Operating The Unit; Operation; Instruciton Of The Users - Convotherm OES 6.10 Installationshandbuch

10. Operation and Instruction
Observe the Checklist for putting into
operation and the Safety advice in the User
Manual and Installation Handbook.*
Damaged units must never be installed
and/or put into operation.

10.1 Operating the unit

Remove the film from the stainless
•
steel housing.
If the temperature is under +4°C, allow
•
the oven to warm up to room
temperature before operating.
After transporting the combi steamer at
•
an outside temperature under -5° C, the
safety thermostat can be tripped when
unit is put into operation. Reset the
safety thermostat.
Turn on the water tap or water taps (for
•
soft and/or warm water connection,
water tap (A) and (B)).
Turn the air ventilation system on and
•
open the gas tap (OGS&OGB).
Check the following:
•
– Suction panel assembled correctly
– Hanging shelf rack hanging
correctly
– Loading trolley is properly rolled in.
Switch unit on at power switch.
•
Set the date, time and language (→
•
User Manual, Chapter ‚Basic settings).
Select the Superheated Steam cooking
•
programme:
– Set to 150° C, 10 min. (→ User
Manual, Chapter ‚Cooking with the
Combi steamer).
Check the following:
•
– Is the oven light on?
– Does the burner light according to
regulations
(OGS & OGB)?
OGS: Burner for the oven heat
exchanger
OGB: Burner for the oven heat
exchanger and burner for the steam
generator.
* Advice to the Installer: A copy of the Checklist can also be found in the Service Handbook.
For the Combi steamer OES and OGS
•
set the manometer in the water supply
for the steam generator at
100 kPa(1bar) for sizes 6.10, 6.20,
10.10, 10.20, 12.20 and 180 kPa
(1.8 bar) for sizes 20.10, 20.20 flow
pressure. In addition operate the unit in
Steaming mode.
For the combi steamerOES and OGS
•
units, set the manometer in the water
supply for the steam generator at
200 kPa (2bar) flow pressure. Operate
the unit in the Steam mode.
For units with automatic cleaning
•
(CONVOClean system) allow a
cleaning cycle to run and check
adequate supply of CONVOClean and
CONVOCare.
Attention: A health danger exists by
consumption of cooked food, when
the connections for CONVOClean
and CONVOCare are switched or
other cleaning products are used.
10.2 Storing after use and
disposal
When taking the unit out of use,
•
disassemble or cut the electrical
connections and dismantle the door
locking system.
For an environmentally safe disposal of
•
the units contact the respective Enodis
dealer.
10.3 Instruction of the users
Inform the users of all function and safety
relevant points (refer to Checklist* →
Chapter 9.2, Installation Handbook and
Users Manual).
52
EN