Wilo Stratos MAXO Einbau- Und Betriebsanleitung Seite 26

en
Table of contents
1 Guidance information..................................................... 28
1.1 About these instructions .................................................... 28
1.2 Original instructions ............................................................ 28
1.3 Identification of safety instructions.................................. 28
1.4 Personnel qualifications...................................................... 28
2 Description of the pump ................................................ 29
2.1 Type key ................................................................................ 29
2.2 Technical data ...................................................................... 30
2.3 Min. inlet pressure................................................................ 30
3 Safety ............................................................................... 31
3.1 Intended use ......................................................................... 31
3.2 Misuse.................................................................................... 33
3.3 Operator responsibilities..................................................... 33
3.4 Safety information............................................................... 33
3.5 Safety instructions............................................................... 34
4 Transportation and storage........................................... 34
4.1 Scope of delivery.................................................................. 34
4.2 Accessories ........................................................................... 34
4.3 Transport inspection ........................................................... 34
4.4 Transport and storage conditions ..................................... 35
5 Installation....................................................................... 35
5.1 Personnel requisition........................................................... 35
5.2 Safety during installation.................................................... 35
5.3 Preparing the installation ..................................................... 36
5.4 Aligning the motor head....................................................... 36
5.5 Installation.............................................................................. 36
5.6 Insulation ................................................................................ 37
5.7 Following installation............................................................ 38
6 Electrical connection....................................................... 38
6.1 Personnel requisition ............................................................ 38
6.2 Requirements......................................................................... 38
6.3 Connection options............................................................... 40
6.4 Analogue input (AI1) or (AI2) - purple terminal block...... 41
6.5 Digital input (DI1) or (DI2) - grey terminal block .............. 41
6.6 Wilo Net - green terminal block ......................................... 41
6.7 Collective fault signal (SSM) - red terminal block............ 41
6.8 Collective run signal (SBM) - orange terminal block ....... 42
6.9 Connecting and removing the Wilo-Connector ............... 42
6.10 Bluetooth radio interface ..................................................... 42
7 Put into operation............................................................ 42
7.1 Venting ................................................................................... 42
7.2 Pump operation ..................................................................... 42
7.3 Double pumps........................................................................ 46
7.4 Faults, causes, remedies....................................................... 46
8 Spare parts........................................................................ 46
9 Disposal............................................................................. 46
9.1 Information on the collection of used electrical and elec-
tronic products ...................................................................... 46