Scheppach DP3000 Originalbetriebsanleitung Seite 22

5. If petrol is spilled, do not attempt to start the engine
but move the machine away from the area of spill-
age and avoid creating any source of ignition until
petrol vapours have dissipated. Replace all fuel
tank and container caps securely.
Adding fuel
• Always switch off the engine before refuelling.
m Attention! Always open the fuel filler cap carefully
to decompose slowly the excess pressure.
• Whilst working with the machine high tempera-
tures can attain on the case. Allow the engine to
cool before refuelling.
m Attention! In case of insufficient cooling of the
machine the fuel may ignite and lead to serious burns
during refueling.
• Make sure not to fill the tank with too much fuel. Im-
mediately remove the fuel and clean the machine
when spilling fuel.
• Always close the screw plug on the fuel tank in or-
der to avoid loosening which may occure by vibra-
tions when using the machine.
m DANGER
Never refuel the engine nearby open flames.
Additional safety instructions while hand-
ling with combustion engines
m DANGER
Combustion engines constitute a special danger dur-
ing operation and refuelling. Always read and note
the warnings. Failure to do so can lead to serious or
even deadly injuries.
1. No changes may be made to the device.
2. m Attention!
Danger of poisoning, Emissions, fuels and lu-
bricants are toxic. Emissions shall not be inha-
lated.
3. m Attention!
Risk of burns. Do not touch the exhaust sys-
tem or drive unit.
4. Never operate the machine in non ventilated
rooms or in a highly inflammable environment. If
you intend to operate the machine in rooms with
good ventilation, the exhaust gases must be chan-
nelled directly outdoors through an exhaust hose.
m Attention! Toxic exhaust gases can escape
despite the exhaust hose. Due to the fire hazard,
never direct the exhaust hose towards inflamma-
ble materials.
5. m Risk of explosion!
Never operate the machine in rooms with com-
bustible materials.
6. Secure the device against shifting and toppling
during transport.
7. Make sure that when you refuel the device no
fuel is spilt on the engine or exhaust pipe.
8. Repairs and adjustment work may only be car-
ried out by authorized trained personnel.
22 I 60
 www.scheppach.com  service@scheppach.com  +(49)-08223-4002-99  +(49)-08223-4002-58
9. Do not touch any mechanically driven or hot
parts. Do not remove the safety guards.
10. The values quoted in the technical data under
sound power level (LWA) and sound pressure
level (LpA) are emission values and not neces-
sarily reliable workplace values. As there is a
correlation between emission and immission
levels, the values cannot be taken to reliably de-
termine the possible need for additional precau-
tions. Factors influencing the current immission
level of the user/operator include the properties
of the work area, other sound sources etc., e.g.
the number of machines and other neighboring
processes, and the time span over which the
user/operator is subjected to the noise. Also, the
permitted immission level can vary from country
to country. Nevertheless, this information makes
it possible for the user to be able to make a better
assessment of the dangers and risks involved.
11. Never put any items into the ventilation openings.
This applies even when the device is switched
off. Non-observance may lead to injury, or dam-
age to the device.
12. Keep the generator free of oil, dirt and other
impurities.
13. Ensure the sound absorber and air filter work
properly. These parts serve as flame protection
in case of misfire.
14. Stop the engine:
- whenever you leave the machine
- before refueling
15. Always close the fuel valve when the machine is
not in operation.
16. Never use the choke lever to stop the engine.
Specific safety instructions for handling the
device
1. Thoroughly inspect the area to be worked, keep
the working area clean and free of debris to
prevent tripping. Operate on a flat level ground.
2.
Never place any part of your body where it
would be in danger if movement should occur
during assembly, installation, and operation,
maintenance, repairing or moving.
3. Keep all bystanders, children, and pets at
least 23 meters (75 feet) away. If you are ap-
proached, stop the unit immediately.
4. Do not mount on dump box and never carry
passengers.
5.
Never park the machine in a place with unstable
ground which could give way, particularly when
it is full.
6. Disengage clutch lever before starting the
engine.
7. Start the engine carefully according to instruc-
tions and with feet well away from the moving
parts.
8.
Never leave the operating position when the
engine is running.
9. Always hold the unit with both hands when
operating. Keep a firm grip on the handlebars.
Beware that the machine may unexpectedly
bounce upward or jump forward if the machine
should strike buried obstacles such as large
stones.
10. Walk, never run with the machine.