Start Up; Operation - Kärcher KM 120/150 R Bp Bedienungsanleitung

Maximum battery dimensions
Length Width
827 mm 324 mm
Pay attention to the following if you are
using maintenance-free batteries in KM
120/150 R Bp:
– It is necessary to conform to the maxi-
mum battery dimensions.
– While charging maintenance-free batte-
ries, it is necessary to tilt the seat up-
ward.
– While charging maintenance-free batte-
ries, follow the specifications of the bat-
tery manufacturer.
Check fluid level in the battery and ad-
just if required
Warning
Regularly check the fluid level in acid-filled
batteries.
è Unscrew all cell caps.
è Where fluid level is too low, top up cells
to the mark provided with distilled water.
è Charge battery.
è Screw in cell caps.
Unloading
Warning
Do not use a forklift truck to unload the ma-
chine as this may damage it.
Note
Press the emergency-stop button to imme-
diately deactivate all functions and turn the
key switch to the "0" position.
To unload the machine, proceed as follows:
è Cut plastic packing belt and remove foil.
è Remove the elastic tape fasteners at
the stop points.
è Four indicated floor boards of the pallet
are fastened with screws. Unscrew the-
se boards.
è Place the boards on the edge of the pal-
let. Place the boards in such a way that
they lie in front of the four wheels of the
machine. Fasten the boards with
screws.
Figure 6
è Slide the four support beams included in
the packaging under the ramp.
è Remove the wooden blocks used for ar-
resting the wheels and slide them under
the ramp.
(1) Machine without built-in battery
è Loosen immobilizing brake (see "move
sweep machine").
Height
è Slide the machine over the prepared
462 mm
ramp from the pallet.
(2) Machine with built-in battery
è Connect battery (see section on Care
and maintenance)
è Release emergency-stop button by
turning.
è Set main switch to "1".
è Press the drive direction switch and
slowly move the machine down from the
ramp.
è Set main switch back to "0".
Move the sweep machine
Danger
Risk of injury! Before releasing the immobi-
lizing brake, the machine must be secured
to prevent it rolling away. After releasing the
immobilizing brake, the machine roles wit-
hout brakes.
Figure 7
è Remove the brake level from the wheel
and put it in its position.
The immobilizing brake is thus deactivated;
the machine can now be moved.
Warning
Danger of damage to the controls! Never
move the machine faster than 8 km/h.
è Park the sweeper on an even surface.
è Remove the key.
Inspection and maintenance work
è Check charging status of battery. *
è Check side brush. *
è Check roller brush. *
è Empty waste container.
* For description, see section on Care and
maintenance.
Note
Press emergency-stop switch to immedia-
tely switch off all functions of the machine.

Start up

General notes

Operation

Adjusting driver's seat
è Pull seat adjustment lever outwards.
è Slide seat, release lever and lock in pla-
ce.
è Check that the seat is properly locked in
position by attempting to move it back-
wards and forwards.
Check immobilizing brake
Danger
Danger of accident! The immobilizing brake
must always be checked first on an even
surface before starting the machine.
è Take the seating position.
è Release emergency-stop button by
turning.
è Set main switch to "1".
è Select pedal for direction of travel.
è Gently depress drive pedal.
è The brake must get released and you
must be able to hear it (the control lamp
for immobilizing brake on the console
switches off). The machine must roll
slightly on a plane surface. When the
pedal is released, the brake falls in in an
audible manner. Switch off the machine
and call the aftersales service if the abo-
ve-mentioned events do not occur.
Programme selection
3
2
1
Figure 8
1 Driving
Driving to the Place of Use.
2 Sweeping with sweep roller
Roller brush is lowered.
3 Sweeping with right side brush
Sweep roller and right side brush are lo-
wered.
4 Sweep using left side brush (optional)
Sweep roller and left side brush are lo-
wered.
5 Sweep using both brushes (optional)
Sweep roller and both brushes are lo-
wered.
4
5
27
English