General Instructions - Nilfisk SR 1601 D3 Betriebsanleitung, Originalanleitung

GENERAL INSTRUCTIONS

Specific warnings and cautions to inform about potential damages to people and machine are shown below.
DANGER!
– Carbon monoxide (CO) can cause brain damage or death.
– The internal combustion engine of this machine can emit carbon monoxide.
– Do not inhale exhaust gas fumes.
– Only use indoors when adequate ventilation is provided, and with the help of an assistant.
DANGER!
– Before performing any maintenance, repair, cleaning or replacement procedure disconnect the battery
– This machine must be used by properly trained operators only.
– Sharp turns must be made at slowest possible speed. Avoid: abrupt turns on incline, turns when the hopper
– Do not lift the hopper when the machine is on incline. The machine loses stability on incline or when the
– Regularly check the tyre pressure (tyres are optional).
– Do not wear jewels when working near electrical components.
– Keep the batteries away from sparks, flames and incandescent material. During the normal operation
– Do not work under the lifted machine without supporting it with safety stands.
– When working under the open hood, ensure that it cannot be closed by accident.
– Do not operate the machine near toxic, dangerous, flammable and/or explosive powders, liquids or vapours:
– Be careful: fuel is highly flammable.
– Do not smoke or bring naked flames in the area where the machine is refuelled or where the fuel is stored.
– Refuel outdoors or in a well-ventilated area, with the engine off.
– Turn off the engine and let it cool down for a few minutes, then remove the fuel tank plug.
– Leave at least a space of 4 cm in the filler to allow the fuel to expand.
– After refuelling, check that the fuel tank cap is firmly closed.
– If any fuel is spilled while refuelling, clean the tank area and allow the vapours to evaporate before starting
– Do not let fuel come into contact with the skin; do not breathe fuel vapours. Keep out of reach of children.
– Do not tilt the engine too much to avoid fuel spillage.
– During machine transportation, the fuel tank must not be full.
– Do not lay any object on the engine.
– Stop the engine before performing any procedure on it. To prevent the engine from starting accidentally,
– See also the SAFETY RULES in the Engine Manual, which is to be considered an integral part of this Manual.
– Lead batteries (WET) are installed on this machine, do not tilt the machine more than 30° from its horizontal
– Do not use the machine in case of gas leaks. Disconnect the fuel hose and replace the LPG tank. If the gas
Downloaded from www.Manualslib.com
connector, remove the ignition key and engage the parking brake.
is lifted.
hopper is full.
explosive gases are released.
This machine is not suitable for collecting dangerous powders.
the engine.
disconnect the battery negative terminal.
position to prevent the highly corrosive acid to leak out of the batteries. When the machine is to be tilted to
perform maintenance procedures, remove the batteries.
leak persists, disconnect the fuel hose and contact the Nilfisk Service Center.
manuals search engine
USER MANUAL
33019216 - SR 1601 D3 / LPG3 / P3
ENGLISH
5