Seite 3
Alle 5000 Stunden - Cada 5000 Horas - Cada 5000 Horas .......... 81 Garantía Limitada De 3 Años Para Motor Diesel Kohler ........127-129 Garantia Limitada De 3 Anos Kohler Para Motor a Diesel ........131-133 Storage - Immagazzinaggio - Stockage - Lagerung - Almacenaje - Armazenagem ......................
SAfETy PRECAUTIoNS To ensure safe operation please read the following statements and understand their meaning. Also refer to your equipment manufacturer's manual for other important safety information. This manual contains safety precautions which are explained below. WARNING Warning is used to indicate the presence of a hazard that can cause severe personal injury, death, or substantial property damage if the warning is ignored.
Seite 5
WARNING WARNING CAUTIoN WARNING Explosive Gas can cause fires Electrical Shock can cause High Pressure fluids can fuel can cause fires and severe and severe acid burns. puncture skin and cause severe injury. burns. injury or death. Charge battery only in a well Do not touch wires while engine is Do not fill the fuel tank while the ventilated area.
NoRmE DI SICUREZZA Al fine di garantire un utilizzo sicuro, si prega di leggere attentamente le seguenti istruzioni ed accertarsi di averne compreso il significato. Si raccomanda di consultare anche il manuale d’uso della propria apparecchiatura su cui sono riportate altre informazioni importanti per la sicurezza. Il presente manuale contiene le norme di sicurezza spiegate di seguito.
Seite 7
AVVERTENZA AVVERTENZA ATTENZIoNE AVVERTENZA I fluidi sotto alta pressione Le scosse elettriche possono Il combustibile esplosivo può Il gas esplosivo può provocare possono penetrare sottocute e provocare incendi e gravi ustioni. provocare gravi lesioni incendi e gravi ustioni. causare lesioni gravi o letali. personali.
PRÉCAUTIoNS DE SÉCURITÉ Afin de garantir une utilisation en toute sécurité, lire les instructions suivantes et s’assurer d’en comprendre la signification. Consultez également le manuel du fabricant de l’équipement pour obtenir d’autres informations importantes concernant la sécurité. Ce manuel contient des précautions de sécurité expliquées ci- dessous.
Seite 9
ATTENTIoN AVERTISSEmENT AVERTISSEmENT AVERTISSEmENT Le carburant explosif peut causer Les gaz explosifs peuvent Les liquides à haute pression Une décharge électrique peut peuvent transpercer la peau et des incendies et de graves causer des incendies et de provoquer des blessures provoquer des blessures graves ou brûlures.
SICHERHEITSVoRKEHRUNGEN Zur Gewährleistung eines sicheren Betriebs sind folgende Hinweise zu lesen und ihre Bedeutung zu verstehen. Weitere wichtige Sicherheitsinformationen entnehmen Sie dem Herstellerhandbuch für Ihre Ausrüstung. Das vorliegende Handbuch enthält Sicherheitsvorkehrungen, die im Folgenden näher erläutert werden. Lesen Sie diese Angaben aufmerksam durch. WARNUNG Warnung wird benutzt, um auf das Vorhandensein einer Gefahr aufmerksam zu machen, die zu schweren Personenschäden, Tod oder beträchtlichem Sachschaden führen kann, wenn die Warnung ignoriert wird.
WARNUNG WARNUNG ACHTUNG WARNUNG flüssigkeiten, die unter hohem Explosives Gas kann Brände Elektrische Schläge können Explosiver Kraftstoff kann Druck herausspritzen, können in und schwere Säureverätzungen Verletzungen verursachen. Brände und schwere die Haut eindringen und schwere verursachen. Verbrennungen verursachen. Berühren Sie bei laufendem Motor oder tödliche Verletzungen Laden Sie die Batterie nur in einem keine elektrischen Leitungen.
PRECAUCIoNES DE SEGURIDAD Para garantizar un funcionamiento seguro, lea detenidamente las siguientes instrucciones. Consulte también el manual del fabricante de su equipo, donde encontrará más información de seguridad importante. A continuación se explican las precauciones de seguridad del presente manual. Le rogamos que las lea atentamente.
Seite 13
ADVERTENCIA ADVERTENCIA ADVERTENCIA PRECAUCIÓN El gas explosivo puede provocar Las descargas eléctricas pueden Los líquidos a alta presión La explosión del carburante pueden perforar la piel y provocar provocar lesiones. incendios y quemaduras graves puede provocar incendios y lesiones graves o la muerte. por ácido.
PRECAUÇÕES DE SEGURANÇA Para garantir o funcionamento seguro, por favor, leia e compreenda as indicações seguintes. Consulte também o manual do fabricante do equipamento relativamente a outras informações de segurança importantes. Este manual contém precauções de segurança que se encontram explicadas abaixo. Por favor leia atentamente.
ADVERTÊNCIA AVISo ADVERTÊNCIA ADVERTÊNCIA fluidos de Alta Pressão podem o Gás Explosivo pode causar o Combustível Explosivo pode o Choque Eléctrico pode causar perfurar a pele e causar ferimentos incêndios e queimaduras de causar incêndios e queimaduras ferimentos. graves ou morte. ácido graves.
overview of Periodic maintenance Indice Riassuntivo delle operazioni di Prima manutenzions Index récapitulatif des opérations de premier entretien Inhaltsverzeichnis der ersten Wartungsarbeiten Indice compendioso de las operaciones de manutencion Indice resumidor das operações de primeira manutenção - THESE REQUIRED MAINTENANCE PROCEDURES SHOULD BE PERFORMED AT THE FREQUENCY OUTLINED IN EACH SECTION. - GLI INTERVALLI DI MANUTENZIONE PREVENTIVA QUI RIPORTATI SONO VALIDI PER L’UTILIZZO DEL MOTORE FATTO FUNZIONARE IN CONDIZIONI D’ESERCIZIO NORMALI E CON COMBUSTIBILE E OLIO CONFORMI ALLE CARATTERISTICHE TECNICHE RIPORTATE IN QUESTO MANUALE.
Seite 17
overview of Periodic maintenance operations Indice Riassuntivo delle operazioni di Prima manutenzione Index Récapitulatif des opérations de Premier Entretien Inhaltsverzeichnis der Ersten Wartungsarbeiten Indice Compendioso de las operaciones de manutencion Indice Resumidor das operações de Primeira manutenção CHECK - CoNTRoLLo - CoNTRÔLE - KoNTRoLLE - ComPRoBACìoN - CoNTRÔLE fREQUENCy x HoURS - PERIoDICITA’...
