Technical Data - Kärcher SB MB Bedienungsanleitung

Malfunction Possible cause
Stains on the car paint Mineral content of the softened water
with Top-Care (permeate is too high
insufficiently demineral-
Break in the RO membrane, defective
ised)
sealing
Mixing permeate and softened water
Malfunction Possible cause
Hot air blower not operat- Hot air blower incorrectly adjusted.
ing
Hot air blower is defective
Frost protection not oper- Voltage supply has been interrupted.
ating
Outdoor temperature sensor is incor-
rectly mounted
Spray lance, high-pres- Sieve with throttle is clogged (marked
sure gun and high-pres- red)
sure hose are frozen
Frost protection pump filter is clogged Clean the filter and insert it again.
Washing station heater Outdoor temperature sensor is incor-
does not work during frost rectly mounted
Heat exchanger or circulation pump is
defective
Burner malfunction
The washing station heater circulation
pump motor circuit breaker was trig-
gered
SB MB
High-pressure module 608, 608fl
High pressure module 908
Electrical connection
Voltage
Maximum permissible mains grid impedance Ohm
Protection class version CAB (version SKID)
Connection output, oil/gas heated
Connection output, electrically heated 24 kW kW
Connection output, electrically heated 48 kW kW
Pre-fuse, oil/gas heated
Pre-fuse, electrically heated 24 kW
Pre-fuse, electrically heated 48 kW
Connection output with frost protection, oil/gas
heated
Connection output with frost protection, electri-
cally heated 24 kW
Connection output with frost protection, electri-
cally heated 48 kW
Pre-fuse with frost protection, oil/gas heated
Pre-fuse with frost protection, electrically heat-
ed 24 kW
Pre-fuse with frost protection, electrically heat-
ed 48 kW
Water connection
Water pressure, dynamic
Nominal width (DN)
Fresh water input amount/4. water type
Input amount warm water by customer
Tank content
Hot water float tank
Cold water float tank
Performance data
Working pressure with supplied nozzle
Working pressure for program hot wax, foam
1
wash
1
Nozzle size
Recoil force of the trigger gun with supplied
1
nozzle
Water consumption per washing station
Water consumption for program hot wax, foam
1
wash
Hot water temperature max.
Hot water temperature for continuous opera-
tion, all high-pressure modules type 608
Hot water temperature for continuous opera-
tion, all high-pressure modules type 608fl
Rectification
Check the conductivity of the softened water.
Replace seal or membrane. Check the conductivity.
Compare the conductivity of permeate from the spray lance and water from the
permeate buffer tank.
Malfunctions in the frost protection device (option)
Rectification
Check the settings of the hot air blower (see "Settings/Hot air blower").
Replace the hot air blower.
Check the power supply and ensure availability.
See section "Installing the system".
Open the screw connection. Clean the sieve. Check the throttle bore for free pas-
sage.
See section "Installing the system".
Check the heat exchanger, pump and pipe system, repair if necessary.
Remedy the burner malfunction.
Reset the motor circuit breaker, determine cause if repeated.
5/10-2
Piece 2 1
Piece - 2
V/~/Hz 400/3~/50
0.301 + j 0.188
IP X5 (IP X1)
kW 10 17
36 -
57 59
A 35 35
A 80 -
A 100 100
kW 15 17
kW 39 -
kW 63 64
35 35
80 -
100 125
MPa (bar) 0.3...0.6 (3...6)
mm 25
3
m /h 1.7 2.0
2 3
m /h 1.2 1.5
l 80
l 2.5
1
MPa (bar) approx. 10 (100) / approx. 10 (100) / approx. 12 (120)
MPa (bar) approx. 3 (30) / approx. 10 (100) / approx. 4.5 (45)
5004, 2504 / 5004, 2504 / 5006, 2507
N 17 / 17 /29
1
l/h (l/min) approx. 500 (8.3) / approx. 500 (8.3) / approx. 900 (15)
l/h (l/min) approx. 250 (4.2) / approx. 500 (8.3) / approx. 450 (7.5)
°C 60
°C about 55
3
°C about 28
4

Technical data

9/12-2 5/10-3
- 3 2 1
2 - 1 2
13 13 14 16
39 - - -
60 60 62 63
35 35 35 50
80 - - -
100 100 125 125
18 18 20 21
42 - - -
66 66 67 69
50 50 50 50
80 - - -
125 125 125 125
2.3 2.2 2.6 2.9
1.8 1.8 2.1 2.4
2 x 2.5
about 42
about 20
English
By whom
Customer Service
Customer Service
Customer Service
By whom
Operator
Customer Service
Operator
Customer Service
Operator
Operator
Customer Service
Customer Service
Operator
Operator, Customer
Service
9/12-3 5/10-4
- 4 3 2
3 - 1 2
17 16 17 19
- - - -
65 63 64 66
50 50 50 50
- - - -
125 125 125 125
23 21 22 24
- - - -
70 68 70 71
50 50 50 63
- - - -
125 125 125 125
3.3 2.7 3.2 3.5
2.7 2.4 2.7 3.0
about 30
about 16
9/12-4
1 -
3 4
20 22
- -
68 69
50 50
- -
125 125
25 27
- -
73 74
63 63
- -
125 125
3.9 4.2
3.3 3.6
75