligned with the “0” mark position. NOTE The beam angle will change about 0’12’ with on mark. HORIZONTAL ADJUSTING Stopper Insert a screwdriver in the horizontal adjusting hole and turn...
Seite 598: Bulb Replacement
CHASSIS ELECTRICAL LUMINOUS INTENSITY MEASUREMENT Measure the luminous intensity of headlights with a photo-me- ter in accordance with the instruction manual prepared by the manufacturer of the photometer and make sure that the luminous intensity is within the following limit. Limit: 20,000 cd or more NOTE (1) When measuring the luminous intensity of headlight, keep...
Seite 599: Removal And Installation
CHASSIS ELECTRICAL - Lighting System REMOVAL AND INSTALLATION (From 1994 models) (Up to 1993 models) 00002389 Removal steps (Up to 1993 models) Removal steps (From 1994 models) Headlight bezel, upper 1. Front combination light 2. Headlight bezel, lower 2. Headlight 3.
Seite 600 CHASSIS ELECTRICAL Using a flat head screwdriver (wrap cloth or similar on the ball joint area to prevent injury), disconnect the connec- tor. NOTE When disconnecting the rod assembly from the link, hold the link by hand. INSPECTION POP-UP MOTOR (Up lo 1993 models) CHECK Rotate the manual knob of the pop-up motor clockwise by hand to check continuity between terminals.
Seite 601 CHASSIS ELECTRICAL - Lighting System FOG LIGHT REMOVAL AND INSTALLATION (Up to 1993 models) (From 1994 models) _ ~___ .._. ____ y-- ..--‘-T--- .. , ‘!U , . I , / I i (From 1994 models) Removal steps (Up to 1993 models)
Seite 602 CHASSIS ELECTRICAL - Lighting System FRONT COMBINATION LIGHT AND OPTICAL HORN LENS REMOVAL AND INSTALLATION (Up to 1993 models) (From 1994 models) 00002392 Removal steps REAR COMBINATION LIGHT AND LICENSE PLATE LIGHT REMOVAL AND INSTALLATION Removal steps TSB Revision...
Seite 603 CHASSIS ELECTRICAL - Lighting System HIGH MOUNTED STOP LIGHT REMOVAL AND INSTALLATION without rear without rear 00002393 00002393 Removal steps Removal steps 1. Liftgate lower trim 4A, HIGH-MOUNTED STOP LIGHT REMOVAL (Vehicles with fixed rear spoiler)
Seite 604 CHASSIS ELECTRICAL RELAY INSPECTION HEADLIGHT RELAY / TAILLIGHT RELAY / FOG LIGHT RELAY CHECK Connect battery to terminal 1 and check continuity between terminals with terminal 3 grounded. Power is supplied terminals Continuity Power is not supplied terminals No continuity Continuity POP-UP MOTOR RELAY (Up to 1993 models) CHECK Check for continuity between terminals under the conditions...
Seite 605 CHASSIS ELECTRICAL - Lighting System POP-UP SWITCH* AND FOG LIGHT SWITCH REMOVAL AND INSTALLATION Removal steps l : Up to 1993 models REMOVAL SERVICE POINTS Front of vehicle UPPER REMOVAL After the screws have been removed, remove the covers, while making sure not to break the grippers. INSPECTION Operate the switch to check for continuity between terminals.
Seite 606 CHASSIS ELECTRICAL - Lighting System RHEOSTAT INSPECTION (1) Remove the instrument panel switch from the knee protec- tor. (2) Connect the battery and a test bulb (40 W) as shown in the figure. (3) The function of the rheostat is normal if the intensity of illumination changes smoothly, without flashing or flicker- ing, when the rheostat is operated.
Seite 607: General Specifications
54-111 CHASSIS ELECTRICAL - Column Switch SPECIFICATIONS GENERAL SPECIFICATIONS SPECIAL TOOL Revision...
Seite 608 54-112 CHASSIS ELECTRICAL - Column Switch COLUMN SWITCH REMOVAL AND INSTALLATION Removal steps REMOVAL SERVICE POINTS Caution Do not hammer on the steering wheel. Doing so may damage the collapsible column mechanism.
Seite 609 CHASSIS ELECTRICAL - Column Switch Front of vehicles PER REMOVAL After the screws have been removed, remove the covers, while making sure not to break the grippers. INSTALLATION SERVICE POINT To center the clock spring, line up the “NEUTRAL” mark of the clock spring with the mating mark.
Seite 610 54-114 CHASSIS ELECTRICAL - Column Switch TURN SIGNAL SWITCH CHECK Operate the switch and check the continuity between the termi- DIMMER/PASSING SWITCH CHECK Operate the switch and check the continuity between the termi- WIPER AND WASHER SWITCH Refer to GROUP 51 - Windshield Wiper and Washer. TSB Revision...
Seite 611: Component Location
CHASSIS ELECTRICAL - Horn SPECIFICATIONS GENERAL SPECIFICATIONS Horn (Except for theft-alarm horn) Theft-alarm horn TROUBLESHOOTING COMPONENT LOCATION OPERATION TROUBLESHOOTING HINTS The horn switch always receives battery voltage 1. One of the horn does not sound. via the dedicated fuse (6) and the coil of the Check the horn.
