Service Information; Disposal And Recycling; Troubleshooting - Scheppach Hp1900S Originalbetriebsanleitung

14.2

Service information

With this product, it is necessary to note that the following
parts are subject to natural or usage-related wear, or that
the following parts are required as consumables.
Wearing parts*: Spark plug, oil, V-belt, rubber pad, air fil-
ter
* = may not be included in the scope of delivery!

15 Disposal and recycling

Notes for packaging
The packaging materials are recy-
clable. Please dispose of packag-
ing in an environmentally friendly
manner.

16 Troubleshooting

The following table shows fault symptoms and describes remedial measures in the event of your product failing to work
properly. If you cannot localise and rectify the problem with this, please contact your service workshop.
Fault
Engine does not start
Motor runs erratically
Motor overheating
Engine does not stop when
throttle is in stop position or en-
gine speed does not increase
properly when throttle is moved.
The plate compactor is difficult to
control during operation (product
bounces or moves
abruptly).
No compacting function or the
plate compactor does not reach
the maximum speed
Oil loss from engine or eccentric
vibration unit
Possible cause
Spark plug connector not
connected
No fuel or stale fuel
Throttle not in correct start
position
Blocked fuel line
Oiled spark plug
Not enough oil
Overfilling the engine
Spark plug connector loose
Product running with choke
on
Blocked fuel line or stale fuel Clean the fuel line. Fill the tank with clean, new fuel.
Water or contamination in the
fuel system
Contaminated air filter
Contaminated air filter
Restricted airflow
Deposits in throttle connec-
tions
Pull cord damaged
Engine speed too high on
hard ground
forward
Shock absorber too loose or
damaged
Damage on eccentric vibra-
tion unit or the plate compac-
tor
Drive belt too loose and slip-
ping
Worn seals
Leaks on housing
www.scheppach.com
You can find out how to dispose of the disused
device from your local authority or city
administration.
Fuels and oils
• Before disposing of the product, the fuel tank and the
engine oil tank must be emptied!
• Fuel and engine oil do not belong in household waste
or drains, but must be collected or disposed of sepa-
rately!
• Empty oil and fuel tanks must be disposed of in an en-
vironmentally friendly manner.
Remedy
Connect the spark plug connector securely to the spark
plug.
Fill with clean, new fuel.
Set the throttle to the Start position.
Clean the fuel line.
Clean the spark plug, adjust the gap or replace it.
Check the engine oil level and top it up if necessary.
Wait a few minutes before re-starting.
Connect the spark plug connector and secure it.
Set the choke lever to the OFF position.
Drain the fuel from the tank. Fill with new fuel.
Clean or replace the air filter.
Clean the air filter.
Clean the engine of the plate compactor.
Remove dirt and debris.
Contact specialist dealer.
Set a lower speed with the throttle.
Contact specialist dealer.
Contact specialist dealer.
Adjust or replace the drive belt.
Contact a specialist dealer and have the seals
checked.
GB | 39