Seite 18
overview of Periodic maintenance operations Indice Riassuntivo delle operazioni di Prima manutenzions Index récapitulatif des opérations de premier entretien Inhaltsverzeichnis der ersten Wartungsarbeiten Indice compendioso de las operaciones de manutencion Indice resumidor das operações de primeira manutenção Replace - Sostituzione - Remplacement - Auswechseln - Sustitución - Substituição oPERATIoN DESCRIPTIoN - DESCRIZIoNE oPERAZIoNE - DESCRIPTIoN DE fREQUENCy x HoURS - PERIoDICITA’...
Seite 19
overview of Periodic maintenance operations Indice Riassuntivo delle operazioni di Prima manutenzione Index Récapitulatif des opérations de Premier Entretien Inhaltsverzeichnis der Ersten Wartungsarbeiten Indice Compendioso de las operaciones de manutencion Indice Resumidor das operações de Primeira manutenção - Using the proper type and weight of oil in the crankcase is extremely important. So is checking oil daily If engine use is infrequent;...
ENGINE IDENTIfICATIoN - IDENTIfICAZIoNE moToRE - IDENTIfICATIoN moTEUR - IDENTIfIZIER- UNGSDATEN - IDENTIfICACIoN DEL moToR - IDENTIfICAÇÃo Do moToR model Number Tipo motore MADE IN ITALY Type moteur Tipo motor Tipo do motor Giri/1’ XX XX XXXX XXXX Model Tours/mn Serial Number Eingestellte Drehzahl XX XX XXXX...
EPA LABEL - TARGHETTA NoRmE EPA - PLAQUETTE NoRmES EPA - EPA-RICHTLINIEN - PLACA NoRmAS EPA - PLACA NoRmAS EPA - EPA Label Shown on the Recoil Starter or on Air Shroud - Targhetta per Norme EPA Applicata Sull’Autoavvolgente o Sul Convogliatore - Plaquette pour Normes EPA Appliquée Sur l’Enrouleur Automatique ou sur le Convoyeur - Schild für EPA-Richtlinien, Angebracht Auf Dem selbstaufrollenden Startseil oder Auf der Kühlerhaube - Placa para las Normas EPA Puesta Aobre el Arranque Recuperable o Sobre el Canalizador de Aire...
The information contained within this manual is the sole property of Kohler Co. As such, no reproduction or replication in whole or part is allowed without the express written permission of Kohler Co.
Seite 23
1. le persone che effettuano un lavoro di servizio su motori Kohler siano adeguatamente addestrate ed attrezzate per provvedere in modo sicuro e professionale alle operazioni necessarie; 2. le persone che effettuano un lavoro di servizio su motori Kohler posseggano un’adeguata manualità e gli attrezzi speciali Kohler per provvedere in modo sicuro e professionale alle operazioni necessarie;...
Seite 24
PREfACE Nous avons fait le possible pour donner dans ce manuel des informations techniques soignées et à jour. Le développement des moteurs Kohler est toutefois continu ; par conséquent les informations données par cette publication sont sujettes à des variations sans obligation de préavis.
Die Informationen in diesem Werkstatthandbuch setzt voraus: 1. Das die Person oder Personen, die die Arbeiten ausführen an der Motortypreihe Kohler gut geschult sind und die notwendigen Kenntnisse haben für diese Arbeiten; 2. Das die Person oder Personen, die die Arbeiten ausführen an der Motortypreihe Kohler über die notwendigen Werkzeuge und Spezialwerzeuge verfügen, um die Arbeiten auszuführen;...
Seite 26
PREmISA Hemos procurado hacer lo posible por dar información técnica precisa y al dia en el interior de este manual. La evolución de los motores Kohler es sin embargo continua por lo tanto la información contenida en el interior de esta publicación está sujeta a variaciones sin obligación de previo aviso.
Seite 27
NoTAS GERAIS DE SERVIÇo 1. Utilize apenas peças de substituição originais da Kohler. A utilização das peças de reposição incorrectas pode causar danos graves ou desgaste ao motor e com isto anular a garantia.
SPECIfICATIoNS - CARATTERISTICHE - CARACTERISTIQUES TECHNISCHE DATEN - CARACTERISTICAS - CARACTERÍSTICAS ENGINE moDEL - moDELLo DI moToRE - TyPE DE moTEUR - KD625-2 moToRENTyPE - TIPo DE moToR - TIPo DE moToR Cylinders - Cilindri - Cylindres - Zilinderzahl - Cilindros - Cilindros...
Failure to follow the maintenance instructions and procedures outlined in this manual, may cause severe engine wear or damage, and will void the warranty. Use only genuine Kohler repair parts. Failure to use the correct replacement part may cause severe engine wear, or damage, and will void the warranty.
oIL USAGE EmPLoI BEDIENUNG UTILISACIoN UTILIZAÇÃo NoTE: Using the proper type and weight of oil in the crankcase is extremely important. Check oil daily and change oil according to the maintenance schedules specified in this manual. Failure to use the correct oil type, or using dirty oil, will cause premature engine wear and failure, and will void the warranty. To prevent extensive engine wear or damage, always maintain the proper oil level in the crankcase.
Avoid prolonged or repeated skin contact with used engine oil, or wear protective gloves. Used oil has been linked to skin cancer in laboratory animals. If contact cannot be avoided, thoroughly wash exposed areas with soap and water. Respect the environment; dispose of oil in accordance with local ordinances. L’olio motore esausto può...
KLASSIfIZIERUNG SAE Bei der Klassifizierung SAE werden die Öle auf der Grundlage ihrer Viskosität bewertet. Andere qualitative Eigenschaften werden nicht berücksichtigt. Die erste Zahl bezieht sich auf die Viskosität im kalten Zustand für den Einsatz in der kalten Jahreszeit (Symbol W = Winter ), während sich die zweite Zahl auf die heiße Jahreszeit bezieht. Die Auswahlkriterien müssen im Winter die Mindesttemperatur, der der Motor ausgesetzt wird, und im Sommer die Höchsttemperatur für den Betrieb berücksichtigen.
INTERNATIoNAL LUBRICANT SPECIfICATIoNS They define testing performances and procedures that the lubricants need to successfully respond to in several engine testing and laboratory analysis so as to be considered qualified and in conformity to the regulations set for each lubrication kind. A.P.I.: American Petroleum Institute MIL:...
INTERNATIoNALE SPEZIfIKATIoNEN fÜR SCHmIERmITTEL Mit diesen Spezifikationen werden die Leistungen und die Testverfahren definiert, die die Schmiermittel erfolgreich in verschiedenen Motortests und bei Laboruntersuchungen bestehen müssen, damit sie als geeignet und normgerecht für die erforderliche Schmierart eingestuft werden. A.P.I.: American Petroleum Institute MIL: Militär-Spezifikation USA für Motoröle, erlassen aus logistischen Gründen ACEA:...
