About Vacuum Packing; How To Preserve Food In Magic Vac Bags - Magic Vac Maxima Betriebsanleitung

The deterioration of food is caused by chemical reac-
tions that occur in food which is exposed to the air, tem-
perature, moisture, the action of enzymes, the growth of
micro-organisms or contamination by insects.
Vacuum packing reduces the absolute pressure of the air
inside the package or container, by removing the oxygen
and eliminating volatile compounds. The oxygen in the air
causes food to deteriorate, firstly through a process of
oxidation, causing the loss of nutritional values, flavour
and all the food's qualities. Air also promotes the growth
of most micro-organisms and causes the frost burns
which occur on frozen food.
Vacuum packing extends the shelf life of many fresh
foods, by reducing oxidation and preventing the prolifer-
ation of microbes (bacteria and mould). However, many
fresh foods contain sufficient moisture to encourage the
growth of micro-organisms that can grow with or without
air. To prevent the deterioration of such foods, they must
be preserved at low temperatures.
Micro-organisms like mould, yeast and bacteria are pre-
sent everywhere, but they can cause problems only in
certain conditions.
For example, mould will not grow in environments with a
low oxygen content, or in the absence of moisture or
humidity. To grow, yeast requires moisture, sugar and a
moderate temperature, but it can grow in the presence or
absence of air. Refrigeration slows the growth of yeast
and freezing blocks it completely. Bacteria can multiply
with or without air, depending on their type.
Clostridium Botulinum is a very dangerous type of bacte-
ria which can develop in environments which do not con-
tain acids, are without oxygen and are exposed to tem-
peratures in excess of 4°C for long periods of time.
Foodstuffs vulnerable to attack by Clostridium Botulinum
HOW TO PRESERVE FOOD IN MAGIC VAC
Vacuum packing for the freezer
First of all, use the freshest possible food. The MAGIC
VAC ® system will allow you to retain all the freshness of
the food only if it is properly preserved. Some foods have
a soft consistency which could be damaged by vacuum
packing the product when fresh. To prepare delicate
foods like meat, fish, berries, bread, etc., it is advisable to
pre-freeze them first. In the first twenty-four hours there
is no risk of freezer burns, so you can vacuum pack the
products frozen the previous day in MAGIC VAC
and then keep them in the freezer for long periods so as
to preserve all the nutritional values and flavour of the
product you have packed.
When vacuum packing soups, stews or other liquid food,
pre-freeze it in a pan or high-strength dish. When the
food becomes solid, vacuum pack it, add a label and

ABOUT VACUUM PACKING

® bags,
22
are those with low acidity (like red meat, poultry, fish,
seafood, olives in brine, eggs, mushrooms and vegeta-
bles) and medium acidity foods like virtually all vegeta-
bles and many fruits (ripe tomatoes, onions, red pepper,
figs and cucumbers). To prevent contamination by this
bacterium, it is essential to observe the basic rules of
hygiene and, to prevent its harmful proliferation in pre-
served foods, they must be refrigerated for short periods
and/or frozen for long-life preservation. However, such
foods must be eaten immediately after heating.
Important: you must consume immediately any food
which has been heated while still sealed in MAGIC
VAC ® bags. Leaving the food to cool slowly at room tem-
perature in the sealed vacuum bag may cause several
harmful micro-organisms to multiply, in just a few hours,
to values that are health-threatening.
Several enzymes found in foods cause increasingly
noticeable changes in colour, structure and flavour; such
changes depend on the preservation time, temperature
and, above all, the presence of air. To halt the action of
enzymes, vegetables must be blanched briefly using
steam or a microwave oven. Food which contains a high
percentage of acidity, like most fruits, do not require
blanching. The absence of air created by the vacuum will
in any case slow down or prevent the action of these
enzymes.
Insect larvae are frequently found in many low water
content or dried foods which have not been vacuum
packed or frozen, and they can develop during preserva-
tion and thus contaminate the food. Some products like
flour and grain might contain larvae, but using MAGIC
VAC vacuum packing will stop them developing into
®
insects.
replace in your freezer.
To vacuum pack vegetables, peel them and then blanche
them briefly in boiling water or a microwave oven until
they are warm but still firm. Then vacuum pack them in
convenient portions.
If the food is not pre-frozen, leave an extra 5 cm in the
length of the bag to allow for expansion due to freezing.
With regard to meat and fish, it is advisable to place the
food on a paper towel and vacuum pack it with the towel
in the bag. This will absorb any moisture in the food.
To preserve food like focaccia, crêpes and small ham-
burgers, stack them on top of each other, placing grease-
proof paper or film between each piece. This will make it
easier to remove some of the food, repackage the rest
and replace it immediately in the freezer.
® BAGS