Troubleshooting - Nouvag Vacuson 60 LP Bedienungsanleitung

Vacuson 60LP
Problem
Device does
Control Unit not turned on
not operate at all
Wrong operating voltage
Mains not connected
Defective Fuse
Floor Pedal
Floor Pedal not connected
fails to Function
Control Unit not turned on
Improper use
Infiltration Pumps
Trip plate not pressed down
fails to run
Infiltration speed too low
Suction Set incorrectly
attached
Adjusting Screw branches
off the Infiltration tube
Improper use
Vacuum Pump does Vacuum Pump not turned
on
not function
Vacuum leaks
Improperly mounted hoses
Jar is full and Overflow
Protection is closed
Improper use
Vacuum Pump does Vacuum Pump not turned
not function on
Vacuum leaks
Motor fails to run
Motor not turned on
Motor not connected
Motor improperly installed
In the event a problem cannot be solved, contact dealer or authorized service technicians, as
listed on the last page of your Operating Instruction Manual.
16

8 Troubleshooting

Cause
Turn Main Switch
"ON/OFF" ON
Check mains voltage
output
Connect mains to Control
Unit
Check fuse and replace if
indicated
Plug Floor Pedal Cable
into rear of Control Unit
Turn Main Switch
"ON/OFF" ON
Refer to Operating
Manual
Press plate down
Turn Pump Regulator
Clockwise
Attach Suction Set
correctly (check
direction!)
Screw up the Adjusting
Screw till the right stop
position
Refer to Operating
Manual
Turn pump on with blue
button on Floor Pedal
Check all seals and
hoses. Make sure Lid
rests securely on Jar.
Inspect hose connections
Replace Jar
Refer to Operating
Manual
Turn pump on with blue
button on Floor Pedal
Check all seals and
hoses. Make sure Lid
rests securely on Jar.
Turn motor on with yellow
foot button
Plug motor cable into
Control Unit
Firm press on motor
handle until snapped in
Refer: Operating
Solution
4.1 Overview
1.2 Technical Data
4.1 Overview
7.6 Control Unit Fuse
Replacement
1.2 Technical Data
4.1 Overview
4.1 Overview
5.2 Floor Pedal Functions
5.2 Floor Pedal Functions
5.3 Regulation of the
Infiltration Procedure
4.5 Infiltration Accessory
Connection
4.5 Infiltration Accessory
Connection
5.2 Floor Pedal Functions
5.3 Regulation of the
Infiltration Procedure
5.2 Floor Pedal Functions
4.3 Secretion Jar Lid
attachment
7.5 Seals and Tubes
4.6 Suchtion Assembly
Connection
4.3 Secretion Jar Lid
attachment
5.4 Regulation of the
Suction Procedure
5.4 Regulation of the
Suction Procedure
7.5 Seals and Tubes
5.2 Floor Pedal Functions
4.1 Overview
4.6 Connection suction
accessory
Manual
No. 31793 15/11