ACEA REGULATIoNS - NoRmE ACEA - NoRmES ACEA - VoRSCHRIfTEN ACEA - NoRmAS ACEA - NoRmAS ACEA SEQUENZE ACEA - SEQUENCES ACEA - ACEA SEQUENCES - ACEA-SEQUENZEN - SECUENCIAS ACEA - SEQUÊNCIAS ACEA HEAVy DUTy DIESEL ENGINE oIL - DIESEL PESANTI - DIESEL LoURD - DIESELmoToREN fÜR GASoLINE/DIESEL ENGINE oIL - PETRoL - BENZINA - ESSENCE - BENZIN - GASoLINA SCHWERE ARBEITEN - DIESEL PESADo - GASoLIo TIPo PESADo A1 = Low-Viscosity Oil for Friction Reduction...
oIL RECommENDATIoNS Specifications oLIo PRESCRITTo Specifiche mULTIGRADE HUILE CoNSEILLÉE API Cf4/SG Spécification 10W40 VoRGESCHRIEBENE SCHmIERÖLE ACEA B2-E2 Spezifikation AGIP ACEITE REComENDADo mIL-L-46152 D/E Especificado SUPERDIESEL ÓLEo REComENDADo Especificação - Using the proper type and weight of oil in the engine is extremely important, as is daily checking of oil level and changing oil regularly. Failure to use the correct oil, or using dirty oil, will cause premature engine wear, failure, and may void the warranty.
Adding oil NoTE: Make sure engine is stopped, level, and cool so oil has time to drain into sump. Rifornimento olio motore Ravitaillement Huile moteur NoTE: Il rifornimento e il controllo livello olio deve essere effettuato con il motore in posizione orizzontale. Nachfüllen von motorÖl Rellenado del Aceite motor NoTE: Le ravitaillement et le contrôle du niveau d’huile doit être fait avec le moteur sur une surface plane.
Engines With oil Bath Air NoTE: Respect the environment; dispose of oil in accordance with local ordinances. Air Cleaner filling Cleaner Rifornimento olio filtro Aria Per motori con filtro Aria a NoTE: Non disperdere l’olio esausto in ambiente in quanto altamente inquinante. Ravitaillement huile filtre à...
fuel Warning WARNING: Explosive fuel vapors can cause severe injury or death. Vaporized fuels are highly explosive. Use extreme care when Rifornimento Combustibile handling and storing fuels. Store fuels in a well-ventilated area away from spark producing equipment and out of the reach of children. Never add fuel to the tank while the engine is running because spilled fuel may ignite on contact with hot parts or from sparks.
Seite 42
DIESEL fUEL fUEL RECommENDATIoNS Purchase diesel fuel in small quantities and store in clean, approved containers. Clean fuel prevents the diesel fuel injectors and pumps from clogging. Do not overfill the fuel tank. Leave room for the fuel to expand. Immediately clean up any spillage during refueling. Never store diesel fuel in galvanized containers;...
ComBUSTIBILE SPECIfICHE ComBUSTIBILE Acquistare il combustibile in piccole quantità e conservarlo in contenitori adeguati e puliti. La pulizia del combustibile previene l’ostruzione degli iniettori. Non riempire completamente il serbatoio combustibile. Lasciare spazio al combustibile per espandersi. Pulire immediatamente ogni fuoriuscita di combustibile durante il rifornimento. Non conservare mai il combustibile in contenitori galvanizzati;...
Seite 44
ComBUSTIBLE SPÉCIfICATIoNS DU CARBURANT Acheter le carburant en petites quantités et le conserver dans des conteneurs propres et adéquats. Le nettoyage du carburant empêche les injecteurs de se boucher. Ne pas remplir complètement le réservoir à carburant. Laisser l’espace nécessaire au carburant pour s’étendre. Nettoyer immédiatement toute sortie de carburant pendant le ravitaillement. Ne jamais conserver le carburant dans des conteneurs galvanisés ;...
KRAfTSToff SPEZIfIKATIoNEN fÜR DEN KRAfTSToff Der Kraftstoff sollte in kleinen Mengen gekauft und in geeigneten und sauberen Behältern gelagert werden. Die Verwendung von gereinigtem Kraftstoff beugt der Verstopfung der Einspritzdüsen vor. Der Kraftstofftank sollte nicht vollständig gefüllt werden. Die Ausdehnung des Kraftstoffs sollte ermöglicht werden. Bei Kraftstoffaustritten während dem Betanken sollten diese unverzüglich entfernt werden.
ComBUSTIBLE ESPECIfICACIoNES DEL ComBUSTIBLE Comprar el combustible en pequeñas cantidades y guardarlo en recipientes adecuados y limpios. La limpieza del combustible previene la obstrucción de los inyectores. No llenar completamente el depósito de combustible. Dejar espacio para que el combustible pueda expandirse. Limpiar inmediatamente los derrames de combustible durante el rellenado. No conservar jamás el combustible en recipientes galvanizados;...
Seite 47
ComBUSTÍVEL ESPECIfICAÇÕES Do ComBUSTÍVEL Adquira combustível em pequenas quantidades e guarde-o em recipientes adequados e limpos. A limpeza do combustível evita a obstrução dos injectores. Não encha completamente o depósito do combustível. Deixe espaço para que o combustível se expanda. Limpe imediatamente sempre que ocorrer uma saída de combustível durante o abastecimento. Nunca guarde o combustível em recipientes galvanizados;...
- Do not overfill fuel tank. Leave room for fuel to expand. Clean up any spillage that occurs during refueling. Adding fuel - Non riempire completamente il serbatoio, ma tenersi a circa 1 cm dal livello massimo, onde permettere un certo movimento del Rifornimento Combustibile carburante.
Air Bleeding - Unscrew the union bolt connected to the pipe coming from the injection pump overflow. Air bleeding Disareazione - Svitare il bullone raccordo collegato al tubo proveniente dal rifiuto pompa iniezione. Desareation Disareazione Entlüftung - Dévisser le boulon relié au tuyau provenant de l’évacuation de la pompe d’injection. Desareation Purgado del Circuito de - Die Anschlussschraube, die an die Leitung angeschlossen ist, die vom Rücklauf der Einspritzpumpe...
Seite 50
- Do NoT manually operate the fuel pump with the engine running. - Operate fuel pump with lever on mechanical feeding pump. - Evitare tassativamente di azionare il comando manuale della pompa di alimentazione con - Pompare il combustibile manualmente con la leva sulla pompa alimentazione meccanica.
