Allgemeiner Teil / General Section PA 5 - Turnit Es gelten die Vorschriften und Sicherheitshin- The regulations and safety instructions shall be weise gemäß dem Service Manual "Sicherheit", valid as provided by the "Safety" Service Manual, Sach-Nummer 72010-800.00, sowie zusätzlich part number 72010-800.00, as well as the...
Test cassette 448A (part no. 35079-023.00) Drehmomentcassette 456 (Sach-Nr. 35079-014.00) Torque test cassette 456 (part no. 35079-014.00) Beachten Sie bitte das GRUNDIG Meßtechnik-Programm, das Sie Please note the Grundig Catalog "Test and Measuring Equipment" unter folgender Adresse erhalten: obtainable from: GRUNDIG Instruments GRUNDIG Instruments Test- und Meßsysteme GmbH...
Allgemeiner Teil / General Section PA 5 - Turnit Ausbauhinweise Disassembly Instructions Allgemeiner Hinweis: General Hint: Steckverbinder vor dem Abziehen markieren, da durch die große Mark the connectors before pulling them off because they may easily Anzahl von gleichen Steckern Verwechslungsgefahr besteht. Beim be confused because of the great number of identical connectors.
Seite 5
PA 5 - Turnit Allgemeiner Teil / General Section Fig. 6 Fig. 7 GRUNDIG Service 1 - 5...
Seite 6
Allgemeiner Teil / General Section PA 5 - Turnit 2. CD-Laufwerk ausbauen. 2. Removing the CD Drive - CD-Schublade ausfahren. - Open CD tray. - Blende der CD-Schublade abnehmen. - Remove the mask of the tray. - CD-Schublade wieder einfahren.
Seite 7
PA 5 - Turnit Allgemeiner Teil / General Section 13. Hauptplatte mit Tunerplatte ausbauen 13. Removing the Main Board and Tuner Board - CD-Laufwerk ausbauen (Pkt. 2). - Remove the CD Drive (para 2). - HF-Senderplatte ausbauen (Pkt. 4). - Remove the RF Transmitter Board (para 4).
Seite 8
Allgemeiner Teil / General Section PA 5 - Turnit 14. Trafo ausbauen 14. Removing the Transformer - Cassettenlaufwerk ausbauen (Pkt. 3). - Remove the Tape Drive (para 3). - Stromversorgungsplatte ausbauen (Pkt. 5). - Remove the Supply Board (para 5).
Seite 9
PA 5 - Turnit Allgemeiner Teil / General Section 19. Ausbau der Display-Mechanik 19. Removing the Display Mechanics - Display-Antrieb ausbauen (Pkt. 17). - Remove the Display Drive (para 17). - Die Halter F (Fig. 22) vorsichtig auseinander biegen und die Achse - Bend the holders F (Fig.
Seite 10
Allgemeiner Teil / General Section PA 5 - Turnit CD-Laufwerk: CD Drive: 21. Schublade manuell öffnen 21. Opening the tray by hand Ist der Schubladenantrieb defekt, kann die Schublade manuell geöff- If the tray driver is defective, the tray can be opened by hand: net werden: - Insert a screw driver into bottom hole N (Fig.
Seite 11
PA 5 - Turnit Allgemeiner Teil / General Section 24. Pick-Up-Einheit ausbauen 24. Removing the Pick Up Unit - CD-Leiterplatte ausbauen (Pkt. 23). - Remove the CD PCB (para 23). - Pick-Up-Einheit ausrasten S (Fig. 29) und herausnehmen. - Disengage the pick up unit S (Fig. 29) and remove it.
Seite 12
Allgemeiner Teil / General Section PA 5 - Turnit Cassettenlaufwerk: Tape Drive: 26. Cassettenschublade ausbauen 26. Removing the cassette drawer - Cassettenlaufwerk ausbauen (Pkt. 3). - Remove the Tape drive (para 3). - Cassettenschublade bis zum Anschlag nach vorne ziehen.
Seite 13
PA 5 - Turnit Allgemeiner Teil / General Section Fig. 37b Fig. 37 28. Drehkopf ausbauen 28. Removing the rotary head - Laufwerksmechanik ausbauen (Pkt. 27). - Remove the drive mechanism (para 27). - Unsolder the headleads (note them). - Tonkopfleitungen ablöten (notieren).
Seite 14
Allgemeiner Teil / General Section PA 5 - Turnit 32. Bandlaufeinstellung 32. Adjustment of the tape transport Die Bandlaufeinstellung wird notwendig nach einem Wechsel des Adjustment of the tape transport is necessary after changing the Kombikopfes bzw. des Kopfträgers (Fig. 37).
