Hopper Dumping; After Using The Machine; Machine Long Inactivity - Nilfisk Floortec R 870 Kurzanleitung

HOPPER DUMPING

WARNING!
The hopper (11) must be emptied on level grounds only.
Do not lift the hopper when the machine is on a slope.
WARNING!
When lifting and dumping the hopper (11), make sure that there are no people around the machine, especially
near the hopper.
NOTE
When the hopper (11) is lifted, the vacuum system turns off automatically and the machine maximum speed is reduced
for safety reasons.
To empty the hopper, move the machine close to the dustbin and proceed as follows.
1. Lift the side and main brooms.
2. Press the enabling switch (66) while pressing the hopper lifting switch (81) to lift the hopper (A, Fig. 1) up to the desired
position.
3. Drive the machine to the disposal area and engage the parking brake.
4. Dump the hopper (B) with the lever (C) to discharge all dust and debris collected (D).
NOTE
If necessary, manually engage the hopper in position (A) with the returning handle (E) when the hoisting system is lifted
and the hopper is disengaged (B).
CAUTION!
The hopper (A) can be dumped only when lifted at a minimum height of 35 cm approximately.
The maximum dumping height is approx. 150 cm.
5. Lower the hopper by pressing both the enabling switch (66) and the switch (81).
NOTE
To ensure that the hopper (11) is fully retracted, check that the warning light (76) is off.
6. The machine is ready to start sweeping again.

AFTER USING THE MACHINE

After working, before leaving the machine, perform the following procedures.
– Turn on the filter shaker shortly, by pressing the lower part of the switch (65).
– Empty the hopper (11) (see the procedure in the previous paragraph).
– Lift the main broom with the lever (63).
– Lift the side brooms with the lever (64).
– Turn off the machine by turning the ignition key (61) to "0", then remove it.
– Engage the parking brake.
– If necessary, charge the batteries (see the procedure in Maintenance chapter in the User Manual).

MACHINE LONG INACTIVITY

If the machine is not going to be used for more than 30 days, proceed as follows:
– Check that the machine storage area is dry and clean.
– Disconnect the battery connector (45).
– (For machines equipped with dust guard system). Empty the tank (24) and clean the water filter (see the procedure in
Maintenance chapter in the User Manual).
1464822000(1)03-2013.indb 35
QUICK START GUIDE
A
max
100 Kg
(220 lb)
Figure 1
1464822000 - FLOORTEC R 870
ENGLISH
C E
D
P100592
18-Mar-13 11:26:53
B
35