- Do not use starting fluids because vapors are flammable. STARTING - Non usare liquidi per l’avvio, poiché i vapori sono infiammabili. AVVIAmENTo - Ne pas utiliser de liquides de démarrage car les vapeurs sont inflammables. DEmARRAGE - Bitte verwenden Sie aufgrund der brennbaren Dämpfe keine Startflüssigkeiten. ANLASSEN - No use fluidos de arranque, pues sus vapores son inflamables.
Seite 52
- Turn key to (2 ) - Starting. - Turn key to (1 ) - Warning Light On. - 2° scatto - Avviamento. - 1° Scatto - Accensione Spie. Position - Démarrage. Position - Eclairage des - Zweite Stellung - Starten. Témoins.
INDICAToRS DESCRIPTIoN - DESCRIZIoNE DELLE SPIE - DESCRIPTIoN DES VoyANTS BESCHREIBUNG DER KoNTRoLLLAmPEN - DESCRIPCIÓN DE LoS TESTIGoS – DESCRIÇÃo DoS INDICADoRES LUmINoSoS Indicator oK - Spia oK - Voyant oK - Kontrolllampe oK - Testigo oK - Indicador Luminoso oK - Turns on when the engine is running/on and the other indicators are off.
Seite 54
oil or Cylinder over-Temperature Indicator - Spia Sovratemperatura olio o Testa motore - Voyant Surchauffe de l’Huile ou de la Culasse - Kontrolllampe Übertemperatur Öl oder Zylinderkopf - Testigo Sobretemperatura aceite o Cabeza motor - Indicador Luminoso de Sobreaquecimento do Óleo ou do Cabeçote motor - Turns on when oil or cylinder temperature limits have been exceeded.
- Run at idle speed for a few minutes according to table. Temperature (outside) Time AfTER STARTING Temperatura Tempo Température Durée DoPo L’AVVIAmENTo - Al minimo per qualche minuto come da tabella. Temperatur Zeit Temperatura Tiempo APRES LE DEmARRAGE - Au minimum pendant quelques minuts d’après tableau. Temperatura Tempo Below -4°F (≤...
NOTA: As operações de manuntenção fazem-se com o motor frio. Use only genuine Kohler repair parts. failure to use the correct replacement parts could cause severe engine wear or damage, and may void the warranty. follow all procedures and recommendations in this document.
Change oil Change oil filter After first 50 Hours of operation Sostituzione filtro olio Sostituzione olio motore Remplacement filtre à Huile Solo Dopo le Prime 50 ore Remplacement Huile moteur Ölfilter-Wechsel Apres les 50 Premieres Heures Öldaten-Wechsel Sostitución filtro Aceite Nach Den Erseten 50 Betriebsstunden Sostitución Aceite del motor Substituição filtro Óleo...
Seite 58
Engines With oil Bath Air Cleaner Per motori con filtro Aria a Bagno d’olio Pour moteur Avec filtre Air en Bain d’Huile für motoren mit Ölbadluftfilter Para motores con filtro Aire a Baño de Aceite Para motores com filtro ar a banho de Óleo - Open oil bath canister and remove the upper element.
Seite 59
- Remove lower filter. - Clean upper canister. - Reinstall upper element. - Togliere la massa filtrante - Rimontare la massa filtrante - Pulire la vaschetta superiore. inferiore. superiore. - Nettoyer la cuve supérieure. - Déposer la masse filtrante - Remonter la masse filtrante - Oberen Filterbecher reinigen.
Seite 60
NoTE: Use only genuine Kohler repair parts. NoTE: Utilizzare esclusivamente ricambi Kohler. NoTE: Utiliser uniquement des pièces de rechange Kohler d’origine. BEmERKUNG: Nur Original-Ersatzteile von Kohler verwenden. NoTA: Use únicamente piezas de repuesto originales Kohler. NoTA: Utilize apenas peças de substituição originais da Kohler.
Seite 61
- Lightly tap filter to dislodge debris. Do not wash paper element or use pressurized air, as this will damage element. Replace a dirty, bent, or damaged element with a genuine Kohler element. - In caso di necessità battere l’elemento su una superficie dura, leggermente e ripetutamente, in modo da eliminare la sporcizia in eccesso. Non usi l’aria compressa per pulire il filtro.
Seite 62
Motorbeschädigungen oder hohem NoTA: Use únicamente piezas de repuesto originales Kohler. NoTA: Utilize apenas peças de substituição originais da Kohler.. NoTE: Securely mount air filter and cover to prevent dust or other impurities from bypassing filtration system and damaging engine.
Inspect fuel Lines - Examine fuel lines for leaks. Controllo Tubi Carburante - Verificare che i tubi siano esenti da perdite. Contrôle Tuyaux Combustibile - Vérifier s’il n’y a pas de fuites dans les tuyaux. Krafstoffleitungen-Kontrolle - Sicherstellen, dass im Kraftstoffleitungen keine Comprobacíon Tubos de Combustibile Kraftstoffleckagen vorliegen.
Seite 64
NoTE: When using compressed air, always wear protective - Use compressed air on cylinder cooling fins and flywheel. goggles. NoTE: Quando viene usata aria compressa è importante utilizzare - Soffiare con aria compressa le alette cilindro e volano. occhiali protettivi. - Souffler de l’air comprimé...
Seite 65
- Remove the air intake cowling. Engines With oil Radiator Per motori Con Radiatore olio - Rimuovere la cuffia convogliatrice. Pour moteurs Avec Radiateur à Huile - Enlever la coiffe du convoyeur d’air. für motoren mit Ölkühler Para motores con Radiador - Die Kühlerhaube abnehmen.
Seite 66
NoTE: Only check after having insulated the positive battery cable to prevent accidental short-circuits and Check Alternator Belt the starter motor from being consequently energized. Tension NoTE: Eseguire il controllo solo dopo avere isolato il cavo positivo della batteria per prevenire corto circuiti Controllo Tensione Cinghia accidentali e di conseguenza l’eccitazione del motorino di avviamento.
Seite 67
- Loosen the two alternator fixing bolts. - Allentare i due bulloni fissaggio alternatore. - Desserrer les deux boulons fixation alternateur. - Die zwei Befestigungsschrauben am Drehstromgenerator lösen. - Aflojar los dos bulones fijación alternador. - Afrouxar os dois parafusos com porca fixagem alternador. - Force the alternator outward and temporarily tighten the fastening - Recheck that belt tension is within the required parameters.
Every 250 Hours Change oil oIL RECommENDATIoNS - oLIo PRESCRITTo - HUILE INDIQUÈE - ogni 250 ore Sostituzione olio motore VoRGESCHRIEBENE SCHmIERÖLE - ACEITE REComENDADo - ÓLEo REComENDADo Toutes les 250 Remplacement Huile moteur Heures Öldaten-Wechsel Alle 250 Stunden Specifications Sostitución Aceite del motor Cada 250 Horas mULTIGRADE...
