Designated Use; Obligations Of The Operator; Warning And Notice Signs - Abicor Binzel FEC Originalbetriebsanleitung

2 Safety

2.1 Designated use

The device described in these operating instructions may be used only for the purpose and in the manner
described in these operating instructions. The device is used to extract welding fumes and dust that is
generated during welding. Unauthorized modifications or changes to enhance the performance are not
permitted.
► Do not exceed the maximum load data as defined by the documentation supplied. Excessive loads lead
to irreparable damage.
► Do not make any constructive changes to this product.
► Do not use or store the device outdoors where it is wet.
► Ensure that the volume flow that is led back to the work area during operation does not exceed 50% of
the supply air of the installation area. In the event of free room ventilation, the supply air flow
corresponds to one room volume per hour. This equals a ventilation rate of 1/h (supply air flow [m³/h]
= room volume [m³] × ventilation rate [1/h]).

2.2 Obligations of the operator

Risk of injury due to electromagnetic fields
The device can produce electromagnetic fields that could impact the proper function of cardiac
pacemakers and implanted defibrillators.
► Do not use the device if you have a pacemaker or an implanted defibrillator.
► The device may be used only in industrial zones according to DIN EN 61000-6-3.
► Ensure that only qualified personnel are permitted to perform work on the device or system.
Authorized personnel are:
— those who are familiar with the basic regulations on occupational safety and accident prevention;
— those who have been instructed on how to handle the device;
— those who have read and understood these operating instructions;
— those who have been trained accordingly;
— those who are able to recognize possible risks because of their special training, knowledge, and
► Keep untrained persons out of the work area.
Country-specific obligations of the operator
The recirculation of filtered air can lead to health risks and is therefore prohibited in certain countries. For
example, when operating the device in France, the cleaned air must be expelled from the building.
► Observe the local occupational health and safety regulations.

2.3 Warning and notice signs

The following warning, notice and mandatory signs can be found on the product:
► These markings must always be legible. They may not be covered, obscured, painted over, or removed.
EN - 6
WARNING
experience.
► Read and observe the operating instructions.
FEC