Seite 612 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <VEHICLES WITHOUT THEFT-ALARM SYSTEM> . ANTI-LOCK BRAKING SYSTEM AND IGNITION KEY CYLINDER ILLUMINATION LIGHT COMPARTMENT LIGHT 'ELECTRONIC CONTROL SUSPENSION: FOG LIGHT FULL AUTO A/C 'HEADLIGHT 'MANUAL A/C . MFI SYSTEM TAPE PLAYER . REAR WINDOW DEFOGGER .
Seite 613 5 4 - 1 1 7 CHASSIS ELECTRICAL <VEHICLES WITH THEFT-ALARM SYSTEM> DEDICATED FUSE HORN RELAY "3 DIODE c-12 HORN TSB Revision...
Seite 614 CHASSIS ELECTRICAL HORN SWITCH REMOVAL AND INSTALLATION (UP TO 1993 MODELS) ~ Removal steps (FROM 1994 MODELS) T h e by itself. If it is faulty, replace the steering wheel assembly. RELAY INSPECTION HORN RELAY CHECK Connect battery to terminal 1 and check continuity between terminals with terminal 3 grounded.
Seite 615 CHASSIS ELECTRICAL SPECIFICATIONS GENERAL SPECIFICATIONS TSB Revision...
Seite 616: Circuit Diagram
CHASSIS ELECTRICAL TROUBLESHOOTING CIRCUIT DIAGRAM <UP TO 1995 MODELS> IGNI SWIT DEDICATED F U S E 0.851 0. 851 0.851 REMOTE CONTROLLED G-' -- ---- -- _----- --__. 0.851 . WINDSHIELD ' ASHTRAY ILLUMINATION LIGHT (D-17) 0.85 0.85 0.85 RHEOSTAT NOTE...
Seite 617 CHASSIS ELECTRICAL 54-121 CIRCUIT DIAGRAM <FROM 1996 MODELS> IGNITION "5 (c-83) 0.851 0.851 0. 851 CIGARETTE LIGHTER 0.85 0.85 B-Y gG4 RHEOSTAT NOTE...
Seite 618 54-122 NOTES TSB Revision...
Seite 619 CHASSIS ELECTRICAL - Cigarette Lighter CIGARETTE LIGHTER REMOVAL AND INSTALLATION Removal steps Console side cover (RH) 5. Plate Plug Socket 3. Fixing ring 7. Protector INSPECTION Take out the plug, and check for a worn edge on the element spot connection, and for shreds of tobacco or other material on the element.
Seite 620: Radio And Tape Player
CHASSIS ELECTRICAL TROUBLESHOOTING CIRCUIT DIAGRAM (1992 model) FUSIBLE LINKa J/B 1 2L T IOD OR STORAGE IOD OR STORAGE CONNECTOR CONNECTOR ------ MOTOR : RELAY ! i - I I I (R-B: RADIO AND TAPE PLAYER...
Seite 621 CHASSIS ELECTRICAL - Radio and Tape Player 54-125 REMOTE CONTROL SWITCH DEDICATED FUSE ------- RADIO AND TAPE PLAYER RHEOSTAT REAR SPEAKER TSB Revision...
Seite 622: Cd-Player
CHASSIS ELECTRICAL CIRCUIT DIAGRAM (1992 model) (CONTINUED) REAR WINDOW GLASS ANTENNA CD PLAYER RADIO AND TAPE PLAYER JUMPER CONNECTOR (F-39) (E-32) ,23_- (c-15) cm: DOOR DOOR SPEAKER SPEAKER FRONT SPEAKER (E-04) (E-29) ETz9 (D-02) (D-13) (D-34) (F-39) TSB Revision...
Seite 623 NOTES...
Seite 624 54-128 CHASSIS ELECTRICAL CIRCUIT DIAGRAM (1993 models) IGNITION IGNITION FUSIBLE LINK@ 4 ------------__ (c-78: "3 CmTg 2L I IOD OR IOD OR STORAGE STORAGE CONNECTOR CONNECTOR MOTOR I RELAY / SPARE (F-31); CONNECTOR (CD CHANGER (F-40) (R-B I \/ 0 ---------------- (D-34) RADIO AND TAPE PLAYER (c-81)
Seite 625 CHASSIS ELECTRICAL RADIO AND TAPE PLAYER ----- ------ ----- ------ ---- --- ---- --- GR-L GR-L GR-R B GR-R B Y-R B-Y Y-R B-Y _______ J ------ :? (c-15) RHEOSTAT RHEOSTAT REAR SPEAKER (D-34) (D-35) (D-36) (D-47) (F-06) TSB Revision...
Seite 626 CHASSIS ELECTRICAL CIRCUIT DIAGRAM (1993 models) (CONTINUED) REAR WINDOW GLASS ANTENNA CD PLAYER RADIO AND TAPE PLAYER JUMPER CONNECTOR (F-39) DOOR DOOR SPEAKER SPEAKER FRONT SPEAKER TSB Revision...
Seite 627 NOTES TSB Revision...
Seite 628 CHASSIS ELECTRICAL - Radio and Tape Player CIRCUIT DIAGRAM (1994 models-Radio and Tape Player with Amplifier) IGNITION FUSIBLE LINK@ IOD OR STORAGE CONNECTOR CONNECTOR MOTOR I ANTENNA j R-B (R-E CONTROL- I "2 RADIO AND TAPE PLAYER TSB Revision...
Seite 629 CHASSIS ELECTRICAL IGHT DEDICATED FUSE ---1 RADIO AND TAPE PLAYER --- _; (D-47) RHEOSTAT...
Seite 630 54-134 CHASSIS ELECTRICAL CIRCUIT DIAGRAM (From 1994 models-Radio and Tape Player with Amplifier) (CONTINUED) REAR WINDOW GLASS ANTENNA RADIO AND TAPE PLAYER AMPLIFIER ---- __. (c-34) 7 > (F-19) 1 -- (F-06) FRONT DOOR R E A R SPEAKER SPEAKER SPEAKER (c-15) (D-02) ~~ (D-16)
Seite 632 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <Hatchback (From 1994 models-Radio and Tape Player without Amplifier)> IGNITION FUSIBLE LINK@ SWITC HORN CHARGING 2B-W (c-78: 10 (c-81 0.85 IOD OR STORAGE CONNECTOR CONNECTOR 1 .------ RADIO AND TAPE PLAYER...
Seite 633 CHASSIS ELECTRICAL 54-137 RADIO REMOTE RADIO REMOTE CONTROL SWITCH CONTROL SWITCH CLOCK SPRING MODELS) RADIO AND TAPE PLAYER ------ ------ R (T)GR-R ------ RHEOSTAT REAR SPEAKER (F-06) FTC9...