Seite 70
- For oil capacity see page 38. - Remove drain plug and drain oil into an approved container. - Per la capacità olio vedi pag. - Togliere il tappo e scaricare l’olio in un contenitore adatto. - Enlevez le bouchon et vidangez l’huile dans un récipient approprié. - Pour contenance huile voir page 38.
Seite 71
óleo. NoTE: Use only genuine Kohler repair parts. NoTE: Utilizzare esclusivamente ricambi Kohler. NoTE: Utiliser uniquement des pièces de rechange Kohler d’origine. BEmERKUNG: Nur Original-Ersatzteile von Kohler verwenden. NoTA: Use únicamente piezas de repuesto originales Kohler.
Seite 72
NoTE: Respect the environment; dispose of used oil filter in - Reinstall the new oil filter and hand tighten. accordance with local ordinances. - Rimontare un filtro olio nuovo e serrarlo esclusivamente a mano. NoTE: Quando si sostituisce il filtro olio, tenerlo separato da altri rifiuti.
NoTE: Utilizzare esclusivamente ricambi Kohler. altri rifiuti. NoTE: Lors du remplacement du filtre à combustible, le tenir séparé NoTE: Utiliser uniquement des pièces de rechange Kohler d’origine. des autres déchets BEmERKUNG: Wenn man den Kraftstoffilter ersetzt, ist er getrennt BEmERKUNG: Nur Original-Ersatzteile von Kohler verwenden.
Seite 74
- In caso di scarso utilizzo: altri rifiuti. ogni anno. NoTE: Lors du remplacement du filtre à combustible, le tenir séparé NoTE: Utiliser uniquement des pièces de rechange Kohler d’origine. - En cas d’emploi limitè: des autres déchets chaque 1 ans.
NoTE: Use only genuine Kohler repair parts. NoTE: Utilizzare solo ricambi originali Kohler. NoTE: Utiliser seulement des pièces de rechange d’origine Kohler. BEmERKUNG: Es sind nur original Kohler - Teile zu verwenden. NoTA: Utilizar sólo recambios originales Kohler. NoTA: Utilizar Só péças de origem Kohler.
Seite 76
- Loosen the two alternator fixing bolts. - Allentare i due bulloni fissaggio alternatore. - Desserrer les deux boulons fixation alternateur. - Die zwei Befestigungsschrauben am Drehstromgenerator lösen. - Aflojar los dos bulones fijación alternador. - Afrouxar os dois parafusos com porca fixagem alternador. - Force the alternator outward and temporarily tighten the fastening bolts.
Seite 77
- Using a torque wrench tighten the fastening bolts to a torque of 30 N·m (8 x 1.25) and 50 N·m (10 x 1.50). - Con l’ausilio di una chiave dinamometrica serrare i bulloni di fissaggio ad una coppia di 30 N·m (8x1,25) e 50 N·m (10x1,50). - Serrer les boulons de fixation à...
Seite 78
The following procedures should be performed by authorized Kohler Service Dealers only. Per le seguenti operazioni rivolgersi alle Stazioni di Servizio autorizzate Kohler. Pour les opérations suivantes veuillez vous adresser aux stations de service autorisées Kohler. folgende Wartungsarbeiten sollen von fachwerkstätten durchgeführt werden.
Every 250 Hours Rocker Arm Valve Clearance NoTE: The adjustment must be made when the engine is cold (intake/exhaust 0.20 mm). ogni 250 ore Adjustment Toutes les 250 NoTE: É necessario effettuare la regolazione a motore freddo (aspirazione scarico 0.20 mm). Registro Gioco Valvole- Heures Bilancieri...
After 2500 Hours Partial overhaul Dopo 2500 ore Après 2500 Heures Revisione Parziale Nach 2500 Stunden Después de 2500 Horas Revision Partielle Depois 2500 Horas 2500 Hours Teilüberholung Revision Parcial h 2500 Revisäo Parcial - Partial overhaul: Valve and Seat Lapping - Pump-Injector Checking - Injection Timing - Crankshaft and Camshaft Endplay - Alternator Check - Radiator oil cleaning (in the versions where it is present) - Starting Motor Check - Fuel Hose Replacement - Revisione Parziale: Smerigliatura Valvole e Sedi - Revisione Iniettori-Pompa - Controllo Anticipo Iniezione - Controllo Gioco Assiale di Albero Motore e Albero a Camme - Controllo Alternatore - Controllo Motorino d’Avviamento - Sostituzione Tubi Carburante...
After 5000 Hours Complete overhaul Dopo 5000 ore Après 5000 Heures Revisione Generale Nach 5000 Stunden Después de 5000 Horas Revision Générale Depois 5000 Horas Generalüberholung 5000 Hours Revision General h 5000 Revisão General In addition to all items in partial overhaul, complete overhaul includes: Replace Pistons and Rebore Cylinders - Resurface or Replace Valves, Valve Seats, Valve guides, crankshaft, main bearing, and connecting rod bearing, if deemed necessary.
Seite 82
SToRAGE ImmAGAZZINAGGIo - Conservazione SToCKAGE - Conservation KoNSERVIERUNG - Erhaltung ALmACENAJE - Almacemaje ARmAZENAGEm - Armazenagem NoTE: When engines are not in service for more than 6 months, they must be protected by performing the operations described in the following pages. NoTE: Quando i motori rimangono inutilizzati per oltre 6 mesi, devono essere protetti, attuando le operazioni descritte nelle pagine seguenti.
Seite 83
ENGINE SToRAGE - If the engine is not to be used for extensive periods, check the storage area conditions PREPARING THE ENGINE foR oPERATIoN AfTER PRoTECTIVE TREATmENT and the type of packaging to make sure they are suitable for correct storage. After the storage period and before starting up the engine and preparing it for operation, If necessary, cover the engine with a proper protective sheet.
Seite 84
SToCCAGGIo moToRE mESSA IN SERVIZIo moToRE DoPo IL TRATTAmENTo PRoTETTIVo - In caso di inattività del motore, verificare le condizioni dell’ambiente, il tipo di imballaggio e controllare che tali condizioni ne assicurino un corretto mantenimento. Al termine del periodo di stoccaggio, prima di avviare il motore e metterlo in servizio, è Se necessario coprire il motore con un’adeguata copertura protettiva.
SToCKAGE DU moTEUR mISE EN SERVICE moTEUR APRÈS LE TRAITEmENT DE PRoTECTIoN - En cas d’inactivité du moteur, vérifier les conditions de l’environnement, le type d’emballage et contrôler que ces conditions en garantissent un maintien correct. Au terme de la période de stockage, avant de démarrer le moteur et de le mettre en Le cas échéant, couvrir le moteur avec une toile de protection adéquate.
