Trouble Shooting The Engine - Eisemann T 4411 Originalbetriebsanleitung

8.2.

Trouble shooting the engine

If the fault cases listed below have been processed, but the error still persists,
please contact your authorized workshop.
FAULT
Engine will not start or starts
badly
Engine starts, but runs irregularly
or sets of
Engine gets too hot
Low Engine power, engine
smokes black
Low oil pressure, oil level protec-
tion switches off the engine
Oil consumption too high, en-
gine smokes blue
Note:
On points that are not included in this table, please contact your authorized workshop
If you contact your local authorized workshop, please provide the model and serial number, use, and current operat-
ing hours of your generating set.
CAUSE
Starting limit temperature under-
cut
Wrong grade of engine oil
Fuel quality is insufficient
Cable connections loose or cor-
roded
False valve clearance
Fuel quality is insufficient
False valve clearance
Cooling air channel contaminated
Engine oil level too low
Engine oil level too high
Air filter polluted
Engine oil level too high
Air filter polluted
Fuel quality is insufficient
False valve clearance
Engine oil level too low
Too much incline
Wrong grade of engine oil
Engine oil level too high
Too much incline
SOLUTION
Actuate the choke
Change oil according to specification
Use fuel according to specification
Check cable connections
Check and adjust if necessary
Use fuel according to specification
Check and adjust if necessary
Clean the cooling air channel
Top up the engine oil
Drain the engine oil
Clean the air filter
Drain the engine oil
Clean the air filter
Use fuel according to specification
Check and adjust if necessary
Top up the engine oil
Set the power generator horizontal
Change oil according to specification
Drain the engine oil
Set the power generator horizontal
Seite 39