Seite 634 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <Hatchback (From 1994 models-Radio and Tape Player without Amplifier)> (CONTINUED) REAR WINDOW GLASS ANTENNA RADIO AND TAPE PLAYER ‘0 (D-42) (E-01) 14 (E-32) (D-13) (E-04) DOOR SPEAKER SPEAKER FRONT SPEAKER...
Seite 635 NOTES TSB Revision...
Seite 636 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <Hatchback (From 1995 models-Radio and Tape Player with Amplifier)> IGNITION IGNITION FUSIBLE LINK@ HORN ------- ----_ J/B 1 IOD OR STORAGE CONNECTOR CONNECTOR ------ I---- MOTOR I UNIT (F-40) ! (D-47) RADIO AND TAPE PLAYER TSB Revision...
Seite 637 54-141 CHASSIS ELECTRICAL REAR WINDOW GLASS ANTENNA RADIO AND TAPE PLAYER AMPLIFIER ---- --__. 1 .------__ 13 1-------_ 1 ------ FRONT SPEAKER TSB Revision...
Seite 638 54-142 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <Hatchback (From 1995 models-Radio and Tape Player with Amplifier)> (CONTINUED) AMPLIFIER ------ 1. 25 (F-19) GR-I REAR SPEAKER...
Seite 639 CHASSIS ELECTRICAL RADIO AND TAPE PLAYER (D-47) 1 ------. CLOCK SPRING . ,$&AND RADIO REMOTE CONTROL SWITCH TSB Revision...
Seite 640 CHASSIS ELECTRICAL - Radio and Tape Player CIRCUIT DIAGRAM <Convertible (1995 models-Radio and Tape Player with Amplifier)> IGNITION IGNITION FUSIBLE LINK@ HORN CHARGING 33-W - - - - - - - - (c-83: R-Y t IOD OR STORAGE IOD OR STORAGE CONNECTOR BUZZER r----- -------...
Seite 641 54-145 CHASSIS ELECTRICAL REAR WINDOW GLASS ANTENNA --l-- RADIO AND TAPE PLAYER AMPLIFIER -------- 0.859-L 13 ---- --__. TSB Revision...
Seite 642 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <Convertible (1995 models-Radio and Tape Player with Amplifier)> (CONTINUED) AMPLIFIER (E-39) . HEATER - - - ------ . FULL AUTO A/C 7 ---___ 6 --__-- GR-L RHEOSTAT RADIO REMOTE CONTROL SWITCH REAR SPEAKER TSB Revision...
Seite 643 54-147 NOTES TSB Revision...
Seite 644 54-148 CHASSIS ELECTRICAL - Radio and Tape Player CIRCUIT DIAGRAM <Convertible (1995 models-Radio and Tape Player without Amplifier)> IGNITION IGNITION FUSIBLE LINKB CHARGING 2B-w -------------- ,,7(c-82) - - - - - - - - "3 (c-70) "3 (c-80) 2L t B - W IOD OR STORAGE IOD OR STORAGE...
Seite 645 CHASSIS ELECTRICAL RADIO REMOTE CONTROL SWITCH CLOCK SPRING . HEATER . MANUAL A/C . FULL AUTO A/C RADIO AND TAPE PLAYER ------ . FULL AUTO A/C . MANUAL A/C . ELC-4A/T . b&&&AND . FOG LIGHT RHEOSTAT SPEAKER (D-36) (D-47) (F-33) TSB Revision...
Seite 646 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <Convertible (1995 models-Radio and Tape Player without Amplifier)> (CONTINUED) REAR WINDOW GLASS ANTENNA RADIO AND TAPE PLAYER (D-13) (E-04) DOOR SPEAKER SPEAKER TSB Revision...
Seite 647 NOTES TSB Revision...
Seite 648 54-152 CHASSIS ELECTRICAL - Radio and Tape Player CIRCUIT DIAGRAM <Convertible (From 1996 models)> FUSIBLE LINK@ HORN CHARGING 2B-W ---- -------- ‘1 2L 1 2L 0.g; IOD OR STORAGE IOD OR STORAGE BUZZER CONNECTOR CONNECTOR (A-~IX) B-W MOTOR UNIT "6 (A-79) CABLE RADIO AND TAPE PLAYER...
Seite 649 CHASSIS ELECTRICAL REAR WINDOW GLASS ANTENNA RADIO AND TAPE PLAYER 2L 2L AMPLIFIER 0. 85W-1 0. 85B-1 1 ------ -_ ( D - 0 2 ) - FRONT DOOR SPEAKER SPEAKER TSB Revision...
Seite 650 54-154 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <Convertible (From 1996 models)> (CONTINUED) IGHT RELA AMPLIFIER (E-39) HEATER RADIO AND TAPE PLAYER (D-47) (Y-W) NO CONNECTION RHEOSTAT RADIO REMOTE CONTROL SWITCH TSB Revision...
Seite 651: Component Location
CHASSIS ELECTRICAL COMPONENT LOCATION Motor antenna control unit ___...
Seite 652: Radio And Tape Player With Anti-Theft
CHASSIS ELECTRICAL RADIO AND TAPE PLAYER WITH ANTI-THEFT SYSTEM When power supply is reconnected after set has been removed from vehicle (after BATT line of set has been disconnected for more than one hour), what can be effectively performed is only supply of power made by POWER button operation.
Seite 653 CHASSIS ELECTRICAL Continued from previous Page Is changeoverto normal operation made by placing POWER button Faulty set to ON position while pressing EJECT button? Is power supply cut off automatically to return to no display state Faulty set after three-minute operation? Does manufacturing numberof set agree with identification number Error in attaching card (For set manufacturing number identification on card?
Seite 654: Trouble Shooting Chart
54-158 CHASSIS ELECTRICAL - Radio and Tape Player TROUBLESHOOTING CHART TSB Revision...
Seite 655 54-159 CHASSIS ELECTRICAL - Radio and Tape Player CHART A. NOISE Noise appears at certain places when traveling (AM). Is there a particular st Do the following measures eliminate the noise? 1. Change to a different station with a strong signal to boost resistance to interference.