Seite 15
PA 5 - Turnit Allgemeiner Teil / General Section Klangeinheit: Sound Unit: 33. Ausbau der Verstärkereinheit 33. Removing the Amplifier Unit - 4 Schrauben 1 (Fig. 47) herausschrauben und den Boden mit den - Undo 4 screws 1 (Fig. 47) and carefully remove the bottom with the Verstärkerplatten vorsichtig abnehmen (kurze Kabel).
Seite 16
Allgemeiner Teil / General Section PA 5 - Turnit 36. Subwoofer-Box ausbauen 36. Removing the Subwoofer Box - Verstärkereinheit ausbauen (Pkt. 33). - Remove the Amplifier Unit (para 33). - Kehler-Tube ausbauen (Pkt. 35). - Remove the Kehler Tube (para 35).
Seite 17
PA 5 - Turnit Allgemeiner Teil / General Section 37. Subwoofer-Box zerlegen (Subwoofer ausbauen) 37. Disassembling the Subwoofer Box (Removing the Subwoofer) - Subwoofer-Box ausbauen (Pkt. 36). - Remove the Subwoofer Box (para 36). - 2 Schrauben + (Fig. 59) herausschrauben und die Abdeckung - Undo 2 screws + (Fig.
Seite 18
Allgemeiner Teil / General Section PA 5 - Turnit 39. Kontrollplatte ausbauen 39. Removing the Control Board - Obere Abdeckung abnehmen (Pkt. 34). - Remove the Top Cover (para 34). - Masseleitung < (Fig. 65) ablöten. - Unsolder Ground Wire < (Fig 65).
PA 5 - Turnit Allgemeiner Teil / General Section Bedienhinweise Dieses Kapitel enthält Auszüge aus der Bedienungsanleitung. Weitergehende Informationen entnehmen Sie bitte der gerätespezifischen Bedienungsanleitung, deren Sachnummer Sie in der entsprechenden Ersatzteilliste finden. EINLEITUNG AUFSTELLEN Space Fidelity - Der Hintergrund...
Allgemeiner Teil / General Section PA 5 - Turnit INSTALLATION BEDIENELEMENTE Oberseite der Steuereinheit POWER Ein- und Ausschalten der Steuereinheit Ist diese über den Powerknopf ausgeschaltet, ist sie auch vollkommen von der Stromversorgung abgetrennt (kein Stromverbrauch). POWER SOUND Schaltet POWER SOUND ein und aus.
Seite 21
PA 5 - Turnit Allgemeiner Teil / General Section FERNBEDIENUNG Nach Auswahl des Tuners Nach Auswahl des Kassettendecks (TAPE) zum Starten der Wiedergabe in normaler S T zum Starten des Sendersuchlaufs (AUTO 2/PAUSE TUNING) oder zum Einstellen der Frequenz Laufrichtung und um das Kassettendeck auf schrittweise (MANUAL TUNING).
Allgemeiner Teil / General Section PA 5 - Turnit BEDIENUNG UND KLANGREGULIERUNG Display Aufstellwinkel Power Sound • Das Display kann liegend oder stehend positioniert werden, dazu • Mit der Taste POWER SOUND können Sie POWER SOUND ein- die Taste DISPLAY / auf der Fernbedienung oder der Steuereinheit und ausschalten.
Seite 23
PA 5 - Turnit Allgemeiner Teil / General Section RADIO Festsenderspeicher (STATION MEMORY) Funktion AUTO STORE Dieser Tuner ist mit einer Funktion ausgestattet, über die man auf sehr Sie haben 59 Speicherplätze zur Verfügung. komfortabele Weise alle Radiosender automatisch speichern kann.
Allgemeiner Teil / General Section PA 5 - Turnit CD-SPIELER Wichtiger Hinweis Abspielen der ganzen CD (aus STOP) CLASS 1 LASER PRODUCT bedeutet, daß der Laser wegen seines • Drücken Sie 2/PAUSE. technischen Aufbaus eigensicher ist, so daß der maximal erlaubte –...
PA 5 - Turnit Allgemeiner Teil / General Section KASSETTENDECK Auswahl Kassettendeck Auswahl des Reverse-Modus • Nachdem TAPE angewählt wurde, befindet das Kassettendeck sich • Drücken Sie MODE und anschließend (innerhalb 2 Sek.) 3 oder 4. immer im STOP-Modus. – Im Display erscheint der selektierte Modus: –...
Allgemeiner Teil / General Section PA 5 - Turnit KASSETTENDECK Umschalten von Bandzählwerk auf Echtzeit Kopieren von CD auf Kassette (CD-COPY) • Mit der Taste schalten Sie zwischen Bandzählwerk und Anzeige Ihr Kassettendeck ist in der Lage,Kontrollkommandos an den CD-Spieler der Echtzeit (Minuten und Sekunden) um.
