Motors; Safety And Protective Equipment - Elmo Rietschle V Serie Originalbetriebsanleitung

PUMP DESCRIPTION
4.4

Motors

The characteristics of the motor used can be found on the motor rating plate.
4.5

Safety and protective equipment

DANGER
NOTE
For a description of the safety instructions, see chapter 2.9
The pump's protective devices must not be dismantled, modified or put out of operation. The pump must
be shut down and secured immediately if protective devices have been removed, modified or taken out of
operation.
Defects in protective devices must be rectified immediately. All protective devices must be undamaged, fully
assembled and functional. Warning and information signs must be clearly visible.
All protective devices must be checked for functionality, damage and completeness after each maintenance
of the pump.
If a maintenance activity requires the dismantling of protective devices, these may only be dismantled for the
duration of the maintenance activity. All protective devices must be fully installed at the designated location
immediately after completion of the maintenance work and checked for proper functioning.
The prescribed inspection intervals for protective devices must be observed and complied with. Protecti-
ve devices may only be maintained, replaced and serviced by trained, instructed and authorised specialist
personnel.
Unauthorised tampering with or manipulation of the safety-related parts of the pump is strictly prohibited
and must be reported immediately to the responsible department.
All safety and accident prevention equipment, such as covers and protective panelling, must be in place.
The removal or modification of these devices as well as the warning and information signs is prohibited.
An overview of the pump with the designations of the protective devices is shown below.
Fig. 3 Protective device
16
|
www.elmorietschle.com © Gardner Denver Schopfheim GmbH
Prematic AG, Märwilerstrasse 43, 9556 Affeltrangen www.prematic.ch
Danger to life due to defective, dismantled and manipulated protective devices.
Tel. 071 918 60 60, Mail: v-g@prematic.ch