Seite 656 CHASSIS ELECTRICAL - Radio and Tape Player Noise appears at certain places when traveling (FM). Do the following measures eliminate the noise? Change to a different station with a strong signal to boost resistance to interference. Suppress high tones to reduce noise. Extend antenna completely.
Seite 657 CHASSIS ELECTRICAL Mixed with noise, only at night (AM). The following factors can be considered as possible to a different station or the appearance of a causes of noise appearing at night. beating sound* may occur. 1. Factors due to signal conditions: Due to the Beat sound*: Two signals close in frequency fact that long-distance signals are more easily interfere with each other, creating a repetitious...
Seite 658 CHASSIS ELECTRICAL Broadcasts can be heard but both AM and FM have a lot of noise. Noise occurs when the engine is stopped. Noise occurs when the engine in running. Do the following measures eliminate the noise? @ Tune to a station with a strong signal. Extend the antenna completely.
Seite 659 CHASSIS ELECTRICAL - Radio and Tape Plaver There is more noise either on AM or on FM. 1. There is much noise onlv on AM Due to differences in AM and FM systems, AM is more susceptible to noise interference. Were conditions such as the following present when noise was received? Lightning was flashing.
Seite 660 54-164 CHASSIS ELECTRICAL - Radio and Tape Player There is noise when starting the engine. Caution against A.C.) decreases, and current flow is 1. Connecting a high tension cable to the noise facilitated. A noise suppressing condenser filter may destroy the noise filter and should which takes advantage of this property is in- never be done.
Seite 661 CHASSIS ELECTRICAL NOISE SUPPRESSION PARTS MOUNTING POSITIONS e con::;;, TSB Revision...
Seite 662 54-166 Some noise appears when there is vibration or shocks during traveling. Are connectors properly connected? Static electricity noise: Does noise appear when the radio switch is turned on while the No Body static electric from the shock absorber rubber bushings used vehicle is stopped and the radio is struck while tuned away from to prevent vibration, tires, etc.
Seite 663 54-167 CHASSIS ELECTRICAL - Radio and Tape Player Noise sometimes appears on FM during traveling. Is the antenna completely extended? (Refer to E-l, 2.) Does the problem clear up when re Does the problem appear only in certain locations and only with yes certain stations? noise*, fading noise*).
Seite 664 54-168 CHASSIS ELECTRICAL - Radio and Tape Player Ever-present noise. Noise is often created by the following factors, and For this reason, if there are still problems with noise often the radio is OK when it is checked individually. even after the measures described in steps A-l Traveling conditions of the vehicle to A-8 have been taken, get information on the fac- Terrain of area traveled through...
Seite 665 54-169 CHASSIS ELECTRICAL - Radio -and Tape Player There is noise but no reception for both AM and FM or no sound from AM, or no sound from FM. Example: in an underground garage or Is proper performance Check the antenna itself. Is the antenna completely extended? Does tuning solve the problem? Are the antenna plug and radio unit properly connected?
Seite 666 CHASSIS ELECTRICAL Is proper performance’obtained when the ve- Check the antenna itself. Is the antenna completely extended? (Refer to E-l, 2.) Electrical field condition related*. (multipath noise or fading noise) from a specific position? Is the antenna plug properly connected to the unit? Ensure proper connection.
Seite 667 CHASSIS ELECTRICAL Distortion on AM or on both AM and FM. Are the speaker cords in contact with the cone paper? Remove cords away from cone pa- per. Remove the speakers and check for tom cone paper or foreign objects. Repair or replace speakers.
Seite 668 CHASSIS ELECTRICAL Too few automatic select stations. Check the antenna itself. Is the antenna completely extended? Is the antenna plug properly connected to the equipment? Ensure proper connection. Does the equipment work properly if the radio is changed? Repair or replace radio. lnsuff icient memory (preset stations are erased).
Seite 669: Cassette Player
54-173 CHASSIS ELECTRICAL C. CASSETTE PLAYER Cassette tape will not be inserted. Are there any foreign objects in the cassette player? Remove the object(s)” “1 Attempting to force a foreign object (e g.. a coin or clip, etc.) out of the cassette player may damage the mechanism. The player should be taken to a service dealer for repair.
