Circuit Diagram - NEO TOOLS 90-083 Anleitung

GAS HEATER
Model: 90-083; 90-084; 90-085
NOTE: BEFORE THE EQUIPMENT IS USED FOR
THE FIRST TIME, READ THIS INSTRUCTION
MANUAL AND KEEP IT FOR FUTURE
REFERENCE. PEOPLE WHO HAVE NOT READ
THIS INSTRUCTION SHOULD NOT ASSEMBLE, LIGHT,
ADJUST OR OPERATE THE UNIT
DETAILED SAFETY REGULATIONS
ONLY PERSONS WHO CAN UNDERSTAND AND FOLLOW
THE INSTRUCTIONS SHOULD USE OR SERVICE THIS
HEATER.
NOT FOR HOME OR RECREATIONAL VEHICLE USE.
● Use only in a well ventilated area and away from combustible
materials
● NOT to be used for the heating of habitable areas of domestic
premises, for use in Public buildings, refer to national
regulations.
● After use turn off the gas supply at the cylinder valve.
● Ensure that the fan is operating correctly before lighting the
burners.
● This appliance can be used by children aged from 8 years and
above and persons with reduced physical, sensory or mental
capabilities or lack of experience and knowledge if they have
been given supervision or instruction concerning use of the
appliance in a safe way and understand the hazards involved.
Children shall not play with the appliance. Cleaning and user
maintenance shall not be made by children without supervision.
●
WARNING: In order to avoid overheating, do not
cover the heater.
● Children of less than 3 years should be kept away unless
continuously supervised.
● Children aged from 3 years and less than 8 years shall only
switch on/off the appliance provided that it has been placed or
installed in its intended normal operating position and they have
been given supervision or instruction concerning use of the
appliance in a safe way and understand the hazards
involved.Children aged from 3 years and less than 8 years shall
not plug in, regulate and clean the appliance or perform user
maintenance.
●CAUTION-some parts of this product can become very hot and
cause burns. Particular attention has to be given where children
and vulnerable people are present.
HEATER SPECIFICATIONS
Model 90-083
Rating 51,180BTU
(15kw)
Fuel 1.09kg/h
Consumption
Fuel Orifice 0.90mm
Port Size
Air flow temp 420℃
Type of Gas
Gas Supply 700mBar
Pressure
Electricity
Input
Ignition
Primary Thermal Probe Operated Gas Valve
Flame Control
Overtheating 95℃
Protection
Insulation
90-084 90-085
102,360BTU 170.600BTU
(30kw) (50kw)
2.18kg/h 3.63kg/h
1.28mm 1.4mm
430℃ 360℃
For use with LPG only
700mBar 1500mBar
220-240V~ 50Hz
piezo
110℃ 110℃
Class I

CIRCUIT DIAGRAM

Safety distances
WARNING! To ensure safe work, always keep a safe
distance:
1.GENERAL INSTRUCTION
1.1.The heaters mentioned in this manual must only be used
outdoors or in well ventilated surroundings.
1.2.For every KW it is necessary to have permanent ventilation
of 25cm³, equally distributed between the floor and high level,
with a minimum outlet of 250cm³.
1.3.Gas cylinders must be used and kept in accordance with
current regulations.
1.4.Never direct the hot air flow towards the cylinder.
1.5.Use only the supplied pressure regulator.
1.6.Never use the heater without its cover.
1.7.Do not exceed 100W/m³ of free room. The minimum volume
of the room must be larger than 100m³.
1.8.Do not obstruct the inlet or outlet sections of the heater.
1.9.If the heater has to work for a long period at its maximum
capacity, it's possible that ice will form on the cylinder. This is
due to excessive vapour withdrawal. Not for this reason, or for
any other, should the cylinder be heated. To avoid this effect, or
at least to reduce it, use a large cylinder or two cylinders linked
together (Figure1)
Figure 1
1.10.Do not use the heater in cellars, basements or in any room
below the ground level.
1.11.In case of malfunction, please contact the technical
assistance service.
1.12.After use, turn the gas cylinder tap off.
1.13.The gas bottle must always be replaced following safety
rules away from any possible source of ignition.
1.14.The gas hose must not be twisted or bent.
1.15.The heater must be placed where there is no risk of fire, the
hot air outlet must be at least 3m from any flammable wall or
ceiling and must never be directed towards the gas bottle.
1.16.Only use original gas hose and spare parts.
1.17.Heaters described in this leaflet are not intended for
domestic use.