Symbols On The Machine; Safety Instructions - Kärcher IVC 60/12-1 Ec H Z22 Bedienungsanleitung

Symbols on the machine

Do not suck in any ignition sources!
Suitable for suction of combustible
dusts of the dust explosion classes in
Zone 22.
Flat fold filter
Order No.
Dust disposal bag
Order No.
Safety filter bag
Order No.
9.989-606.0

Safety instructions

DANGER
– When the outgoing air is carried back into the room,
a sufficient ventilation rate L in the room must be
ensured. To comply with the required limit values
the carried back volume flow must be 50% of the
fresh air volume flow (room volume V
rate L ) at maximum. Without a specific ventilation
W
system the following applies: L
– Only persons trained in the use of the machine and
the handling of substances for which the machine
is to be used including training in the safe disposal
of the sucked-in material may use the machine.
14
6.904-364.0
9.989-606.0
6.904-420.0
When using the dust bag,
the lower suction hose
port must be tightly
closed.
When using the safety fil-
ter bag, the upper suction
nozzle must be tightly
sealed.
Two suction hoses may
not be connected to the
vacuum cleaner at the
same time. One suction
nozzle must be tightly
sealed with the connec-
tion bushing.
x ventilation
R
=1h .
–1
W
– This appliance contains harmful dust. Evacuation
and maintenance work, including the disposal of
the dust collection containers, may only be per-
formed by specialists who wear the appropriate
protective equipment.
– Do not use the appliance without the complete fil-
tering system.
– Please follow the safety regulations applicable to
the materials that are to be treated.
– The accessories approved by the manufacturer are
electrically conductive. Do not use any other acces-
sories!
– Vacuum only using all the filter elements; other-
wise, the suction motor can get damaged and this
can be hazardous to health on account of in-
creased release of fine dust particles!
– Please observe the safety regulations applicable to
the materials to be vacuumed up. During proper/
improper operation parts of the appliance can
reach temperatures of up to 95 °C.
– You are not allowed to use an extension cable.
In case of emergency (e.g. in case of a short or other
electrical errors), switch off the appliance and pull the
mains plug.
 If necessary, peel the adhesive label in the rele-
vant national language off the accompanying ad-
hesive label sheet and paste it over the German
text on the appliance.
Caution: Depending on the application, the suction
hose can be attached to 2 different suction nozzles:
1 Suction nozzle on the intermediate ring:
a) Dry vacuum cleaning with disposal bag: Coarse
dusts, large quantities of vacuumed material over a
short period of time
b) Wet vacuuming
2 Suction nozzle on the dirt container:
a) Dry vacuum cleaning with safety filter bag: As-
bestos, fine particles, constantly large quantities of
vacuumed material
b) Wet vacuuming
WARNING
Do not vacuum without the filter elements; otherwise,
the suction motor can get damaged and this can be haz-
ardous to health on account of increased release of fine
dust particles.
Note: Additional regulations can be applicable to dusts
with an ignition capacity below 1mJ.
 Bring the appliance to working position - secure it,
if required, with parking brakes.
 Attach the suction hose (not included in the scope
of delivery) to the selected suction nozzle. Tightly
seal the other suction nozzle with the connection
bushing, see operation.
– 2
EN
In Emergency
Start up