Special Hazards; Hydraulic Excavator And Other Lifting Equipments; Workplaces - probst QUICKJET QJ-600-E Betriebsanleitung

Operating Instructions
QJ 600-E
3.5

Special Hazards

● The operating range has to be covered for unauthorized persons, especially children.
● The workplace has to be sufficiently illuminated.
● Take care when handling wet, dirty and not solidified components.
● The working with the vacuum lifting device in case of atmospheric editions under 37,5° F
is forbidden!
● Take care in case of thunderstorm!
● Since the load is held on the suction plates of the unit by a vacuum, it will fall off as soon as
this vacuum is lost (e.g. energy failure).
● This can happen if the vacuum generator fails. An integrated vacuum reservoir maintains the
vacuum for a short safety period whose duration depends on the porosity of the work piece
surface.
● If the vacuum generator fails, lower the load immediately if this is possible. Otherwise, leave
the danger area below the load immediately.
● The unit draws in large amounts of air and hair and items of clothing can be drawn into the air inlet.
Do not look into the air inlet when the unit is running: it is even possible for your
drawn into the air inlet.
3.5.1

Hydraulic excavator and other lifting equipments

● Hydraulic excavator and other lifting equipments have to be in good, safe working condition.
● Only authorized, certificated and qualified personnel is allowed to operate the excavator and other
lifting equipments.
● The operator staff must have all the necessary qualifications.
● Take care that the maximum capacity of the hydraulic excavator and other lifting
equipments is not exceeded.
3.6

Workplaces

● The workplace of the operator is in front of the operator handle.
● The operator must stand so that he can see the vacuum gauge at all times.
8 / 25
Safety
Because the goods could be fall down caused by dampness or freezing.
eyes to be
GB