Seite 670 CHASSIS ELECTRICAL No sound from one speaker. Repair or replace cassette player. Replace the cassette player and check again. the speaker harness for conductance. shorted out. Repair speaker harness and ensure Check the speaker for conductance. proper connection of relay connectors. Repair or replace speaker.
Seite 671 CHASSIS ELECTRICAL - Radio and Tape Player 54-175 Sound quality is poor, or sound is weak. Ensure that the tape label is not loose, that the tape itself is not deformed and that the tape is tightly wound. Tapes of C-i 20 or greater length often get caught in the mechanism and should not be used.
Seite 672 54-176 CHASSIS ELECTRICAL Uneven revolution. Tape speed is fast or slow. Are there any foreign objects inside the cassette player? Remove foreign object(s). I s the head or capstan roller dirty? Automatic search does not work. Does the MSS (automatic search) button” depress properly? Button improperly operated.
Seite 673 54-177 CHASSIS ELECTRICAL Faulty auto reverse. Does the player play OK if the tape is changed? Ensure that the tape label is not loose, that the tape itself is not deformed and that the tape is tightly wound. Tapes of C-120 or greater length often get caught in the mechanism and should not be used.
Seite 674: Cd-Player
CHASSIS ELECTRICAL D. CD PLAYER CD will not be accepted. Take out the CD. Does the shutter open when a CD is inserted? Though CD is completely inserted once, “e CD is rejected? Check CD. Is the labeled side faced downward? CD is defective.
Seite 675 54-179 CHASSIS ELECTRICAL No sound. Does it play if an existing proper CD is inserted? ) ture, and recheck operation. Does it operate properly? I No Are the radio set and CD player connected Repair or replace CD player. (The combined radio cassette must operate properly.) CD sound skips.
Seite 676 CHASSIS ELECTRICAL - Radio and Taste Plaver Sound quality is poor. Does it play properly if another proper CD is loaded? Replace CD. Repair or replace CD player. CD will not be ejected. Is the key switch (ignition key) at ACC or ON? Turn the key to ON.
Seite 677: Motor Antenna/Antenna Feeder Cable/Amplifier
CHASSIS ELECTRICAL E. MOTOR ANTENNA Motor antenna won’t extend or retract. Clean and polish the surface of the antenna rod. Is the radio power switch ON? Switch it ON. Is voltage (approx. 12 V) emitted to the radio’s motor antenna terminal’? Repair or replace the radio.
Seite 678 54-182 CHASSIS ELECTRICAL Motor antenna extends and retracts but does not receive. Is the antenna’ itself OK? Repair or replace it. Is operation normal when a new antenna assembly is directly installed Refer to B. “Radio troubleshooting”. to the radio?
Seite 679 54-183 CHASSIS ELECTRICAL PROCEDURE FOR INPUTOFSECURITYCODE FOR RADIO AND TAPE PLAYER WITH ANTI-THEFT SYSTEM The radio and tape player does not operate in the following states. (1) Power supply to the radio and tape player has been sus- pended for more than one hour continuously by removing the cable from the battery terminal or disconnecting the harness connectors.
Seite 680 CHASSIS ELECTRICAL - Radio and Tape Plaver Return power supply for the radio and player to the normal state. POWER button Disp’ay PROG button 3. Turn the ignition key to the “ACC” position. 4. Press the POWER button, and “code” will be displayed on the display.
Seite 681 54-185 CHASSIS ELECTRICAL After the erasing, therefore, repeat step 3 and up. If the ignition key is turned to the “OFF” position during one-hour period of keeping it in “ACC” or “ON” position, the “OFF” display will be erased. With the ignition key placed in the “ACC” position again, press the POWER button, and the “OFF”...
Seite 682: Radio Remote-Control
54-186 CHASSIS ELECTRICAL RADIO REMOTE-CONTROL REMOVAL AND INSTALLATION CAUTION: SRS <From 1994 modek> When removing and installing the remote control switch, Before removal of air bag module, refer to GROUP 52B - don’t allow any impact or shock to the air bag module. Service Precautions and Air Bag Module and Clock Spring.
Seite 683: Speaker
CHASSIS ELECTRICAL - Radio and Tape Plaver SPEAKER REMOVAL AND INSTALLATION <DOOR SPEAKER> <REAR SPEAKER> 00002404 Rear speaker removal steps Door speaker removal steps 1. Door trim (Refer to GROUP 42 - Door Trims.) Trim and Waterproof Film.) 2. Speaker garnish 2.
