Inhaltsverzeichnis - Jacobsen Greens King IV Handbuch

FOREWORD
This manual contains safety and operating instructions
for your new Jacobsen machine. This manual should be
stored with the equipment for reference during operation.
Before you operate your machine, you and each operator
you employ should read the manual carefully in its
entirety. By following
maintenance instructions, you will prolong the life of your
equipment, and maintain its maximum efficiency.
If additional information is needed, contact your
Jacobsen Dealer.
CONTENTS
SAFETY
1.1 Operating Safety . . . . . . . . . . . . . . . . . . . . . . 3
1.2 Important Safety Notes. . . . . . . . . . . . . . . . . 4
CONTROLS
2.1 Icons. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
2.2 Control Descriptions . . . . . . . . . . . . . . . . . . . 7
SET-UP
3.1 General. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
3.2 Initial Inspection . . . . . . . . . . . . . . . . . . . . . . 8
3.3 Reel Motors . . . . . . . . . . . . . . . . . . . . . . . . . 8
3.4 Torsion Springs . . . . . . . . . . . . . . . . . . . . . . 9
3.5 Anti-Sway Springs . . . . . . . . . . . . . . . . . . . . 9
3.6 Grass Catchers . . . . . . . . . . . . . . . . . . . . . . 9
3.7 Steering Wheel. . . . . . . . . . . . . . . . . . . . . . 10
3.8 ROPS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
3.9 Fuel Hose Routing . . . . . . . . . . . . . . . . . . . 11
3.10 Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
3.11 Reel Adjustments . . . . . . . . . . . . . . . . . . . . 11
3.12 Operating Checks. . . . . . . . . . . . . . . . . . . . 12
3.13 Interlock System. . . . . . . . . . . . . . . . . . . . . 12
© 2009, Jacobsen, A Textron Company/Textron Innovations Inc.
"All rights reserved, including the right to reproduce this material
or portions thereof in any form."
2
the safety, operating,
Litho In U.S.A. 9-2014
The serial plate is attached to the frame near the battery.
Jacobsen recommends you record these numbers below
for easy reference.
and
CHARLOTTE, NC
ADJUSTMENTS
4.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
4.2 Bedknife-To-Reel . . . . . . . . . . . . . . . . . . . . 13
4.3 Bedknife Adjustment . . . . . . . . . . . . . . . . . . 14
4.4 Cutting Height . . . . . . . . . . . . . . . . . . . . . . . 14
4.5 Reel Bearing . . . . . . . . . . . . . . . . . . . . . . . . 15
4.6 Lift Cylinders . . . . . . . . . . . . . . . . . . . . . . . . 15
4.7 Antisway Spring . . . . . . . . . . . . . . . . . . . . . 15
4.8 Leveling Procedure . . . . . . . . . . . . . . . . . . . 16
4.9 Accelerator Pedal . . . . . . . . . . . . . . . . . . . . 16
4.10 Brake Pedal. . . . . . . . . . . . . . . . . . . . . . . . . 16
4.11 Parking Brake . . . . . . . . . . . . . . . . . . . . . . . 17
4.12 Interlock Switches . . . . . . . . . . . . . . . . . . . . 17
4.13 Reel Switches . . . . . . . . . . . . . . . . . . . . . . . 17
4.14 Traction Lever . . . . . . . . . . . . . . . . . . . . . . . 18
4.15 Reel Control . . . . . . . . . . . . . . . . . . . . . . . . 18
4.16 Steering Cable Adjustment . . . . . . . . . . . . . 18
4.17 Choke Control . . . . . . . . . . . . . . . . . . . . . . . 19
4.18 Specific Torque Requirements . . . . . . . . . . 19
4.19 Torque Specification . . . . . . . . . . . . . . . . . . 20
TROUBLESHOOTING
5.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
LUBRICATION CHART
6.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
6.2 Lubrication Chart. . . . . . . . . . . . . . . . . . . . . 22
NOTES
This
chemicals known to the State of
California to cause cancer and birth
defects or other reproductive harm.
A Textron Company
PRODUCT OF U.S.A.
Proposition 65 Warning
product contains or
®
emits