LAGERUNG DES moToRS INBETRIEBNAHmE DES moToRS NACH DER SCHUTZBEHANDLUNG - Im Fall einer längeren Nichtbenutzung des Motors die Umgebungsbedingungen und das Verpackungsmaterial prüfen und sicherstellen, dass diese Bedingungen eine korrekte Aufbewahrung gewährleisten. Vor dem Start und der Inbetriebnahme des Motors am Ende einer längeren Nichtbenutzung müssen einige Arbeiten durchgeführt werden, um die maximale Effizienz des Motors zu Gegebenenfalls den Motor mit einer geeigneten Schutzabdeckung abdecken.
ALmACENAJE DEL moToR - En caso de inactividad del motor, comprobar las condiciones ambientales y el tipo de PUESTA EN SERVICIo DEL moToR DESPUÉS DEL TRATAmIENTo DE PRoTECCIÓN embalaje. Dichas condiciones deben asegurar el mantenimiento correcto del motor. Una vez finalizado el período de almacenaje, antes de poner en marcha el motor y de De ser necesario, cubrir el motor con una funda de protección adecuada.
ARmAZENAGEm Do moToR PÔR A fUNCIoNAR o moToR APÓS o TRATAmENTo PRoTECToR - No caso de inactividade do motor, verifique as condições do ambiente, o tipo de embalagem e certifique-se de que estas condições asseguram uma correcta manutenção do próprio motor. No final do período de armazenagem, antes de ligar o motor e pôr a funcioná-lo, será...
TROUBLESHOOTING TABELLE PROBABILI ANOMALIE IN FUNZIONE DEI SINTOMI TABLEAU ANOMALIES PROBABLES EN FONCTION DES SYMPTÔMES TABELLE MIT MÖGLICHEN STÖRUNGEN AUFGRUND BESTIMMTER SYMPTOME TABLA DE POSIBLES ANOMALíAS EN FUNCIÓN DE LOS SíNTOMAS TABELA DAS PROVáVEIS ANOMALIAS CONFORME OS SINTOMAS...
Seite 90
THE ENGINE mUST BE SToPPED ImmEDIATELy WHEN: QUANDo IL moToRE DEVE ESSERE ImmEDIATAmENTE ARRESTATo: LoRSQU’IL fAUT ARRÊTER LE moTEUR ToUT DE SUITE: DER moToR mUSS SofoRT ABGESTELLT WERDEN, WENN: EL moToR SE DEBE PARAR INmEDIATAmENTE CUANDo: QUANDo É PRECISo PARAR ImEDIATAmENTE o moToR: 1) - The engine RPMs suddenly increase and decrease - I giri del motore aumentano e diminuiscono improvvisamente - Les tours du moteur augmentent et diminuent tout à...
PRoBLEm - INCoNVENIENTI PoSSIBLE fAULT - CAUSA PRoBABILE - CAUSE PRoBABLE INCoNVENIENTS - BETRIEBSSToERUNGEN mÖGLICHE URSACHE - CAUSA PRoBABLE - CAUSA PRoVÁVEL ANomALIAS - INCoNVENIENTES - Engine does not start - Poorly Sealed Intake Valve - Cattiva Tenuta Valvole - Soupape Peu Étanche - Schlechte Ventildichtigkeit - Mala estanqueidad de la Válvula - Má...
Seite 92
PRoBLEm - INCoNVENIENTI PoSSIBLE fAULT - CAUSA PRoBABILE - CAUSE PRoBABLE INCoNVENIENTS - BETRIEBSSToERUNGEN mÖGLICHE URSACHE - CAUSA PRoBABLE - CAUSA PRoVÁVEL ANomALIAS - INCoNVENIENTES - The Engine Does Not Start - No Fuel - Mancanza di Combustibile - Manque de Combustible - Kraftstoff Fehlt - Falta de combustible - Falta de Combustível - Il motore Non Si Avvia - Le moteur ne Démarre Pas - Worn Cylinder - Cilindro Usurato - Cylindre Usagé...
Seite 93
PRoBLEm - INCoNVENIENTI PoSSIBLE fAULT - CAUSA PRoBABILE - CAUSE PRoBABLE INCoNVENIENTS - BETRIEBSSToERUNGEN mÖGLICHE URSACHE - CAUSA PRoBABLE - CAUSA PRoVÁVEL ANomALIAS - INCoNVENIENTES - Starts and Stops - No Fuel - Mancanza di Combustibile - Manque de Combustible - Kraftstoff fehlt - Falta de combustible - Falta de combustível - Si Avvia e Si ferma - Demarre et S’Arret - Blocked Air Filter - Filtro Sria Intasato - Filtre à...
Seite 94
PRoBLEm - INCoNVENIENTI PoSSIBLE fAULT - CAUSA PRoBABILE - CAUSE PRoBABLE INCoNVENIENTS - BETRIEBSSToERUNGEN mÖGLICHE URSACHE - CAUSA PRoBABLE - CAUSA PRoVÁVEL ANomALIAS - INCoNVENIENTES - Stiff Injection Pump Control Rod - Asta Comando Pompe Iniezione Indurita - Tige de Commande des Pompes à Injection Durcie - - Poor Acceleration Einspritzpumpe-Stänge Schwergängig - Eje de Mando de las Bombas de Inyección Endurecido - Haste de Comando Bombas de Injecção - Non Accelera...
Seite 95
PRoBLEm - INCoNVENIENTI PoSSIBLE fAULT - CAUSA PRoBABILE - CAUSE PRoBABLE INCoNVENIENTS - BETRIEBSSToERUNGEN mÖGLICHE URSACHE - CAUSA PRoBABLE - CAUSA PRoVÁVEL ANomALIAS - INCoNVENIENTES - Black Smoke - Blocked Air Filter - Filtro Aria Intasato - Filtre à Air Encrassé - Luftfilter verstopf - Filtro Sire Obstruido - Filtro ar Intubido - fumo Nero - Engine Overloaded - Sovraccarico - Surchagé...
Seite 96
PRoBLEm - INCoNVENIENTI PoSSIBLE fAULT - CAUSA PRoBABILE - CAUSE PRoBABLE INCoNVENIENTS - BETRIEBSSToERUNGEN mÖGLICHE URSACHE - CAUSA PRoBABLE - CAUSA PRoVÁVEL ANomALIAS - INCoNVENIENTES - Low oil Pressure - Worn Main Con. Rods Bearings - Bronzine Banco-Biella Usurate - Coussinets Pallers ou Bielle Usagés - Haupt-Oder Schubstangenlager Abgenutzt - Cojinete Bancada-Biela, Desgastados - Chumaceira Banco-Biela Fesgstada - Pressione olio Bassa - Basse Pression d’Huile...
