Adjusting The Bowden Cable Of The Wheel Drive (15); Repair Work; Help In Case Of Malfunction - Solo AL-KO 4237 Li P Betriebsanleitung

Help in case of malfunction

8.4 Adjusting the Bowden cable of the
wheel drive (15)
The Bowden cable of the wheel drive lengthens
over time. If the wheel drive can no longer be
switched on with the motor running, the Bowden
cable has become too long and must be tight-
ened.
CAUTION!
Risk of injury
Sharp-edged and moving appliance
parts (e.g. cutting blade) as well as a
suddenly starting lawnmower can lead to
injuries.
■
Only adjust the Bowden cable when
the motor is switched off and the
mower mechanism has come to a
standstill.
1. Switch off the appliance: Turn the safety key
to 0 and remove it.
2. Turn the adjusting part (15/1) on the Bowden
cable (15/2) in the direction of the arrow, i.e.
anticlockwise until the Bowden cable is taut
between the gear engagement bar (15/3) and
holding point (15/4).
3. To check the Bowden cable setting: Switch
on the appliance, start the motor and try to
switch on the wheel drive.
4. If the wheel drive does not switch on: Repeat
the previous steps.
If the adjustment of the Bowden cable is not suc-
cessful: Contact an AL-KO service centre.
Malfunction
Motor does not run.
456877_c
Cause
Safety key is not inserted
and turned to I.
Rechargeable battery miss-
ing or not seated correctly.
Rechargeable battery is flat.
Mower mechanism is
blocked.
Control cable or switch is de-
fective.
8.5

Repair work

Repair work may only be carried out by AL-KO
service centres or authorised specialist work-
shops.
In the following cases, visit the AL-KO service
centre:
■
Motor no longer starts.
■
Appliance has moved onto an obstruction.
■
Cutting blade and/or motor shaft are bent.
■
Appliance vibrates and does not run smooth-
ly.
■
Rechargeable battery has discharged or is
damaged.
9 HELP IN CASE OF MALFUNCTION
CAUTION!
Risk of injury
Sharp-edged and moving appliance
parts can lead to injury.
■
Always wear protective gloves
during maintenance, care and clean-
ing work.
■
Switch the appliance off. Remove
the safety key, and remove the re-
chargeable batteries.
NOTE
For malfunctions that are not listed in
this table or that you cannot resolve
yourself, please contact our customer
service.
Remedy
Insert the safety key and turn to I.
Insert the rechargeable battery correct-
ly.
Charge the rechargeable battery.
■
Clean the mower mechanism.
■
Start the lawnmower on short grass.
Do not operate the tool! Contact an AL-
KO service centre.
39