Troubleshooting; Winter Storage; Disposing Of The Machine - Peruzzo PANTHER MULTIFIT series Handbuch Zum Betrieb Und Zur Wartung

7.

TROUBLESHOOTING

PROBLEM
Excessive vibration of the machine
The grass is not cut
The collector does not lift or does
not open or close completely
8.

WINTER STORAGE

At the end of the season, or when the machine is laid up for long periods, it is necessary to:
- Carefully wash the machine and, if necessary, replace damaged or worn parts.
- Check the machine and replace any damaged parts.
- Tighten all bolts, paying particular attention to checking the condition of screws and flails.
- Grease all the parts carefully to protect them.
- Cover the machine, after placing it in a protected environment and secure it in order to avoid it shifting due to accidental
bumps.
Finding it in perfect order when resuming work can only be a benefit to the user.
9.

DISPOSING OF THE MACHINE

At the end of the life of the machine, before taking it to a special demolition company, make sure that there is no oil in the
machine's gear box or hydraulic system.
Avoid dispersions into the environment that can cause ecological damage.
Code. 29050071
Release 01/08/2017
CAUSE
Fracture or excessive wear of a flail
Breakage of a rotor support
Breakage of a drive shaft support
At worst, deformation of the rotor
due to bumps.
Breakage or excessive wear of the
flails
Slipping of the belts
Breakage of the belts
Slipping of the pulleys on the shafts
Multiplier broken
Low level of tractor oil
Air in the machine's hydraulic circuit
No pressure in the hydraulic circuit.
Hydraulic cylinders blocked
SOLUTION
Replace the flail
Replacing the rotor support with an
original one
Replace the shaft support with an
original one
Replacing the rotor with an original,
or refurbishment.
Replacing or sharpening the flails
Adjusting the tension of the belts
Replace the belts
Locking pulleys shrink-discs
Repair or replace multiplier
Add oil to the hydraulic circuit of
the tractor
Tractor with insufficient hydraulic
oil capacity
Bleed the air in the hydraulic circuit
Check the pressure of the tractor's
hydraulic system and /or the
hydraulic oil level
Overhaul the hydraulic cylinders.
48
DANGER LEVEL
For replacing the flails, see the
relative maintenance section.
In the other two cases the
replacements must be carried out
by specialized personnel
For replacing the flails, adjusting the
tension of the belts, replacing belts,
locking shrink-discs, see the relative
maintenance sections.
For purging air in the hydraulic
circuit of the machine, see the
relative maintenance section.