Seite 97
PRoBLEm - INCoNVENIENTI PoSSIBLE fAULT - CAUSA PRoBABILE - CAUSE PRoBABLE INCoNVENIENTS - BETRIEBSSToERUNGEN mÖGLICHE URSACHE - CAUSA PRoBABLE - CAUSA PRoVÁVEL ANomALIAS - INCoNVENIENTES - Poorly Sealed Intake Valve - Cattiva Tenuta Valvola - Soupape peu étanche - Schlechte Ventildichtigkeit - Mala Estanqueidad de la - overheated Engine Válvula - Má...
Seite 98
PRoBLEm - INCoNVENIENTI PoSSIBLE fAULT - CAUSA PRoBABILE - CAUSE PRoBABLE INCoNVENIENTS - BETRIEBSSToERUNGEN mÖGLICHE URSACHE - CAUSA PRoBABLE - CAUSA PRoVÁVEL ANomALIAS - INCoNVENIENTES - Incorrect Governor Linkage Setting - Falsche Messa a Punto Degli Apparati di Iniezione Errata (Anticipo Pareggiamento Portate) - Mise au - Poor Engine Performance point des dispositifs d’injection erronée (avance nivellement débits) - Einstellung der Einspritzvorrichtungen (Förderbeginn und Abgleich der - Rendimento Insufficente...
Seite 99
PRoBLEm - INCoNVENIENTI PoSSIBLE fAULT - CAUSA PRoBABILE - CAUSE PRoBABLE INCoNVENIENTS - BETRIEBSSToERUNGEN mÖGLICHE URSACHE - CAUSA PRoBABLE - CAUSA PRoVÁVEL ANomALIAS - INCoNVENIENTES - Excess oil Consumption - Non-Conforming Engine Oil - Olio Motore Non Conforme - Huile moteur pas conforme - Motoröl Entspricht Nicht den Vorschriften - Aceite Motor No Conforme - Óleo Motor Não Conforme - Consumo olio Eccessivo - Consommation Excessive d’Huile...
Seite 100
PRoBLEm - INCoNVENIENTI PoSSIBLE fAULT - CAUSA PRoBABILE - CAUSE PRoBABLE INCoNVENIENTS - BETRIEBSSToERUNGEN mÖGLICHE URSACHE - CAUSA PRoBABLE - CAUSA PRoVÁVEL ANomALIAS - INCoNVENIENTES - Incorrect Timing Adjustment - Fasatura Distribuzione Errata - Calage Distribution Erroné - Falsche Ventilsteuerzeiten - Calado de la - Excess Noise Distribución Incorrecto - Regulação da Fistribuição Errada - motore Rumoroso...
Electrical System 7) QSD Device Circuito Elettrico Dispositivo QSD Circuit Electrique Dispositif QSD Elektrische Anlage QSD Vorrichtung Circuito Electrico Dispositivo QSD Circuito Eléctrico Dispositivo QSD Voltage Regulator Assemby Diagram 8) Head Temperature Thermostat Schema montaggio Regolatore di Tensione Termostato Temperatura Testa Schéma de montage Pour Régulateur de Tension Thermostat Température de la Culasse montageschema des Spannungsreglers...
2) Assembly Diagram for Voltage Regulator - Schema montaggio Regolatore di Tensione - Schéma de montage Pour Régulateur de Tension - montageschema des Spannungsreglers - Esquema del montaje del Regulador de la Tensión - Esquema de montagem regulador de Tensão Place the voltage regulator in an open-air location, away from heat sources.
3) Starter motor Wiring Diagram - Schema Elettrico Cablaggio motore Standard - Schéma de Câblage moteur Standard - Schaltplan der motorverkabelung Standard - Esquema Eléctrico del Cableado del motor Standard - Esquema Eléctrico Electrificação motor Standard...
4) Complete Engine Wiring Diagram - Schema Elettrico Cablaggio motore Completo - Schéma de Câblage moteur Complet -Schaltplan der Kompletten Verkabelung des motors - Esquema Eléctrico del Cableado del motor Equipado - Esquema Eléctrico Completo de Cablagem do motor Elettrovavola 2nd Electric Check Valve Bulbo Pressione olio oil Pressure Switch...
7) QSD Device - Dispositivo QSD - Dispositif QSD - QSD Vorrichtung - Dispositivo QSD - Dispositivo QSD To the feeding Pump Intake Alla Aspirazione Pompa Alimentazione Á l’aspiration Pompe Alimentation Zur Saugeseite förderpumpe from the Pump Delivery A la Aspiraciòn Bomba Alimentaciòn To Injection Pump Dalla mandata Pompa Para a Aspiração da Bomba de Alimentação...
8) Head Temperature Thermostat - Termostato Temperatura testa - Thermostat Température de la Culasse - Thermostat Kopftemperatur Termostato Temperatura culata - Termóstato Para Temperatura da Cabeça - Head temperature thermostat to be assembled on a “A“ stud bolt. - Hex screw m 10 - Termostato rilevamento temperatura testa da montare su prigioniero “A“.
RECommENDED BATTERIES BATTERIE CoNSIGLIATE BATTERIES CoNSEILLÉES EmPfoHLENE BATTERIE BATERÍAS REComENDADAS BATERIAS REComENDADAS NoTE: Battery not included. Ground rubber-mounted engines. NoTE: Batteria non fornita. Se il motore ha supporti in gomma collegare a massa. NoTE: La batterie n’est pas livrée. Si le moteur a des supports en caoutchouc, connecter à la masse. BEmERKUNG: Lieferung der Batterie nicht inbegriffen.
• Failures caused by: (i) faulty repairs made by any party other than Kohler Co. or an authorized service facility designated by Kohler Co.; (ii) use of non-Kohler replacement service parts;...
Seite 112
Kohler Co. cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled maintenance. (b) As the off-road engine owner, you should however be aware that Kohler Co. may deny you warranty coverage if your off-road engine or a part has failed due to abuse, neglect, improper maintenance or unapproved modifications.
Seite 113
As the heavy-duty off-road engine owner, you should however be aware that Kohler may deny you warranty coverage if your heavy-duty off-road engine or a part has failed due to abuse,...
• Anomalie dovute a: (i) riparazioni erronee eseguite da parti terze diverse da Kohler Co. o da un centro di assistenza autorizzato indicato da Kohler Co.; (ii) utilizzo di parti di ricambio non Kohler;...
