Scheppach Air Case Original Bedienungsanleitung Seite 22

• Do not smoke during the spraying process and/or in
the work area. Risk of explosion! Paint vapours are
easily combustible.
• Never set up or operate the equipment in the vicinity
of a fire place, open lights or sparking machines.
• Do not store or eat food and drink in the work area.
Paint vapours are harmful to your health.
• The work area must exceed 30 m³ and suffi cient ven-
tilation must be ensured during spraying and drying.
• Do not spray against the wind. Always adhere to the
regulations of the local police authority when spray-
ing combustible or hazardous materials.
• Do not process media such as white spirit, butyl al-
cohol and methylene chloride with the PVC pressure
hose. These media will destroy the pressure hose.
• The work area must be separated from the compres-
sor so that it cannot come into direct contact with the
working medium.
Operating pressure vessels
• You must keep your pressure vessel in good working
order, operate the vessel correctly, monitor the vessel,
carry out necessary maintenance and repair work im-
mediately and meet the relevant safety precautions.
• The supervisory authority may enforce essential
control measures in individual cases.
• A pressure vessel is not allowed to be used if it has
faults or deficiencies that can endanger workers or
third parties.
• Check the pressure vessel for signs of rust and dam-
age each time before using. Do not use the com-
pressor with a damaged or rusty pressure vessel. If
you discover any damage, then please contact the
customer service workshop.
Safety instructions for accessories
• Check the air pressure with a suitable manom-
eter after filling.
• RISK OF FIRE, EXPLOSION AND DAMAGE TO
HEALTH! The device must be used in well-ventilat-
ed areas only.
• DANGER OF INJURY! Never exceed the maximum
allowable working air pressure of 8 bar. Use a pres-
sure reducer to set the working air pressure.
• RISK OF RECOIL FORCES! High working pressures
can give rise to recoil forces that under certain con-
ditions can result in danger from continuous loading.
• DANGER OF INJURY! IMPROPER USE! Never
point the device at people or animals.
• DANGER OF INJURY! Never use oxygen or other
combustible gas as the energy source.
22 | GB
• DANGER OF INJURY! First disconnect the hose
from the compressed air source and only then
disconnect the compressed air supply hose
from the device. This will ensure that the com-
pressed air supply hose does not wave around or
recoil in an uncontrolled manner.
• For your own safety, wear suitable personal pro-
tective equipment.
• Keep children and other people away while you
are operating the device. Distractions can cause
you to lose control of the device.
• Disconnect the device from the compressed air
source before carrying out any repairs or mainte-
nance of the device or moving it to another location.
• When removing the hose coupling, hold the hose
tightly in your hand to avoid injury caused by the
hose shooting backwards.
• Look out for damage on the device. Check the
device for damage before bringing it into use. Do not
use the device if you discover any defects.
• Do not kink the device's hose, otherwise you may
damage it.
• NOTE! Observe the safety advice provided by the
manufacturer of your inflatable article.
• Do not remove rating plates or labels - they are
safety-relevant parts of the device.
• If you are inexperienced in the use of this type of
device, you should seek out information or training
to learn how to handle it safely.
Do not lose these safety instructions
6. Technical data
Mains connection
Motor rating
Operating mode
Compressor speed
Pressure vessel capacity
Operating pressure
Theoretical intake capacity
Theoretical delivery rate
Protection type
Weight of the unit
*S3 15% = periodical intermediate duty with a duty
cycle of 15% (1.5 min based on a 10 minute period)
www.scheppach.com
220 - 240 V~ 50 Hz
max. 1100 W
S1
3750 min
-1
2 l
approx. 8 bar
approx. 180 l/min
approx. 95 l/min
IP20
8 kg