Werbung
Verfügbare Sprachen
Verfügbare Sprachen
2
Safety
2.1
General safety notes
NOTICE
Hazardous atmosphere!
There is a risk of a hazardous atmosphere occurring in the chamber system during work.
Make sure the system is well aerated.
Use safety equipment such as e.g. a multi-gas warning device if necessary.
WARNING
Explosive gas mixture can escape from tanks! The gases formed by the separated material are potentially
explosive.
Empty system tanks regulaly containing separated material!
Avoid naked flames and sparks during disposing or dismantling.
Always ensure that the room is ventilated properly.
WARNING
Explosion hazard due to transfer of an EX-zone. Inadequate aeration and ventilation in connected systems
can cause the gas released by the separated material to spread into downstream systems where it can
cause an explosive mixture of gases.
On connecting a separator system, ensure proper ventilation of the downstream drainage system (especially lift-
ing stations or pumping stations).
WARNING
Transport risk / system's own weight!
Check the weight of the system / system components (see "Technical data", page 24).
Pay attention to correct lifting and ergonomic factors.
Standing under overhead loads is prohibited.
The cover plate may only be transported tightly lashed down on the pallet.
CAUTION
Note the structural calculations for traffic safety. Chamber installation for load class D requires a load distribution
slab made of reinforced concrete or a binder layer with asphalt.
Determine the required load class and structural calculations in accordance with the environment / use condi-
tions.
Note the relevant information: Reinforcement plan on the website or see "Bewehrungsplan Fettabscheider Oval",
page 104 and see "Installation", page 26.
CAUTION
Hot surfaces!
Pumps can become very hot during operation.
Wear protective gloves or allow the pump to cool.
Prescribed personal protective equipment!
Always use personal protective equipment during installation, maintenance and disposal work on the system.
Protective clothing
Protective gloves
Safety footwear
Face protection
Operating and maintenance instructions must be kept available at the product.
2.2
Personnel - qualification
The relevant operational safety regulations and the hazardous substances ordinance or national equivalents apply for the
operation of the system.
The operator of the system must:
prepare a risk assessment
identify and demarcate corresponding hazard zones
carry out safety training
secure the system against unauthorised use.
016-310
Installation and operating instructions
21 / 112
Werbung
