Checking And Cleaning The Device - HEYLO KS 85 T Betriebsanleitung

18.1

Checking and cleaning the device

The cleaning intervals for the device depend on the
actual operating conditions. Check and clean the
device regularly.
NOTICE
Suitable cleaning products
Suitable cleaning products for your device are
available from your dealer or directly from HEYLO.
– Cleaning can be performed with compressed air,
a vacuum cleaner or by wiping with a damp
cloth. CAUTION! Never use a hose or high
pressure cleaner.
– The electrical system must be checked regularly
for signs of damage.
– To ensure trouble-free operation, regularly check
and clean the filters of the device.
Switching device off
To clean and check the device, switch it off as fol-
lows:
a) Switch off the device at the device switch and
let the cooling time elapse (fan stops).
b) Disconnect the power plug.
Cleaning device housing
a) Clean the housing with a damp, lint-free cloth
and a mild detergent. The original gloss can be
restored with polish.
Cleaning fuel tank
Clean the fuel tank at least once a year, or as re-
quired.
Fig. 39: Emptying fuel tank
1 Fuel tank
a) Place a container that can hold the entire tank
volume under the fuel tank cap.
b) Open the fuel tank cap.
c) Rinse the tank with clean fuel.
d) Dispose of fuel according to the relevant statu-
tory regulations.
EN
1
2
2 Fuel tank cap
Cleaning filter
Clean the filter at least once a year, or as required.
Always replaced damaged filters.
Cleaning tank inlet filter
Fig. 40: Cleaning inlet filter
1 Screw cap of fuel
tank
a) Open the fuel tank cap.
b) Pull the inlet filter from the tank.
c) Clean the inlet filter with clean fuel. Do not
damage the filter.
d) Mount the inlet filter in the tank.
e) Mount the screw cap.
Cleaning oil filter
The oil filter must be checked regularly and replaced
if necessary. Proceed as follows:
✓ Keep a cloth to collect any escaping fuel ready.
a) Turn the filter cup counter-clockwise and pull it
down.
Collect the escaping fuel, remove the gaskets
and keep them safely.
b) Turn the filter cartridge counter-clockwise and
pull it from the filter cup.
Collect the escaping fuel.
c) Clean the filter cup and filter cartridge with clean
fuel. Do not damage the filter.
If the filter cartridge is damaged, replace it.
d) Install the filter cartridge in the filter cup.
e) Mount the filter cup on the filter lid. Ensure that
all gaskets are correctly installed.
f) Dispose of the replaced filter cartridge and the
fuel according to the relevant statutory regula-
tions.
Cleaning fuel pump filter
The fuel pump filter must be cleaned at least once a
year, or as required. Contact the HEYLO service
department.
Replacing oil nozzle
The oil nozzle must be replaced at least once a
year. Contact the HEYLO service department.
Oil heater KS 85 T
1
2
2 Inlet filter
39 / 44