Start Up; Operation - Kärcher KM 75/40 W Bp Bedienungsanleitung

Fault display:
Charger or motor con- glows red
trol malfunction
(2) Charging process for Bp model
 Open the device hood.
 Insert the charging cable of the charger
in the charger box of the sweeper
 Plug in mains connector and switch on
charger.
After charging
 Bp Pack model:
 Disconnect the mains plug.
 Wrap the mains cord around the cable
holder of the charger.
 Close cover.
 Bp model:
 Switch off the charger and remove the
plug from the socket.
 Hang out the charging cable out of the
machine.
 Close cover.
Remove the battery
 Open the device hood.
 Disconnect pole terminal to negative
pole (-).
 Unscrew the connection wires from the
batteries.
 Disconnect pole terminal to positive
pole (-).
 Loosen the holding strap.
 Remove the battery.
 Dispose of the used battery according
to the local provisions.
Recommended batteries, chargers
Order number
Battery 60 Ah 6.654-226.0
Charger 6.654-225.0
Batteries and chargers are available in spe-
cialised stores.
Maximum battery dimensions
Length Width
267 mm 177 mm

Start up

General notes
Danger
Risk of injury! Switch off the appliance prior
to removing the waste container.
Note: Start the appliance only when the
hood is closed.
 Park the sweeper on an even surface.
 Switch off engine.
 Lock parking brake.
Inspection and maintenance work
 Check charging status of battery.
 Check side brush.
 Check roller brush.
 Shake off dust filter.
 Empty waste container.
Note: For description, see section on Care
and maintenance.
Starting the machine
 Release parking brake.
Start the motor.
 Turn the main switch to position "1".
Note: The roller brush and the side brush
will rotate.
Drive forward
 Pull the lever for forward drive.
Note: The drive speed for forward drive
can be adjusted steplessly depending on
the position of the lever.
Dry run
 Release the lever for forward drive. De-
vice comes to a halt.
Driving over obstacles
Driving over fixed obstacles which are 30
mm high or less:
 Raise bulk waste flap.
 Drive forwards slowly and carefully.
Driving over fixed obstacles which are
more than 30 mm high:
 Only drive over these obstacles using a
suitable ramp.
Danger
Risk of injury! If the bulk waste flap is open,
stones or gravel may be flung forwards by
the roller brush. Make sure that this does
not endanger persons, animals or objects.
Caution
Do not sweep up packing strips, wire or
similar objects as this may damage the
sweeping mechanism.
Height
Note: To achieve an optimum cleaning re-
sult, the driving speed should be adjusted
190 mm
to take specific situations into account.
Sweeping with bulk waste flap raised
Note: To sweep up larger items up to a
height of 50 mm, e.g. cigarette packs, the
bulk waste flap must be raised briefly.
Raising bulk waste flap:
 Pull the lever for raising the bulk waste
flap.
Lowering the bulk waste flap:
 Release the lever for raising the bulk
waste flap.
Note: An optimum cleaning result can only
be achieved if the bulk waste flap has been
lowered completely.

Operation

Drive the machine
Sweeping mode
5
-
EN
Sweeping with side brushes
 Move the lever to lower the side brush
to the front. The side brush will be low-
ered.
Sweeping dry floors
Note: During operation, the waste contain-
er should be emptied at regular intervals.
Note: During operation, the dust filter
should be shaken off and cleaned at regu-
lar intervals.
 Close wet/dry flap
Sweeping damp or wet floors
 Open wet/dry flap.
Note: This protects the filter from moisture.
Battery display
The battery display shows the charging sta-
tus of the batteries during operation:
full glows green
30% capacity remain- glows yellow
ing
10% capacity remain- blinks red
ing
Protection against total glows red
discharge; the appli-
ance is switched off
Cleaning the dust filter
 Pull the handle of the filter clean-off out
several times and reinsert it.
Emptying waste container
Danger
Risk of injury! Switch off the appliance prior
to removing the waste container.
Note: Make sure the seal strip is not dam-
aged while emptying the waste container.
Note: The max. load of the waste container
is 40 kg.
 Shake off dust filter.
 Pull lock bow of the waste container up-
ward.
 Pull out the waste container.
 Empty waste container.
 Push in the waste container.
 Push lock bow of the waste container
downward.
17