Product Description And Intended Use - tau T-SKY Bedienungs- Und Wartungsanleitung

1. PRODUCT DESCRIPTION AND INTENDED USE

T-SKY is a range of gearmotors destined for the automation of sectional doors and, by means of the special accessory P-100BANT not supplied,
spring or counterweight up-and-over doors, projecting and non-projecting.
2 solutions of T-SKY are available: one with a single track sliding guide (L= 3,3 m – moving parts are already assembled at the factory) or in the
2-section version for assembly (moving parts need to be assembled by the installer).
The irreversible system guarantees mechanical blocking of the door when the motor is not operating, and therefore no lock is necessary; an
internal and external manual release (optional) enable door manoeuvres in the event of a power failure or when out of service.
The buffer battery accessory P-200BATTSKY (optional) is also available, which enables certain manoeuvres in the event of a mains power failure.
The T-SKY automation has been designed and constructed for indoor use and to control vehicle access. Any other use is strictly
prohibited.
1.1 Application limits and dimensions (fig. 1-2)
All performance data of the products in the T-SKY range are provided in the table "Technical Data" are the only values that enable and ensure
correct evaluation for use.
The structural features of T-SKY products make them suitable for use on sectional or up-and-over doors, within the limits as specified in the
table.
Model
T-SKY (guide P-100BINBELT33 /
BINCHAIN33)
T-SKY (guide P-100BINBELT33-2 /
BINCHAIN33-2)
T-SKY1 (guide P-100BINBELT33 /
BINCHAIN33)
T-SKY1 (guide P-100BINBELT33-2 /
BINCHAIN33-2)
Model
T-SKY (guide P-100BINBELT33 / BINCHAIN33)
T-SKY (guide P-100BINBELT33-2 / BINCHAIN33-2)
T-SKY1 (guide P-100BINBELT33 / BINCHAIN33)
T-SKY1 (guide P-100BINBELT33-2 / BINCHAIN33-2)
Note: if art. P-100PROC33 (or P-100PROB33) is used, the heights stated in the tables may be increased by 1m.
The measurements stated in the tables are guideline only and serve as a general estimate. The effective suitability of T-SKY for the automation
of a specific door depends on the degree of leaf balance, friction on the guides and other factors, including occasional events, such as wind
pressure or the presence of ice, which may obstruct leaf movement.
1.2 Type of system and cable sections (figs. 3)
1. Gearmotor with built-in control
2. Photocells
3. Flashing light and aerial
a. 4x0,5 mm²
b. 2x0,5 mm² + RG58
c. 2x0,5 mm²
1.3 Set of Accessory for track and motor assembly (fig. 19)
1. Wall anchoring bracket
2. Door fixing bracket
3. Rail mounting "U"-bracket
4. Short plug
5. Long plug
6. Split pin for thorns
7. Opening - closing limit switch
8. "U"-bracket for fixing the rail to the ceiling
9. M8x20 galvanized te screw
SECTIONAL door Model
Height Width
2,6m 3,5m T-SKY (guide
CHAIN33)
2,6m 3,5m T-SKY (guide
CHAIN33-2)
2,6m 5m T-SKY1 (guide
CHAIN33)
2,6m 5m T-SKY1 (guide
BINCHAIN33-2)
4. Key-operated selector switch
5. Pushbutton panel
6. External release (optional)
d.
e.
f.
1 10. Hexagonal nut m8
1 11. Self-drilling screw
2 12. Wall and ceiling fixing plug
2 13. Screw for wall and ceiling mounting
1 14. Straight arm
3 15. Curved arm
2 16. Ceiling suspension bars
1 17. Lanyard release lever and fixing screws
4
P-100BINBELT33 / BIN-
P-100BINBELT33-2 / BIN-
P-100BINBELT33 / BIN-
P-100BINBELT33-2 /
UP-AND-OVER
door projecting (with accessory P-100BANT)
Height
2,8m
2,8m
2,8m
2,8m
3x0,5 mm²
3x0,5 mm²
4x0,5 mm²
26
UP-AND-OVER
door non projecting (with accessory
P-100BANT)
Height Width
2,2m 3m
2,2m 3m
2,2m 4m
2,2m 4m
Width
3m
3m
4m
4m
4
4
6
6
1
1
2
1