Possible Faults; Technical Data; Rlc - ATIKA RLC 40-10 Originalbetriebsanleitung

Before each fault elimination:
 switch off device
 wait for standstill of the beater
 remove the battery

After each fault clearance, put into operation and recheck all security installations.
Problem
Motor won't start
Unusual vibrations
Device starts but blocks under
slight load and cuts off auto-
matically.
Output per battery charge too
short
Type / Model
Year of construction
Suitable for battery type
Suitable for battery capacity
Speed n (with speed control)
0
Beater diameter
Beater chuck
Beater length
Volume of the material to be mixed
Weight (without battery)
Hand-arm-vibration on the handle a
Measuring uncerntainty K
Sound power level L
WA
Measuring uncerntainty K
WA
Measured sound pressure level L
Measuring uncerntainty K
PA
16
P o s
P o s
Possible cause
 Li-Ion battery run down
 Lithium-ion battery not inserted cor-
rectly
 Li-Ion battery too cold/ too warm
 Li-Ion battery, Motor or switch defect
 Beater defective.
 Chuck defective.
 Non-intended material to be mixed.
 Extension cable too long, or cross-
section too small.
 Socket too far away from main con-
nection, and cross-section of con-
nection lead too small.
 Rechargeable battery is low
 Battery service life exhausted
T e c
T e c
h
PA
s i b l e f a u l t s
s i b l e f a u l t s
Remedy
 Charge the Li- ion battery
 Check whether the lithium battery has engaged
audibly.
 Allow the lithium battery to warm up/cool down
 Have the battery, motor or switch checked / repaired
by a licensed electrician or customer service or re-
placed by original spare parts.
 Replace the beater.
 To correct the problem, refer to the manufacturer or
other approved service centre.
 Incorrect processing. Follow the processing instruc-
tions from the supplier.
 Extension cable at least 1,5 mm2 , maximum 25 m
long.
 Cross- section of at least 2,5 mm2 in longer cables.
 Charge the Li- ion battery (manual battery "Charging
the battery")
 Charging the rechargeable battery
h n i c a l d a t a
h n i c a l d a t a
2000 mAh oder 4000 mAh
RLC 40 – 10
See last page
Li-Ion 36 V
0 - 740 min
-1
120 mm
M14
approx. 570 mm
approx. 40 litres
approx. 4.8 kg
5.56 m/s²
1,5 m/s²
96 dB (A)
3.0 dB (A)
85 dB (A)
3.0 dB (A)
Technical modifications reserved!