Symbols Used; Intended Use; Safety Instructions - Truma BG 10 Einbauanweisung

Boiler gas / Boiler gas/electric - Hot water generator
Table of contents
Symbols used ................................................................... 10
Intended use ..................................................................... 10
Safety instructions .......................................................... 10
Operation while driving ....................................................... 11
Regulations ......................................................................... 11
Installation instructions
Selecting a location ......................................................... 12
Installing the boiler .......................................................... 12
Water connection ............................................................ 13
Flexible hose installation ..................................................... 13
Rigid duct installation using the John Guest System ......... 13
Installing the drain valve ..................................................... 14
Water line routing ............................................................... 14
Gas connection ................................................................. 15
Fitting the control panels ............................................... 15
12 V electrical connection ......................................... 15
230 V electrical connection ....................................... 16
230 V control panel connection ...................................... 16
Function check ................................................................. 16
Warnings ........................................................................... 16
Technical data ................................................................... 17
Trade name (version)
Boiler gas (BG 10)
Boiler gas/electric (BGE 10)

Symbols used

The appliance must only be installed and repaired by an
expert.
Symbol indicates possible hazards.
Note containing information and tips.
The operating instructions for this Truma appliance are
an important part of these installation instructions and
must be followed. The operating instructions are sup-
plied with the appliance as a separate document and
can also be downloaded at www.truma.com under the
heading Products.
Read the installation instructions, the operating instruc-
tions and the safety instructions carefully before com-
mencing the work, and then comply with them.

Intended use

Proper use
The appliance is approved solely for installation and operation
in caravans and construction trailers of vehicle class O, mo-
tor homes of vehicle class M1 and mobile homes if the gas
system is installed in accordance with EN 1949. The national
legislation and regulations for operating and testing gas in-
stallations (e.g. DVGW Work Sheet G 607 in Germany) must
be observed.
The appliance may be used only to heat drinking water.
If the appliance is operated while the vehicle is in motion,
facilities must be installed to prevent uncontrolled emission
of liquefied gas in the event of an accident (according to
UN-ECE regulation 122).
10
If the appliance is being used for commercial purposes, the
operator must ensure that special statutory and insurance
regulations of the respective destination country are observed
(e.g. DGUV regulations in Germany).
Improper use
All other uses not listed under proper use are improper and
therefore prohibited. This applies for example to installation
and operation in:
- Motor buses of vehicle classes M2 and M3,
- Commercial vehicles of vehicle class N,
- Boats and other water vessels,
- Hunting/forestry huts, weekend homes or awnings.
- Installation in trailers and vehicles used to transport hazard-
ous goods is prohibited
- Heating of liquids other than drinking water (e.g. cleaning,
descaling, disinfectant and preserving agents) is prohibited.
- Defective appliances must not be used.
- Appliances installed and utilised in contravention of the op-
erating and installation instructions must not be used.

Safety instructions

Read the safety instructions and operat-
ing instructions carefully before starting
the appliance.
To ensure safe and proper use, carefully
read and observe the installation and
operating instructions and other documents
supplied with the product, and keep them in a
safe place for future reference. The respective
valid laws, directives and standards must be
observed.
Not following the rules in the operating and
installation instructions can result in serious
material damage and serious risk to the health
or life of persons. The appliance's operator or
user is solely responsible for such damage.