Plastic Parts; Inspection; Disinfection - Vermeiren Elios Gebrauchsanweisung

4.3.2 Plastic parts

Clean plastic parts of your chair with commercial plastic cleaners. Only use a soft brush or
soft sponge. Please comply with special product information.
4.3.3 Coating
The high quality of the surface layer guarantees optimal protection against corrosion. If the
outer coat is damaged by scratching or in some other way, get your specialist dealer to
repair the affected surface.
When cleaning, only use warm water, normal household detergents, soft brushes and cloths.
Ensure that no moisture gets into the tubes.
Initially the zinc parts only require rubbing with a dry cloth. Stubborn dirt can best be
removed by using a suitable commercial zinc polish.
4.4

Inspection

In principle we recommend one inspection every year, and a minimum of one before usage
is resumed. All of the following checks must be performed and documented by authorized
persons:
Check the frame parts for plastic deformation, cracks and impaired functioning.
•
Visually check for damage to the paintwork (danger of corrosion).
•
Check the operation of the wheels (free running, level rolling, axle play).
•
Check the solidity and tightness of all screws, nuts and bolts.
•
Verify the amount of grease on the metal joints of movable parts.
•
Visually check all plastic parts for cracks and brittle spots.
•
Check the function of the leg rest (locking, loading, deformation, wear and tear due to
•
loading).
Check the operation of other detachable parts (example: safety belt).
•
Check the inclination system.
•
Completeness of the delivery condition, instruction manual available?
•
The service must only be signed off in the maintenance plan if a minimum of all the above-
mentioned aspects have been checked.
4.5

Disinfection

WARNING:
Dangerous Products - The use of disinfectants is restricted to
   
authorized personnel.
WARNING:
    Dangerous Products, change on irritate your skin - You should wear
suitable protective clothing because the disinfectants could irritate your skin. For
this purpose you should also take note of the product information of the solutions
concerned.
All parts of the chair can be treated by scrubbing with a disinfectant.
All steps taken to disinfect rehabilitation equipment, their components or other accessory
parts are to be recorded in a disinfection report containing a minimum of the following
information (with product documentation appended):
Date of the Reason
disinfection
Abbreviations used in column 2 (reason):
V = Suspected infection IF = Infection case
For a blank sheet of a disinfection book see § 9.
The recommended disinfectants for scrubbing (based on the list provided by the Robert
Koch Institute, RKI) are listed in the table below. The current state of the disinfectants
included in the RKI list can be obtained from the Robert Koch Institute (RKI) (homepage:
www.rki.de).
Specification
Table 3: Example of a disinfection book
W = Repetition I = Inspection
ƒ‰‡
Substance and Signature
concentration
Elios
2012-07