Xylem FLOJET BevJet Compact BLC-Serie Handbuch Seite 2

BevJet Compact | Series BLCXXXX-XXXX
Equipment Required
Two (2) 2 1/2 Gallon (9.6L) Household Pails
One (1) Roll of Paper Towels
One (1) Small Container of Household Bleach
Clean In-Place Procedure
1. Using the ON/OFF switch on the back of the LF pump, turn
BevJet Compact System OFF by putting the switch in the OFF
position. [See figure # 1].
2. Fill a clean pail (A) with two (2) gallons of hot tap water 135°F
(57.2°C), adding one (1) ounce of household bleach. [See
figures # 2 & 3].
3. Remove the suction tube from the pure water bottle and
submerge the bottle cap end into pail (A) in the water/bleach
solution [See figures # 4 & 5], for ten minutes and then wash
underside of cap and suction tube exterior with a clean paper
towel. If using the optional Flojet faucet, disconnect the
tubing. Remove the faucet, immersing it in the water/bleach
solution for ten minutes. Wash the faucet exterior with clean
paper towel; install the faucet and reconnect the tubing. Place
suction wand into clean empty pail (B) and dispose of solution
in pail (A). [See figures # 6 & 7].
4. Refill the cleaned pail (A) with two (2) gallons of hot tap water
135°F (57.2°C) adding one (1) ounce of household bleach
and place suction wand(s) into pail with bottle cap up. [See
figures # 8 & 9].
5. Disconnect the discharge tube from the faucet or the refriger-
ator and place into the empty second pail (B). (Do not use pail
with clean water and water/bleach solution).
6. Turn dispensing system on, by placing ON/OFF switch in the
ON position (red light will come ON) [See figure # 10] and dis-
pense all of the water/bleach solution into pail (B) [See figure
# 11]. Place discharge tube into pail (A) and dispose of bleach,
and rinse pail (B). Replace discharge tube into pail (B).
7. Refill pail (A) with two (2) gallons of hot tap water 135°F
(57.2°C), adding one (1) ounce (29.57 mm) of household
bleach [See figures # 6, 8 & 9]. Dispense water/bleach as in
step #6.
8. Reinstall suction wand(s) into new bottle(s) of pure water
and reconnect discharge tube into refrigerator or faucet and
dispense 12 to 18 ounces (355 ml to 532 ml) of water, or until
bleach taste is removed [See figure # 13].
9. Cleaning should be performed at least six (6) times per year or
every 2 months. System should be cleaned and flushed with
fresh water if stagnant for more than 48 hours.
CAUTION: Do not place BevJet Compact
System into a dishwasher as it will cause
electrical failure of pump and controls.
2
135°F (57.2°C)
A
4
6
CLEAN
WATER
8
135°F (57.2°C)
A
10
ON
12
B
2
1
OFF
3
HOUSEHOLD
BLEACH
A
5
10 MIN
A
7
PAPER
TOWEL
9
HOUSEHOLD
BLEACH
A
11
A B
13