Application And Operation; Safety Precautions - Kemper autoflow Bedienungsanleitung

1. Application and operation

KEMPER autoflow ® and KEMPER freshflow
based on the principle of the overpressured air in the hood. It protects its users against dust, aerosols and
toxic gases present in the air. For the highest efficiency it is necessary to choose a correct combination of
the respiratory unit and the protecting hood. It is also important to use suitable filters.
The KEMPER autoflow
and toxic particles, solid and liquid aerosols with penetration of PS level.
The KEMPER freshflow
To reach the best efficiency it is essential to supply hygienically clean, breathable incoming air. Otherwise
the KEMPER compressed air conditioner must be used to clean it. It is able to purify pressured air from all
kinds of contamination except carbon monoxide (CO). Be aware that pressured air can contain higher
concentration of CO if the compressor does not work properly and burns lubricating oil inside while
working. If there is any doubt that the pressured air might be contaminated it is necessary to check that
there is no CO in the pressured air.
Please read this manual carefully!

2. Safety precautions

2.1 General precautions when using KEMPER respiratory systems
Follow national rules for choosing and using the right breath apparatus!
• Read and follow user manual carefully.
• Use the KEMPER respiratory system only after you have read and understood the user manual.
• Sort and concentration of particles and vapours in the working area must be known by the user.
• Do not use the KEMPER respiratory system in areas with risk of explosion.
• If the respiratory system stops working for any reason, leave the (contaminated) working area
immediately.
• Do not use the KEMPER respiratory system if the impermeability of the hood is influenced by a
beard or long hair.
• Using the respiratory system at a temperature below 10° C is not recommended.
• If there is danger of low oxygen concentration in the air, unknown vapours or unknown particle
concentration in the workspace, do not use the KEMPER autoflow
KEMPER freshflow
• Check the air-flow of the system before each use.
® are products for respiratory system protection which is
® respiratory unit meets the standards of EN 12 941 and is able to filtrate non-toxic
® respiratory unit meets the standards of EN 1835.
® respiratory system should be used.
® respiratory system. Instead the
15