General Warnings; Hazards; Operating And Maintenance Personnel; Inserting Replacement And Wearing Parts - Sartorius Stedim Biotech Sartocheck 3 plus Betriebsanleitung

4

General Warnings

4.1

Hazards

The safety systems and safety
notes described in these operating
instructions should be complied
with accordingly.
Keep the work area of the filter
cartridge housing free of objects
during operation so that unimpeded
access is possible at all times.
Before any installation, servicing
or repair work is carried out, make
sure you are aware of the electrical
hazards!
Unplug the equipment from the
wall outlet (mains supply) before
opening it!
Observe the required operating
conditions, especially with regard
to the temperature of the medium.
It is transmitted to the components.
Touching components or contact
with the medium can result in
burns or scalding.
Wear suitable protective clothing
if necessary. Don't forget that the
components of the filter cartridge
housing store heat and cool down
slowly.
4.2 Operating and Maintenance
Personnel
Operating personnel and service
and maintenance personnel are
persons who are responsible for the
transport, installation, operation,
equipping, maintenance and clean-
ing as well as troubleshooting on
the unit.
1. The unit may only be operated
by trained and authorized persons
in accordance with operating
instructions that have been issued
by the operator.
2. The responsibilities for operation
of the unit must be clearly set
down and observed so that no
ambiguities arise with respect
to safety.
3. The safety precautions and
warnings given in the operating
instructions must be complied
with when carrying out any work
(operation, maintenance, repairs
etc.).
4. The operator shall never work in
any way that could impair the
safety of the unit or him|herself
or others.
5. It is the responsibility of the
operator to ensure that only
authorized persons work on
the unit.
6. It is the responsibility of the
operator to report immediately any
changes occurring on or to the unit
to the operating company.
7. It is the responsibility of the
operator to ensure that the unit is
only operated in perfect working
condition.
4.3 Inserting Replacement and
Wearing Parts
We must expressly draw your atten-
tion to the fact that replacement
parts and accessories that not have
been supplied by Sartorius Stedim
Biotech GmbH have not been tested
and approved by Sartorius Stedim
Biotech GmbH. The installation of
and|or the use of such products
can therefore have a negative effect
on the design properties of the unit
as constructed.
Sartorius Stedim Biotech GmbH is
not liable for any damages resulting
from the use of non-original parts
or non-original accessory parts.
Standard parts can be purchased
from specialized dealers.
4.4

Switch-off Procedures

!
The following shutdown procedure
must be followed before any
cleaning, servicing or repair work
is carried out.
1. Line disconnect
Turn off the main switch by pulling
out the AC adapter of the mains
supply.
2. Compressed air supply
Turn off the compressed air supply
and vent system.
Personnel may suffer physical
injuries or fatalities if this procedure
is not followed!
11