Seite 684 54-188 CHASSIS ELECTRICAL MOTOR ANTENNA / ANTENNA FEEDER CABLE / AMPLIFIER REMOVAL AND INSTALLATION <Hatchback> Motor antenna removal steps Antenna feeder cable removal steps Rear side trim (LH) Rear side trim (LH)*l (Refer to GROUP 52A - Trims.) Quarter trim (LH)” 1.
Seite 685 CHASSIS ELECTRICAL REMOVAL SERVICE POINT Raise and remove the seat cushion with the lever pulled. INSTALLATION SERVICE POINT (1) Securely fit the attachment wire of the seat cushion under the seatback. (2) Pass the inner seat belt buckles through the cushion. (3) Securely fit the lock plates of the seat cushion into the holes in the floor.
Seite 686 CHASSIS ELECTRICAL - Radio and Tape Player ANTENNA POLE REPLACEMENT (1) Remove the ring nut. Ring nut (2) Set the radio switch to ON. After the antenna pole has extended, remove the antenna pole and rack cable as an assembly. (3) Extend the antenna pole up to its farthest point.
Seite 687 CHASSIS ELECTRICAL CD AUTO CHANGER REMOVAL AND INSTALLATION 0 0 0 0 2 4 0 8 Removal steps 1. CD changer cover 2. CD auto changer 3. CD changer bracket (front) 4. CD changer bracket (rear) TSB Revision...
Seite 688: Rear Window Defogger
54-192 CHASSIS ELECTRICAL SPECIAL TOOLS TSB Revision...
Seite 689: Circuit Diagram
CHASSIS ELECTRICAL TROUBLESHOOTING CIRCUIT DIAGRAM (UP TO 1993 MODELS) REMOTE CONTROLLED MIRROR “1 (B-Y) 4 DATA LINK CONNECTOR DEFOGGER RHEOSTAT THEFT-ALARM SYSTEM THEFT-ALARM SYSTEM TSB Revision...
Seite 690 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <HATCHBACK (FROM 1994 MODELS)> IGNITION GENERATOR FUSIBLE LINK@ (D-45) JO CHARGING pa-u (c-65) 2% (c-65) (c-66) MIRROR NOTE THEFT-ALARM SYSTEM. THEFT-ALARM SYSTEM. TSB Revision...
Seite 691 54-195 CHASSIS ELECTRICAL FUSIBLE LINK@ TAILLI GH' T RELAY HORN ‘11 DOOR LIGHT AND LUGGAGE C O M P A R T M E N T CONNECTOR PARKING/SIDE MARKER LIGHT AND LICENSE (D-41) PLATE LIGHT ETACS ECU (D-41) RHEOSTAT NOTE THEFT-ALARM SYSTEM.
Seite 692: Defogger Relay
CHASSIS ELECTRICAL CIRCUIT DIAGRAM <CONVERTIBLE (1995 MODELS)> IGNITION GENE F'JSIBL E LINK@ SWITC CHARGING (D-45) L-RI DEFOGGER RELAY MFI SYSTEM REMOTE NOTE THEFT-ALARM SYSTEM. THEFT-ALARM SYSTEM.
Seite 693 CHASSIS ELECTRICAL FUSIBLE LINKa TAILLIGHT RELAY HORN ‘J/B ------ A/1 DOOR LIGHT AND LUGGAGE COMPARTMENT LIGHT IOD OR STRAGE CONNECTOR PARKING/SIDE MARKER LIGHT AND LICENSE PLATE LIGHT DEFOGGER SWITCH 5 DATA LINK CONNECTOR (D-41) RHEOSTAT NOTE THEFT-ALARM SYSTEM. THEFT-ALARM SYSTEM. TSB Revision...
Seite 694 CHASSIS ELECTRICAL - Rear Window Defogger CIRCUIT DIAGRAM <CONVERTIBLE (FROM 1996 MODELS)> IGNITION FUSIBL CHARGING CHARGING MFI SYSTEM ( c - 6 6 ) 5 2 REMOTE CONTROLLED MIRROR...
Seite 695 CHASSIS ELECTRICAL - Rear Window Defogger FUSIBLE LINKa TAILLIGHT RELAY DOOR LIGHT AND LUGGAGE , \, (c-71) IOD OR STRAGE CONNECTOR PARKING/SIDE MARKER LIGHT AND LICENSE PLATE LIGHT (D-41) DEFOGGER SWITCH (D-06) 5 DATA LINK CONNECTOR RHEOSTAT Revision...
Seite 696 CHASSIS ELECTRICAL OPERATION If the defogger switch is turned to “ON” when the generator is generating electricity (L terminal exceeds 10 V.) with the ignition switch at the “ON” position, the timer circuit in the ETACS unit will be operated to keep the transistor “on”...
Seite 697 CHASSIS ELECTRICAL Revision...
Seite 698 CHASSIS ELECTRICAL - Rear Window Defogger INPUT SIGNAL With voltmeter Data link connector When using the scan tool (MUT) or voltmeter Using the scan tool or voltmeter, check whether or not the input signals from each switch are being input to the ETACS unit.
Seite 699: On-Vehicle Service
CHASSIS ELECTRICAL - Rear Window Defogger ON-VEHICLE SERVICE Normal characteristic curve Voltage THE PRINTED-HEATER LINES CHECK (1) Run engine at 2,000 rpm. Check heater element with bat- tery at full. (2) Turn ON rear window defogger switch. Measure heater element voltage with circuit tester at rear window glass Positive Printed heater line center A.
Seite 700 54-204 CHASSIS ELECTRICAL - Rear Window Defogger DEFOGGER RELAY 1994 model INSPECTION Connect battery power source to terminal 5. Check circuit between terminals with terminal 3 grounded. 00002410 Connect battery power source to terminal 1. Check circuit between terminals with terminal 3 grounded. 00002411 TSB Revision...
Seite 701: Special Tools
CHASSIS ELECTRICAL - Theft-alarm Svstem Tool number and name Supersession Application MB991 341 MB991 341 C Up to 1993 models Checking the theft-alarm system Scan tool (Multi-use tester ROM Pack (For the number, refer to GROUP 00 - Precautions Before Service.) MB991 502 All models...