Seite 116
MY2014-2016. Nelle applicazioni regolamentate dall’EPA in California (“lo Stato”) e USA, i nuovi motori off-road per servizio gravoso devono essere progettati, fabbricati e possedere dotazioni tali da osservare le rigorose norme EPA in materia di anti smog vigenti nello Stato e negli Stati Uniti. Kohler Co. è tenuta a garantire il sistema di controllo delle emissioni presente nel motore per i periodi elencati di seguito, nella misura in cui non abbiano avuto luogo cattivo uso, incuria o manutenzione scorretta del motore stesso.
Seite 117
CoPERTURA Kohler Co. riparerà o sostituirà le parti di ricambio del sistema di controllo delle emissioni, i componenti e le unità che risultino difettosi in relazione ai materiali e alla manodopera senza costi aggiuntivi, provvedendo anche alla diagnosi dell’impianto di scarico del motore, alla manodopera, e alle parti di ricambio. La scelta e la responsabilità della decisione di riparare o sostituire un sistema per il controllo delle emissioni difettoso saranno a esclusiva discrezione di Kohler Co.
• Anomalies dues à : (i) erreurs de réparation effectuées par des tiers, autres que la société Kohler Co. ou un centre d’assistance autorisé indiqué par Kohler Co. ; (ii) emploi de pièces de rechange non d’origine (Kohler) ; ou bien (iii) un acte imputable à la volonté de Kohler Co. qui comprend, entre autres, vol, vandalisme, incendie, foudre, séisme, tempête, grêle, éruption volcanique, inondation ou tornade.
Seite 120
(b) Le propriétaire du moteur off-road doit tout de même garder à l’esprit que Kohler Co. a le droit de refuser la couverture sous garantie si le moteur off-road ou une de ses pièces de rechange a subi une panne suite à...
Seite 121
Le propriétaire du moteur off-road pour service lourd doit tout de même garder à l’esprit que Kohler Co. a le droit de refuser la couverture sous garantie si le moteur off-road ou une de ses pièces de rechange a subi une panne suite à...
Verarbeitungsmängeln ist. Dies gilt für die im Folgenden angeführte anwendbare Garantie, deren Laufzeit mit dem Kaufdatum beginnt, sofern der Motor entsprechend den Anweisungen und Handbüchern von Kohler Co. eingesetzt und gewartet wird. Sollte kein Stundenzähler als Originalkomponente vorgesehen sein, so werden die Betriebsstunden berechnet und dafür eine Betriebsdauer von 4 Stunden pro Tag an 5 Tagen pro Woche angenommen.
Seite 124
GARANTIEERKLÄRUNG GEmÄSS EmISSIoNSREGELSySTEm fÜR KALIfoRNIEN UND USA. GARANTIEBEDINGUNGEN UND -VERPfLICHTUNGEN Die kalifornische Behörde zum Schutz der Luft (California Air Resources Board - ARB), die US-Behörde zum Schutz der Umwelt (Environmental Protection Agency - EPA) und Kohler Co. möchten Ihnen hiermit die Garantie in Bezug auf das Emissionsregelsystem für den Motor MY2014-2016 darlegen. Bei den von der EPA in Kalifornien (“der Bundesstaat”) und in den USA geregelten Anwendungen müssen die neuen Hochleistungs-Offroad-Motoren nach den strengen, im Bundesstaat und in den Vereinigten Staaten gültigen EPA Antismog-Vorschriften...
Seite 125
DECKUNG Kohler Co. repariert oder ersetzt ohne zusätzliche Kosten jene Teile, Komponenten und Einheiten des Emissionsregelsystems, die sich als defekt in Bezug auf das Material und auf die Verarbeitung erweisen, einschließlich Diagnose des Auspuffsystems des Motors, Arbeitskraft und Ersatzteile. Die Wahl und die Verantwortung für die Entscheidung, ob ein defektes Emissionsregelsystem repariert oder ausgetauscht wird, liegt alleine bei Kohler Co.
• Anomalías debidas a: (i) reparaciones incorrectas realizadas por terceros ajenos a Kohler Co. o a un centro de asistencia autorizado indicado por Kohler Co.; (ii) uso de partes de recambio que no sean Kohler; o (iii) un acto que no se pueda atribuir a la voluntad de Kohler Co. que puede ser, aunque no solo éstos, robo, vandalismo, incendio, rayo, terremoto, tormenta, granizo, erupción volcánica, inundación o tornado.
Seite 128
(b) El propietario del motor off-road, debe tener presente de todas formas que Kohler Co. tiene el derecho de negar la cobertura bajo garantía si el motor off-road o una de sus partes de recambio han sufrido una avería tras un uso inadecuado, negligencia, mantenimiento incorrecto o modificaciones sin autorización.
Seite 129
El propietario del motor off-road para servicio pesado de todas formas debe tener en cuenta que Kohler Co. tiene el derecho de negar la cobertura bajo garantía si el motor off-road para servicio pesado o una de sus partes de recambio han sufrido una avería tras un uso inadecuado, negligencia, mantenimiento incorrecto o modificaciones sin autorización.
• Anomalias devidas a: (i) reparações incorretas efetuadas por terceiros, não pela empresa Kohler Co. ou por um centro autorizado por Kohler Co.; (ii) uso de peças sobressalentes não originais ou (iii) um ato não imputável à vontade de Kohler Co. que inclui, sem que sem a tal limitar-se, furto, vandalismo, incêndio, raios, terremoto, tempestade, granizo, erupção vulcânica, inundação ou tornado.
Seite 132
(b) O proprietário do motor de tipo todo-o-terreno (off-road) deve considerar que a empresa Kohler Co. tem o direito de recusar a cobertura da garantia se o motor de tipo todo-o-terreno (off-road) ou se uma peça sobressalente se avariar após uso indevido, negligência, manutenção incorreta ou modificações não autorizadas.
Seite 133
O proprietário do motor de tipo todo-o-terreno (off-road) por serviço gravoso deve considerar que a empresa Kohler Co. tem o direito de recusar a cobertura da garantia se o motor de tipo todo-o-terreno (off-road) para serviço gravoso ou se uma peça sobressalente se avariar após uso indevido, negligência, manutenção incorreta ou modificações não autorizadas. O...
For sales and service information go to KohlerEngines.com or call 1-800-544-2444 (U.S. and Canada). Per assistenza e ricambi rivolgersi a stazioni di servizio autorizzate Kohler. KohlerEngines.com o 1-800-544-2444 (gli Stati Uniti ed il Canada). Pour toute exigence de service après vente et pièces détachées, s’adresser aux Stations du service du réseau Kohler.
Seite 136
FOR SALES AND SERVICE INFORMATION IN U.S. AND CANADA, CALL 1-800-544-2444 FORM NO. ED0053028700 KohlerEngines.com ISSUED 12/08 ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044 REVISED DATE 10/02/2014...