Engine Weekly: (Every 50 Working Hours); Clutch And Layshaft Cover - Ransomes Super Certes 51 Sicherheits-, Bedienungs- Und Wartungshandbuch

10 MAINTENANCE
10.2

ENGINE WEEKLY: (EVERY 50 WORKING HOURS) _____________________

Air cleaner (dual element type)
Remove the wing nut and the air cleaner cover.
Remove the elements and sperate them. Carefull check
both elements for holes or tears and replace if damaged.
Cleaning the Foam Element: Wash the element in a
solution of household detergent and warm water, then
rinse thoroughly, or wash in nonfl ammable or high flash
point solvent allow the element to dry thoroughly.
Soak the element in a clean engine oil and squeeze out
the excess oil. The engine will smoke during initial start-
up if too much oil is left in the foam.
Cleaning the Paper Element: Tap the element lightly
several times on a hard surface to remove excess dirt, or
blow compressed air through the filter from the inside out.
Never try to brush the dirt off; brushing will force dirt into
the fibres. Replace the paper element if it is excessively
dirty.
Reassemble the parts in their original positions.
IMPORTANT: Dirt wears engines. Incorrect maintenance of the air cleaner will cause premature wear.
Service more frequently if the air cleaner is very dirty or if operating in dusty conditions.
10.3

CLUTCH AND LAYSHAFT COVER __________________________________

Undo the fixing screws for cover [A] and remove cover.
Grass can then be cleared from the primary clutch and
layshaft area.
When completed replace cover and secure with original
fixings.
LANDROLL BRAKE
Check for wear on the brake band and adjust as
described in section 8.15.
en-52
Fig 10.2
A
Fig 10.3