Seite 702: Troubleshooting
CHASSIS ELECTRICAL - Theft-alarm Svstem (UP TO 1993 MODELS) CIRCUIT DIAGRAM IGNITION IGNITION HEADLIGHT RELAY c-77) 16 0.85 , B-W "2 / ----- --A 3 _---- ,,6 LIGHT AUTOMATIC 0 SHUT-OFF UNIT...
Seite 703 CHASSIS ELECTRICAL LINK 6 b (c-77) ‘10 IOD OR STORAGE CONNECTOR B l6...
Seite 704 CHASSIS ELECTRICAL - Theft-alarm System CIRCUIT DIAGRAM (CONTINUED) LIGHT IGNITION AUTOMATIC SHUT-OFF UNIT M/T " G-E3 (1992 MODEL> *cl993 MODEL> LG-B G-B 3 POSITION STARTER RELAY LG-E A/T * Revision...
Seite 705 CHASSIS ELECTRICAL - Theft-alarm System FUSIB E LINK (c-76) DIODE c-12 ETACS UNIT CLOCK HORN SPRING HORN HORN SWITCH 9 ~ 1 0 ~ 1 1 ~ ~ 1 2 / 1 3 ~ 1 4 1 1 5 1 1 6 l 1 ? ~ ~ 1 6 ~ 1 9 TSB Revision...
Seite 706 CHASSIS ELECTRICAL CIRCUIT DIAGRAM <HATCHBACK (FROM 1994 MODELS)> FUSIBLE LINK@ IGNITION IGNITION SWITCH(ACC) FOG LIGHT HEAD SIDE MARKER LIGHT LIGHT AND RELAY c-7’ WITHOUT ACCESSORY ACCESS (R-Y I - - L CIGARETTE BACK-UP LIGHT LIGHTER RADIO AND TAPE PLAYER (R-Y (R-Y) HEADLIGHT (R-Y...
Seite 707 CHASSIS ELECTRICAL FUSIBLE LINK@ NATION IOD OR STORAGE CONNECTOR (E-17) LOCKING B-L --------------- ---------- J, EQ(c-66) ETACS UNIT 2B l6 TSB Revision...
Seite 708 CHASSIS ELECTRICAL CIRCUIT DIAGRAM (CONTINUED) LIGHT AUTOMATIC IGNITION SHUT-OFF UNIT M/T y A/T 20-Y - STARTER RELAY _______ MFI SYSTEM LG-B SUPPLEMENTAL SYSTEM MFI SYSTEM BATTERY ----- 16 16 -5 -5 DATA LINK CONNECTOR (c-79) FRONT SIDE...
Seite 709 CHASSIS ELECTRICAL LINK s b DEDICATED FUSE (c-76) (c-57) ETACS UNIT (c-66) (A-26) (A-47) CLOCK HORN SPRING HORN (A-27) CYLINDER LOCK (F-24) SWITCH (F-23) HORN SWITCH TSB Revision...
Seite 710 CHASSIS ELECTRICAL - Theft-alarm Svstem CIRCUIT DIAGRAM <CONVERTIBLE (FROM 1995 MODELS)> FUSIBLE LINK@ IGNITION I IGNITION SWITCH(ACC) , 2R-B 7 -----_---------------- FOG LIGHT ------- LIGHT AND LICENSE PLATE LIGHT BACK-UP LIGHT (R-Y) ---------------- HEADLIGHT (R-k (c-34) LIGHT AUTOMATIC SHUT-OFF UNIT (E-17) Y-B 5 DOOR SWITCH...
Seite 711: Theft-Alarm System
CHASSIS ELECTRICAL FUSIBLE LINK@ STORAGE CONNECTOR L1GHT AUTOMATIC (E-17) A-- - - - - - - - - - - - - - - --1 r TSB Revision...
Seite 712 CHASSIS ELECTRICAL - Theft-alarm System CIRCUIT DIAGRAM (CONTINUED) LIGHT AUTOMATIC IGNITION SHUT-OFF UNIT 2%-Y M/T ! A/T CLUTCH PEDAL POSITION SWITCH A/T i M/T MFI SYSTEM MFI SYSTEM ----- BATTERY DATA LINK CONNECTOR ( A - 6 6 ) SIDE...
Seite 713 CHASSIS ELECTRICAL DEDICATED FUSE DIODE c-12 ETACS UNIT (A-47) CLOCK SPRING I 10 HORN SWITCH TSB Revision...
Seite 714: Component Location
CHASSIS ELECTRICAL - Theft-alarm System COMPONENT LOCATION 0 0 0 0 2 4 1 2...
Seite 715 CHASSIS ELECTRICAL - Theft-alarm System <Vehicles with keyless entry <Vehicles without keyless entry Revision...
Seite 716 CHASSIS ELECTRICAL - Theft-alarm Svstem TROUBLESHOOTING GUIDE With voltmeter CHECKING THE INPUT When using the scan tool (MUT) or voltmeter 1. Connect a voltmeter between terminal for ETACS and terminal for ground, or connect the scan tool to the data link connector.
Seite 717 CHASSIS ELECTRICAL - Theft-alarm Svstem 2. Make sure that when the following switches are turned on, the output shown in the illustration is delivered. (Only those switches which are related to the theft-alarm system are listed here.) Driver and front passenger door switches Headlight switch Driver and front passenger door lock switches Passing light switch...
Seite 718 CHASSIS ELECTRICAL - Theft-alarm System TROUBLESHOOTING QUICK-REFERENCE TABLE For information concerning the locations of electrical components, refer to GENERAL-Theft-alarm System Circuit. ARMING / DISARMING RELATIONSHIP Trouble symptom Cause Check method Remedy The system is not armed (The Damaged or disconnected Check by using check Replace the fusible link SECURITY light doesn’t illumi-...
Seite 719 CHASSIS ELECTRICAL - Theft-alarm System Trouble symptom Cause Check method Remedy Damaged or disconnected There is no alarm when, as an If input checks Repairthe harness or re- alarm test, the hood is opened wiring of hood switch input place the hood switch. from within the vehicle.
Seite 720 CHASSIS ELECTRICAL - Theft-alarm Svstem CHECKING THE CIRCUIT AND INDIVIDUAL PART 1. ETACS POWER-SUPPLY AND GROUND CIRCUITS Description of operation The battery supplies a stabilized 5 V power supply to the ECU, via the constant-voltage circuit and terminal 51 (which is directly connected to the battery).
