Changing The Battery; Maintenance - Vermeiren Forest Narrow Gebrauchsanweisung

•
Steering wheels (front wheels)
•
Driving wheels (rear wheels)
L L L L
WARNING:
Risk of injury - Make sure all screws are firmly secured by hand
before driving with your electric wheelchair. Screw adhesive (ex. Loctite) should
be applied to the screws on the flange. Screw adhesive will only work if the thread
is free of grease and particles.
3.6

Changing the battery

L L L L
CAUTION:
Risk of burns - Do not come in contact with the acid from the batteries.
See for a good ventilation of the battery compartment.
The battery shall be changed by trained personel. To change the batteries, send your electric
wheelchair to the specialist dealer.
4

Maintenance

For the maintenance manual of the electric wheelchairs refer to the Vermeiren website:
www.vermeiren.be.
DISMANTLING
A. Loosen the screw on the steering wheel axle and
remove it from the steering wheel fork.
B. Let the air out of the steering wheel by lightly pressing
the pressure pin on the valve.
C. Loosen the 5 screws that hold the split rim together.
Now separate the rim sides.
ASSEMBLY
Insert the partly-filled inner tube into the tyre.
C. Connect the two sides of the rim through the tyres and
use the 5 connecting screws to screw the rim
together.
B. Make sure that the valve juts out of the valve opening
in the rim.
A. Put the wheel back into the front wheel fork and inflate
the wheel.
DISMANTLING
A. Unscrew and remove the axle nut on the drive
wheel and the 4 screws that attach the wheel
to the flange.
B. Let the air out of the wheel by lightly pressing
the pressure pin on the valve.
C. Unscrew the 5 screws on the inside of the rim.
Separate the rim sides.
ASSEMBLY
Insert the partly-filled inner tube into the tyre.
C. Connect the two sides of the rim through the
tyres and screw them back again.
B. Put the valve through the hole for it in the rim.
A. Put the wheel back on the flange and secure
these connection
Afterwards secure the wheel by hand-
tightening the axle nut. Inflate the wheel to the
recommended tyre pressure.
Page 32
Forest, Forest Narrow
2012-12
with the 4 screws.