Troubleshooting; Troubleshooting Table - Handicare Winner Bedienungsanleitung

Troubleshooting

7 Troubleshooting
If your Winner will not function, even though the batteries are fully charged, check the
following points before getting in touch with your dealer.
1. Check whether all battery clamps are securely in place.
2. Check whether it is in DRIVE position (not NEUTRAL).
3. Check if the automatic safety fuse has jumped out. If it has, push the fuse back in
again.
If it jumps out again, contact your dealer.
4. The scooter has a troubleshooting diagnosis system that can be read by the dealer
with special hard and software.
7.1

Troubleshooting table

If your scooter will not drive, or does not drive as it should, please check the list below
first, to see if you can solve the problem yourself, before approaching the dealer.
Possible cause
The contact plug is not properly put
into the contact.
The connectors in the motor
compartment are not put into the
controller properly, or they are loose.
The battery clamps are not fastened
properly.
Neutral is on.
The automatic safety fuse has jumped
out.
There is a loose connection in the
wiring or a connector.
The battery voltage is too low.
The scooter drives too slowly.
Overcharge.
Temperature is too high.
Sometimes simply switching the scooter off and back on again will correct the problem.
If you cannot solve the problem by using the list above, contact your dealer.
42
Action
Put the contact plug into the
contact properly.
Check the connectors and make
sure they are put into the
controller properly.
Check the battery clamps and
tighten them.
Switch off the neutral.
•
See 'Automatic fuse'
•
Find the cause and push the
automatic fuse back in when
the problem is solved.
Correct the connection.
•
Check the battery voltage. See
'Battery condition meter'.
•
Charge the batteries.
•
Check operation of the battery
charger.
Turn the speed controller up (by
turning it to the right).
Check whether the scooter was
frequently used on steeps slopes.
Allow the scooter to cool down.
Action to
be taken
by
Yourself
Yourself
Yourself
Yourself
Yourself
Yourself
Yourself
Yourself
Yourself
Yourself