Seite 27
PA 5 - Turnit Allgemeiner Teil / General Section SETTING UP Control unit and sound unit in separate places control unit Power supply connection – The mains cable that is fixed on the bottom of the sound unit has to be connected to a mains outlet (230V~, 50/60 Hz).
Allgemeiner Teil / General Section PA 5 - Turnit DISPLAY REMOTE CONTROL Display General functions switches the unit to STAND BY. The display indicates + / – adjusts the volume – when receiving FM stereo stations mutes the speakers – during station search, during fast...
Seite 29
PA 5 - Turnit Allgemeiner Teil / General Section OPERATION Switching on and off Turnit - Multipath effect Automatic standby mode The TURNIT has an RF system which enables the – The sound unit is provided with an automatic standby •...
Seite 30
Allgemeiner Teil / General Section PA 5 - Turnit RADIO Selecting tuner RDS Radio Data System – The first time you select tuner, it automatically switches to FM Your tuner is an RDS tuner. STEREO ) and the display indicates 87,50 MHz.
PA 5 - Turnit Allgemeiner Teil / General Section RADIO RDS Radio Data System Programme type (PTY) Your unit is capable of receiving and evaluating RDS information which RDS allows you to select memorized FM stations according to is broadcast along with the normal broadcast signal. The channel programme type.
Seite 32
Allgemeiner Teil / General Section PA 5 - Turnit CD PLAYER Shuffle play (random playback) You can programme your own track sequence for each CD. The order of the programmed tracks determines the order in which they are You can play all the titles on a CD in random order.
Seite 33
PA 5 - Turnit Allgemeiner Teil / General Section TAPE DECK Fast winding during normal operation Protecting cassettes against unintentional erasure These functions are only possible when in the STOP mode. • Press S or T. Every time you record onto a tape, its contents is erased and replaced –...
Abgleichvorschriften / Adjustment Procedures PA 5 - Turnit Abgleichvorschriften / Adjustment Procedures D Tuner Meßgeräte: Wobbler, Meßsender, Stereocoder, Tongenerator, Oszilloskop, Digitalvoltmeter, NF-Voltmeter, Klirrfaktormeßgerät Hinweis: Das Frontend ist ein komplett abgeglichener Baustein. Nur das ZF-Filter muß dem ZF-Verstärker angeglichen werden (1).
PA 5 - Turnit Abgleichvorschriften / Adjustment Procedures Abgleichlageplan Tuner / Alignment Layout Tuner Beim Austausch eines der ZF-Filter achten Sie darauf, daß nur Filter mit gleicher Kennfarbe bestückt sind. When replacing one of the ceramic resonators, take care that the colour codes of all resonators are the same.
Seite 36
Abgleichvorschriften / Adjustment Procedures PA 5 - Turnit D Tape-Deck Meßgeräte / Meßmittel: Frequenzzähler, NF-Voltmeter, NF-Generator, Tonhöhenschwankungsmesser, Cr-Testcassette, Drehmomentcassette. Abgleich Vorbereitung Abgleichvorgang ± 1. Bandgeschwin- Frequenzzähler an AUX OUT. Mit dem Einstellregler R482 (Logikplatte) 3150Hz 1,0% digkeit Testcassette einlegen, einstellen.
Seite 37
PA 5 - Turnit Abgleichvorschriften / Adjustment Procedures Abgleich Vorbereitung Abgleichvorgang 11.NF-Kopfstrom- NF-Voltmeter an Meßpunkt D1 (linker Kanal) bzw. an Eingangspegel bei Aufnahme so einstellen, daß an den einstellung bei Meßpunkt D2 (rechter Kanal). Meßpunkten D1 und D2 120mV anstehen.
Seite 38
Abgleichvorschriften / Adjustment Procedures PA 5 - Turnit Tape Deck Measuring instruments / equipment: Frequency counter, AF voltmeter, AF generator, wow and flutter meter, Cr test cassette, torque test cassette. Adjustment Preparations Adjustment Procedure 1. Tape speed Frequency counter to AUX OUT.
Seite 39
PA 5 - Turnit Abgleichvorschriften / Adjustment Procedures Adjustment Preparations Adjustment Procedure 11.AF head current AF-voltmeter to test point D1 (left channel) or test point Set the input level during Record so that the voltage adjustment during D2 (right channel).
PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs Gesamtblockschaltplan / General Block Diagram...
Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Blockschaltplan Steuereinheit / Block Diagram Control Unit CONTROL LOADING CONTROL DOLBY B LED BD MOTOR P.L.
PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs Schaltpläne Steuereinheit: Hauptplatte, I/O-Platte, Verstärkerplatte Circuit Diagrams Control Unit: Mainboard, I/O Board, Amplifier Board...
Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Hauptplatte, Kopfhörerplatte, Audio Verbindungsplatte Main Board, Head Phone Board, Audio Plug Board...
PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs Hauptplatte Main Board R648 +5V-UP R649 R690 R650 SIN1 R651 R691 +12V...
Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Hauptplatte, Schalterplatte, Antennenplatte, Tastenplatten, Display-Detektor-Platte, IR-Empfänger-Platte, Motorplatte Main Board, Switch Board, Antenna Board, Keys Boards, Display Detector Board, IR Board, Motor Board p.
PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs Stromversorgungsplatte, LED-Platte, Reglerplatte, Netzplatte, Netzschalterplatte Supply Board, LED Board, Regulator Board, Mains Board, Power Switch Board...
Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Cassetten-Audio-Platte Tape Audio Board C213 120p/5% 19202-358.97 T109 C177 PLAYBACK LEVEL R222...
PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs Cassetten-Steuerungs-Platte, Detektor-Platte, Dolby-LED-Platte Tape Logic Board, Detector Board, Dolby LED Board T417...
Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit CD-Platte CD Board HF - AMPLIFIER R304 R305 74HCU04 IC300 C305 C306...
PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs Display DISPLAY BOARD -VEE 56 55 54 53 52 51 50 49...
Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Tuner FM-STEREO FM-MONO 3 - 23 GRUNDIG Service 3 - 24 GRUNDIG Service...
Seite 53
PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs +9.8V P551 p. 3-9 +3.6V +3.2V +2.5V P552 p. 3-9 P550 p. 3-9 P512 p.
Seite 54
Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Hauptplatte / Main Board Audio Verbindungsplatte Audio Plug Board C510 C523 C519 P514 820.06...
Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Stromversorgungsplatte / Supply Board Display-Detektor-Platte CD-Platte / CD Board Display Detector Board IC201 59451-822.00(00)
Seite 57
PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs Blockschaltplan Klangeinheit / Block Diagram Sound Unit AUDIO PLUG BOARD 1 AUDIO PLUG BOARD 2...
Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne Klangeinheit: Kontrollplatte, Netzschalterplatte, Netzfilterplatte, AC-Ausgangsplatte, Potentiometerplatte, Audio-Verbindungsplatten Circuit Diagrams Sound Unit: Control Board, Power Switch Board, AC Filter Board, AC Outlet Board, Potentiometer Board, Audio Plug Boards...
PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs Kontroll-Platte, Mute-LED-Platte, Stby-LED-Platte, LED-Platte Control Board, Mute LED Board, Stby LED Board, LED Board...
Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Audio-Verstärker-Platten Audio Amplifier Boards P907 p. 3-38 P112 MUTE_TREBLE DC_PROT_TREBLE C144 R108 IC105 09238-197.01...
Seite 61
PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs Kontroll-Platte / Control Board Audio-Verstärker-Platten / Audio Amplifier Boards Netzschalterplatte / Power Switch Board...
Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit Schaltpläne und Druckplattenabbildungen / Circuit Diagrams and Layout of PCBs PA 5 - Turnit PIN-No. . Connection Schaltbild Pick-Up-Einheit / Circuit Diagram Pick Up Unit Display 1 .....
Seite 65
POS. NR. SACHNUMMER BEZEICHNUNG POS. NR. SACHNUMMER BEZEICHNUNG POS. NR. SACHNUMMER BEZEICHNUNG POS. NR. SACHNUMMER BEZEICHNUNG POS. NO. PART NUMBER DESCRIPTION POS. NO. PART NUMBER DESCRIPTION POS. NO. PART NUMBER DESCRIPTION POS. NO. PART NUMBER DESCRIPTION D 824 83092 150 2000 DIODE 1 N 4004 -GA IC 1850 83053 035 7900 IC SAA6579T PHI T 101...
PA 5 - Turnit Ersatzteillisten und Explosionszeichnungen / Spare Parts Lists and Exploded Views Explosionszeichnung Cassettenlaufwerk / Exploded View Tape Drive GRUNDIG Service 4 - 7...
Seite 70
Ersatzteilliste Ersatzteilliste HIFI AUDIO CASSETTE Spare Parts List Spare Parts List LAUFWERK CD 06 / 97 7 / 95 LAUFWERK TN 1800 D DRIVE MECHANISM CD SACH-NR. / PART NO.: 59726-015.00 SACH-NR. / PART NO.: 59726-012.00 POS. NR. ABB. SACHNUMMER ANZ. BEZEICHNUNG DESCRIPTION POS.