Lubrication; Accessories; Adjustable Legs; Baskets For Jumbo Buns - Hatco Toast King Installations- Und Bedienungsanleitungen

LUBRICATION

The motor bearing requires periodic lubrication
at recommended intervals.
CAUTION
Failure to lubricate the rear motor bearing as recommended
will reduce the operating life of the motor and possibly void
the warranty.
1. Disconnect toaster from the power supply.
2. Remove the screws securing the rear lower access panel,
and carefully lift panel up to expose motor compartment.
3. Lubricate the bearing by applying 10-12 drops of Mobil SHC
624 lubricant (Hatco part no. 05.01.018.00) to the bearing.
See 9 .
4. Re-install the rear access panel.
Motor Bearing Lubrication Schedule
24 hours operation . . . . . . . . . . . . . . . . . . . . . . . . . .Every 6 weeks
18 hour operation . . . . . . . . . . . . . . . . . . . . . . . . . .Every 8 weeks
12 hour operation . . . . . . . . . . . . . . . . . . . . . . . . .Every 12 weeks
Periodic operation . . . . . . . . . . . . . . . . . . . . . . . . .Every 6 months
10 CM (4") ADJUSTABLE LEGS
1. Carefully place unit on its side.
!
CAUTION
Do not lay unit on the side with the control panel or damage
to unit could occur.
2. Thread the 10 cm (4") adjustable legs into the existing leg holes
on the bottom of the unit. See 10A and 10B .
3. After all legs are secure, return the unit to the upright position.
4. If unit is not level, use a 16 mm (5/8") open-end wrench
to adjust the foot of each leg until unit is level.
!
WARNING
If service is required on this unit, contact your Authorized
Hatco Service Agent, or contact the Hatco Service Department
at 800-558-0607 or 414-671-6350; fax 800-690-2966
or International fax 414-671-3976.
!
WARNING
This product has no "user" serviceable parts. To avoid damage
to the unit or injury to personnel, use only Authorized Hatco
Service Agents and Genuine Hatco Parts when service
is required.
!
WARNING
Genuine Hatco Replacement Parts are specified to operate
safely in the environments in which they are used. Some
aftermarket or generic replacement parts do not have
the characteristics that will allow them to operate safely
in Hatco equipment. It is essential to use Hatco Replacement
Parts when repairing Hatco equipment. Failure to use Hatco
Replacement Parts may subject operators of the equipment
to hazardous electrical voltage, resulting in electrical
shock or burn.

BASKETS FOR JUMBO BUNS

(TK-100, TK-135B & TK-155B MODELS ONLY)
Baskets will accommodate jumbo buns up to 14 cm (5-1/2")
in diameter.

ELECTRICAL RECEPTACLES

Various electrical receptacles are available for different applications.
See the applicable Electrical Rating Chart for details.
10
MAINTENANCE

ACCESSORIES

Form No. TR/TKCEM-0902