Transport; Maintenance And Care - Kärcher KMR 1700 D Bedienungsanleitung

Turn off the appliance.
Push in the engine speed adjustment
completely,
Press brake pedal and keep it de-
pressed.
Lock parking brake.
Raise roller brush.
The side-brushes lift up.
Turn ignition key to "0" and remove it.
Note:Once the machine has been switched
off, the dust filter is shaked automatically
for approx. 10 seconds.

Transport

Danger
Risk of injury and damage! Observe the weight
of the appliance when you transport it.
Turn ignition key to "0" and remove it.
Lock parking brake.
Secure the appliance at the transport
eyelets using tension belts, ropes or
chains.
Secure the wheels of the machine with
wheel chocks.
When transporting in vehicles, secure
the appliance according to the guide-
lines from slipping and tipping over.
Storage
Danger
Risk of injury and damage! Note the weight
of the appliance in case of storage.
Shutdown
If the sweeper is going to be out of service
for a longer time period, observe the follow-
ing points:
Park the sweeper on an even surface.
Raise the roller brush and the side-
brushes to prevent the bristles from be-
ing damaged.
Turn ignition key to "0" and remove it.
Lock parking brake.
Lock the sweeper to ensure that it does
not roll off.
Fill fuel tank and close fuel cock.
Change engine oil.
Drain off the cooling water if frost is ex-
pected and check whether there is ade-
quate anti-frosting agent.
Clean the inside and outside of the
sweeper.
Charge the battery and clamp it off.

Maintenance and care

General notes
– Maintenance work may only be carried
out by approved customer service out-
lets or experts in this field who are famil-
iar with the respective safety
regulations.
– Mobile appliances used for commercial
purposes are subject to safety inspec-
tions according to VDE 0701.
Park the sweeper on an even surface.
Turn ignition key to "0" and remove it.
Lock parking brake.
Cleaning
Caution
Risk of damage! Do not clean the appliance
with a water hose or high-pressure water
jet (danger of short circuits or other dam-
age).
Cleaning the inside of the machine
Danger
Risk of injury! Wear dust mask and protec-
tive goggles.
Clean machine with a cloth.
Blow through machine with com-
pressed air.
External cleaning of the appliance
Clean the machine with a damp cloth which
has been soaked in mild detergent.
Note: Do not use aggressive cleaning
agents.
Maintenance intervals
Note: The elapsed-time counter shows the
timing of the maintenance intervals.
Maintenance by the customer
Daily maintenance:
Check engine oil level.
Check cooler water level.
Check tyre pressure.
Check the sweeping roller and the side
brush for wear and wrapped belts.
Weekly maintenance:
Clean the water cooler.
Check the hydraulic oil level.
Maintenance to be carried out every 100
operating hours or every year:
Change engine oil.
Change the oil filter inlay.
Lubricate the bearings and cylinder.
Check tension of V-Belt.
Check battery acid level.
Clean the fuel filter.
Check fuel hose and clamps.
Clean air filter elements.
Check hydraulic unit.
Maintenance to be carried out every 200
operating hours or every six months:
Check cooler hoses and clamps.
Maintenance following wear:
Replace sealing strips.
Replace roller brush.
Replace side brush.
Note: For description, see section on Main-
tenance work.
Follow instructions in maintenance
booklet 5.950-547!
Note:Where maintenance is carried out by
the customer, all service and maintenance
work must be undertaken by a qualified
specialist. If required, a specialised Archer
dealer may be contacted at any time.
Maintenance by Customer Service
Maintenance to be carried out after 20 op-
erating hours:
Carry out initial inspection.
– Maintenance to be carried out every
400 operating hours or every six
months
– Maintenance to be carried out every
1200 operating hours
7
-
EN
Note: In order to safeguard warranty
claims, all service and maintenance work
during the warranty period must be carried
out by the authorised Kärcher Customer
Service in accordance with the mainte-
nance booklet.
Maintenance Works
Preparation:
Park the sweeper on an even surface.
Turn ignition key to "0" and remove it.
Lock parking brake.
General notes on safety
Danger
Risk of injury! Always apply the safety bar
when the waste container is raised.
Pull out the securing pin and remove
the safety bar from the holder.
Use the safety bar for emptying from a
height.
Please do not release engine
oil, fuel oil, diesel and petrol
into the environment Protect
the ground and dispose of used
oil in an environmentally-clean
manner.
Safety notes regarding the batteries
Please observe the following warning notes
when handling batteries:
Observe the directions on the
battery, in the instructions for
use and in the vehicle operat-
ing instructions!
Wear an eye shield!
Keep away children from acid
and batteries!
Risk of explosion!
25