Seite 721 CHASSIS ELECTRICAL 3. HOOD SWITCH INPUT CIRCUIT Description of operation When the hood is closed (the hood switch is switched OFF), HIGH-level signals are sent to the ECU: When the hood is opened (the hood switch is switched ON), LOW-level signals are sent to the ECU. ECU terminal voltage (Connection condition of the.
Seite 722 CHASSIS ELECTRICAL 5. DOOR LOCK ACTUATOR SWITCH INPUT CIRCUIT Description of operation When a door is locked by the lock knob or the key, the door lock actuator switch is switched OFF, and HIGH-level signals are sent to the ECU. These signals activate the timer circuit of the R ECU, thereby causing the activation circuit to function, thus R activating the door lock actuator of all doors.
Seite 723 CHASSIS ELECTRICAL 6. DOOR KEY CYLINDER UNLOCK AND LIFTGATE CYLINDER LOCK SWITCH INPUT CIRCUIT Description of operation When the door key is rotated or the liftgate key is unlocked, ECU terminal voltage (Connection condition of the ECU R connector). Signal Condition Terminal terminal No.
Seite 724 CHASSIS ELECTRICAL 7. LIFTGATE SWITCH INPUT CIRCUIT Description of operation When the liftgate is closed (the liftgate switch is switched ROFF), HIGH-level signals are sent to the ECU. When the level signals are sent to the ECU. ECU terminal voltage (Connection condition of the ECU con- nector).
Seite 725 CHASSIS ELECTRICAL - Theft-alarm System 8. SECURITY LIGHT ACTIVATION CIRCUIT Description of operation If all doors are in locked state after key-less locking, the ECU transistor is turned ON and the security light comes on. Checking the security light activation circuit (Disconnect the connector of the ECU and check at the wiring harness side.) Nor- Check object...
Seite 726 CHASSIS ELECTRICAL 10. HORN ACTIVATION CIRCUIT Description of operation The ECU transistor is turned ON if the vehicle door, etc. are opened without use of the key. This energizes the horn relay to activate the horn. Checking the horn activation circuit (Disconnect the connector of the ECU, then short-circuit terminal connector No.58, and activate the horn relay.) Nor- 1...
Seite 727 CHASSIS ELECTRICAL 12. THEFT ALARM HORN ACTIVATION ClRCUlT Description of operation link (6) The ECU transistor is turned ON if the vehicle door, etc. are opened without use of the key. This energizes the theft alarm horn relay to activate the horn. Checking the horn activation circuit (Disconnect the connector of the ECU, then short-circuit terminal connector No.
Seite 728 CHASSIS ELECTRICAL - Theft-alarm System 14. HEADLIGHT ACTIVATION CIRCUIT Description of operation The ECU transistor is turned ON if the vehicles Checking the headlight activation circuit (Disconnect door, etc. are opened without use of the key. This the connector of the ECU, then short-circuit terminal energizes the headlight relay to active the headlight.
Seite 729 CHASSIS ELECTRICAL 1993 models> Check object Normal Cause Remedy condi- function tion Headlight relay terminal voltage Malfunction of the Check the headlight headlight relay relay (Refer Headlight terminal voltage Harness damaged or Repair the harness disconnected Headlight termi- Column switch: Malfunction of the Replace the headlight voltage Low...
Seite 730 CHASSIS ELECTRICAL 15. STARTER RELAY ACTIVATION CIRCUIT Key reminder switch (STI alarm starter relay . ..-- . OY C-56 B-23 Starter motor Description of operation The ECU transistor is turned ON if the vehicle door etc. are opened without use of the key. This turns OFF the starter relay and power ceases to be supplied to the starter magnet switch.
Seite 731 ALPHABETICAL INDEX DISC ......... . Front, Check .
Seite 732 ALPHABETICAL INDEX CROSSMEMBER ........32-8-l COOLANT CRUISE CONTROL .
Seite 733 ALPHABETICAL INDEX FUNCTION, Check (4WS) ... . .37B-5-l GARNISHES ..51-15-l KEY INTERLOCK MECHANISM ..23-51-l GENERATOR ......
Seite 734 ALPHABETICAL INDEX Leak Repair Procedure ......55-28-l LINE <Full Auto A/C> ........55-79-l Transmission, Replacement REGULATOR, Door .
Seite 735 STARTER MOTOR ........16-23-11 22-17-l STARTING SYSTEM ....... . . 16-19-11 .
Seite 736 Output Voltage Measurement . WINDOW GLASS ....... . . 42-26-l Door, Adjustment..

Mitsubishi MOTORS 3000GT Bedienungsanleitung

Contents

Charging System

Generator

On-Vehicle Service

Specifications

Troubleshooting

Ignition System

On-Vehicle Service

Special Tools

Quicklinks

Kapitel

Fehlerbehebung

Verwandte Anleitungen für Mitsubishi MOTORS 3000GT

Inhaltszusammenfassung für Mitsubishi MOTORS 3000GT

Inhaltsverzeichnis